Damon Intruder 2003
Model Intruder made in 2003 by Damon got 19 consumer complains as well as 6 recalls. Consumer complaints with reference, among others things, to electrical system and exterior lighting. There were some recalls concerningelectrical system and equipment.
Model 2003
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - INSTRUMENT PANEL | ||||||||||||||||
| 06V132000 | DAMON CORPORATION | from 07/01/2002 to 05/31/2004 | V (Vehicle) | 1705 | ODI | DAMON CORPORATION | 04/24/2006 | 04/24/2006 | 571 | 101 & 105 | ||||||
| Defect Summary | Certain motor homes built on workhorse chassis and equipped with actia corporate instrument clusters fail to comply with the requirements of federal motor vehicle safety standard no. 101, controls and displays and no. 105, hydraulic and electric brake systems. if the brake fail input falls below a voltage of 1.5v, the brake failure lamp and alarm will be activated. also activation of the abs telltale when the abs is not properly functioning does not always occur. | |||||||||||||||
| Consequence Summary | At night the instrument cluster lights may fail and the driver may not be able to see the instrument panel gauges and the brake warning light indicator which could increasing the risk of a crash. | |||||||||||||||
| Corrective Summary | Damon is working with workhorse to contact the owners and remedy this campaign . workhorse will reprogram the instrument panel cluster free of charge. owners may contact workhorse at 1-877-246-7731 or damon at 1-800-860-3812. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
| 03V095000 | DAMON CORPORATION | from 11/05/2002 to 01/06/2003 | V (Vehicle) | 125 | 04/07/2003 | MFR | DAMON MOTOR COACH | 03/21/2003 | 03/21/2003 | |||||||
| Defect Summary | During the winterization process on certain motor homes from november 5, 2002 through january 6, 2003, the rv antifreeze used may have been contaminated with engine antifreeze. | |||||||||||||||
| Consequence Summary | This poses a potential toxic hazard if ingested at high levels. | |||||||||||||||
| Corrective Summary | Dealers will ensure that the water system has been properly flushed. owner notification began april 7, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact damon at 1-574-264-2900. | |||||||||||||||
| Notes | Damon recall no. 03-105. customers can also contact the national highway traffic safety administration | |||||||||||||||
| 07V130000 | DAMON CORPORATION | from 04/01/1997 to 04/30/2004 | V (Vehicle) | 25128 | 06/26/2007 | MFR | DAMON CORPORATION | 03/20/2007 | 03/22/2007 | |||||||
| Defect Summary | Certain travel trailers and motor homes equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. | |||||||||||||||
| Consequence Summary | Release of coolant under certain conditions could ignite and result in a fire. | |||||||||||||||
| Corrective Summary | Damon will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or damon at 1-800-860-3812. | |||||||||||||||
| Notes | Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
| EXTERIOR LIGHTING | ||||||||||||||||
| 07V022000 | DAMON CORPORATION | V (Vehicle) | 2618 | 07/09/2007 | MFR | DAMON CORPORATION | 01/30/2007 | 01/30/2007 | 571 | 108 | ||||||
| Defect Summary | Certain motor homes fail to comply with the requirements of federal motor vehicle safety standard no. 108, lamps reflective devices, and associated equipment. these motor homes were built without the red rear reflex reflectors and some motor homes were built without the side rear red reflex reflectors. | |||||||||||||||
| Consequence Summary | During night driving conditions or while the motor home is parked, the rear and side marker lights will not provide any reflex reflection to mark the vehicle's location in the dark increasing the risk of a crash. | |||||||||||||||
| Corrective Summary | Damon will provide the owners with a kit containing the missing reflectors and instructions for applying them to their vehicle. owners may choose to have their dealers do the repair free of charge. the recall began on july 9, 2007. owners may contact damon at 1-800-860-3812. | |||||||||||||||
| Notes | Damon recall no. 06-119.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
| SERVICE BRAKES, HYDRAULIC | ||||||||||||||||
| 09V225000 | DAMON CORPORATION | from 01/01/2001 to 05/27/2009 | V (Vehicle) | 2415 | 05/01/2009 | ODI | DAMON CORPORATION | 06/16/2009 | 06/15/2009 | |||||||
| Defect Summary | Damon is recalling 2,415 motorhomes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. when combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. this can result in abnormal heat generation at the wheel end causing brake drag. | |||||||||||||||
| Consequence Summary | The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. | |||||||||||||||
