Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| CSN-J-21 | 11/01/2009 | 10032634 | Chrysler/dodge: hot start engine cranking. the battery ground cables on the vehicles may cause slow engine cranking during hot engine starting conditions. *pe | 04/21/2010 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
| SB-J19 | 08/01/2009 | 10032766 | Chrysler/jeep/dodge: california emissions warranty addendum. the warranty book on certain vehicles may contain errors or may be missing information regarding the coponents covered by the california emissions warranty. dodge-caravan/grand | 05/19/2010 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
| 18-005-11 | 02/05/2011 | 10037970 | Ready | 06/08/2011 | |
| 18-005-11 | 02/05/2011 | 10037970 | Chrysler: malfunction light is on with a stored trouble code. *rm | 06/08/2011 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE | |||
| 08/09/2012 | 33358 | 3 | |
| There seems to be issues with the 5.7 ltr dodge engines failing at highway speeds. my first occurrence was sept. 8th, 2011 with 33,358 miles on engine, my second occurrence was on feb 01, 20122 with 43,872 and my third occurrence was aug 9, 2012 with 59,600 miles. timing chains failure on all occurrences and this is happening to more and more 2009-2010 dodge challengers with automatic transmissions. my concern is that these occurrences are happening at highway speeds greater then 65 mph and eventually will cause serious harm and or death when car shuts down in the middle of rush hour traffic on interstates. this will be my third new engine total of four that will be put in this car with no upgraded parts to prevent these failures. all they keep doing is putting them back together with the same parts that are failing. something needs to be done to correct these problems before some one gets seriously hurt or killed! i can provide more info on a number of challenger that are having these same failures if you request it. *tr | |||
| 08/09/2012 | 33358 | ||
| There seems to be issues with the 5.7 ltr dodge engines failing at highway speeds. my first occurance was sept. 8th, 2011 with 33358 miles on engine, my second occurance was on feb 01, 20122 with 43,872 and my third occurance was aug 9, 2012 with 59600 miles. timing chains failure on all occurances and this is happening to more and more 2009-2010 dodge challengers with automatic transmissions. my concern is that these occurances are happening at highway speeds greater then 65 mph and eventually will cause serious harm and or death when car shuts down in the middle of rush hour traffic on interstates. this will be my third new engine total of four that will be put in this car with no upgraded parts to prevent these failures. all they keep doing is putiing them back together with the same parts that are failing. something needs to be done to correct these problems before some one gets seriously hurt or killed! i can provide more info on a number of challenger that are having these same failures if you request it. | |||
| 07/27/2011 | 16630 | 2 | |
| My 2009 challenger has stalled twice when making a right-hand turn. 4/11/11 - i was driving between 30-35 mph. i started braking so i could turn right into my office parking lot. as i started to turn right, the engine just turned off - there were no idiot lights on the dash. i restarted the car, but i could not get it to move - drive would not work - reverse would not work - still no idiot lights on the dash. i turned the car off and restarted it again - and was able to drive the car. 7/27/11 - same right-hand turn - i was driving between 30-35