| Corrective Summary | Dealers will inspect and replace the necessary components free of charge. workhorse is handling the remedy and owner notification for this campaign please see 09v-110. owners may contact workhorse at 1-877-246-7731. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE WARNING | ||||||||||||||||
| 03V080000 | DAMON CORPORATION | from 05/01/1999 to 02/28/2003 | V (Vehicle) | 2656 | 05/12/2003 | MFR | DAMON MOTOR COACH | 03/05/2003 | 03/19/2003 | 571 | 105 S5.3 | |||||
| Defect Summary | Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, hydraulic and electric brake systems. the brake system warning indicator may not function as required by standard. | |||||||||||||||
| Consequence Summary | In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the brake system warning indicator. | |||||||||||||||
| Corrective Summary | Dealers will repair the brake warning lamp circuit. owner notification is began may 12, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact damon at 1-219-272-9212. | |||||||||||||||
| Notes | Damon recall no. 03-106.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 03/18/2008 | 19000 | 1 | |
| 1. no accident occurred. 2. the lcd display in the dash goes blank. most importantly i cannot see the speed the vehicle is traveling as well as any other information such as gear the vehicle is in, oil pressure, etc. this has occurred at least three times since i have had the motor home. 3. there was a recall on the dash display which was done in 2007. all of these incidents have occurred after the recall reprogramming was done. this problem has never been remedied. *tr | |||
| EXTERIOR LIGHTING | |||
| 03/18/2008 | 19000 | 1 | |
| 1. & 2. no accident occurred. when i use the high beams for about 15 minutes they will go out for a couple of seconds then come back on. the frequency becomes shorter and the duration of outage becomes longer. eventually i have to stop using high beams since they are constantly flashing on and off. 3. i have contacted gm and damon who have each denied responsibility stating the other party is responsible. ( i have emails from each) i still have the problem as no one will take responsibility and fix the problem. *tr | |||
| FUEL SYSTEM, GASOLINE | |||
| 04/13/2012 | 20150 | ||
| This vehicle is equipped with a cummins onan generator model 5.5hgjab spec. b, with two fuel filters. the filters are apparently faulty and can separate at the seam causing fuel to leak. the upper filter can leak onto hot generator surfaces and both can leak onto the hot exhaust pipe. the upper filter on my unit is leaking and cannot be operated safely in that condition. the company is aware of the problem but have not issued a recall notice. they recommend replacement parts at the owner's expense. the problem is not confined to this one model. there are multiple references to this issue in online posts and forums. | |||
| SERVICE BRAKES, AIR | |||
| 04/10/2007 | 20206 | ||
| Tl*the contact owns a 2003 damon intruder. when the brakes were depressed, the vehicle would shake badly. the dealer stated that all four rotors were cracked. the manufacturer stated that there were not enough complaints for them to proceed with any type of assistance. the vin was verified, but appears to be inaccurate. the failure and current mileages were less than 20,206. | |||
| SERVICE BRAKES, HYDRAULIC | |||
| 11/12/2005 | 38000 | ||
| Tl-the contact owns a 2003 damon intruder. upon exiting the vehicle after a long distance drive he could smell a burning odor coming from the brakes. the failure recurred whenever he completed a long distance drive. while having the vehicle repaired for the recall associated with nhtsa campaign id number 09v110000, service brakes, hydraulic, he was informed that all of the rotors were cracked. the vehicle was repaired. the failure and current mileages were 38,000. the vin was unavailable. sm. | |||
| 04/23/2008 | 11000 | ||
| Tl*the contact owns a 2003 damon intruder 373 recreational vehicle. the contact stated the rear brakes continued to lock and exhibit smoking when engaged. the abs warning light was also illuminated on the warning panel. the dealer where there were unknown repairs made to the vehicle. after repairs, the failure persisted and the brakes felt extremely spongy. the dealer advised bleeding the brakes if the failure persisted however the contact was unfamiliar with the procedure. the manufacturer was contacted and advised taking the vehicle to an authorized dealer that could make the necessary repairs. the failure mileage was 11,000. | |||
| 06/01/2007 | 10852 | 3 | |
| Re: recall 50901-c repairs dated 11/16/07-6/15/09 i have had three repairs due to this problem. the most expensive was in 6/2007 - why is a time-frame mentioned and how can i have my problem addressed? my vin falls in the area of recall and i feel that my bills related to the recall should be paid also. five months should not make a difference if the recall is related to a vehicle. please help. *tr | |||
| 03/23/2009 | 21000 | 1 | |
| 1. no accident occurred, luckily. 2. while traveling through the houston area in stop and go traffic, the brakes suddenly turned to mush and i could not stop. luckily the vehicle in front of me moved again just as i was about to roll into them. by leaving plenty of extra space and pumping the brakes 3 or 4 times i was able to keep from rolling into the vehicle in front of me. eventually after getting out of the stop and go traffic the brakes returned to normal and i have not had this happen again although this was not the first time this occurred. roads were dry, temp was in the 90's and sunny. 3. since i do not know what caused the situation and the brakes have performed fine to date, nothing has been done to correct the problem. *tr | |||
| STEERING - WHEEL AND HANDLE BAR | |||
| 11/01/2003 | 1 | ||
| This could be a problem: while trying to see the instrument panel which is obscured by the stering wheel a crash could result. what could be done is a 18 wheel installed so we can see the speed ometer ect.*ak | |||
| TIRES | |||
| 03/07/2003 | 1 | 03/07/2003 | |
| Generator is located right outside the bedroom slide causing the co detector to go as high as 210. my son became ill. the windshield just popped out. when i contacted the dealer he said that damon knew about this problem and showed them what to do if they came across this problem, he saw this at the plant tour. why aren't the consumer aware of this problem, we weren't until it popped out on us.the tire size i feel is unsafe for this size unit. the right front folded out twice on me. they now have bigger tires on the new units but what about the ones who don't. when you drive this unit and go over a bump in the road you go so high you feel like you're coming out of your seat.i do not feel save at all in this unit.i've gone through two dealerships and the attorney generals office and i contacted damon. damon doesn't do anything but say they stand behind their product. i realized that motorhomes are not covered under the lemon law so you have people out there driving around in unsafe vehicles because manufacturers can take as many times as they want to try to fix something.i also feel very strongly that people who drive these vehicles don't have to have a special license to do so. all you need is a regular class license. also the slides don't shut properly. the dealer said they have been adjusted to the maximum but they still don't shut right also the drivers door has the same problem. damon wants to take it back to indiana but i refused as i was told they have been adjusted to the maximum. what if they open while driving? i really feel that damon needs address these problems.now there is an electrical problem. there may be a possible short somewhere. this unit has been in the shop for over 72 days for repairs that are still unresolved. *la | |||
| VISIBILITY | |||
| 07/15/2004 | 2000 | 1 | |
| Passenger side windshield separates from gasket at top right leaving a 2 opening between window opening and windshield. *tr | |||
| VISIBILITY - WINDSHIELD | |||
| 08/26/2005 | 11500 | 2 | 10/16/2002 |
| Traveling on interstate whistling noise started around windshield area inspection found windshield coming out of mounting. pushed windshield back for duration of trip. windshield is a major safety hazard. this coach only has 12.000 miles on it. the windshield continues to pop out. *nm | |||
| 10/03/2004 | |||
| While driving down the road the window came out of the seal causing a 2 opening in the upper right corner. when a window installer was hired to re-install the window he informed me that the opening was cut too large for the windshield. the installer also noted that the factory doctored the window seal/opening to attempt to secure it. several attempts to contact the manufacturer (damon) have been unsuccessful. repair consisted of having a body shop remove the windshield and build up the opening in order to get proper structural support. this work could have been performed by the manf. with little delay and effort to the manufacturing schedule. a search of other rv sites have identified several other cases of this issue with damon motor homes. if you are reading this complaint and this issue has occurred to you please take the time to complete a complaint report. | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| MA | WEST BOYLSTON | 01583 | FLAGG RV | 1-800-678-9278 |
| NY | HAMBURG | 14075 | MEYERS RV |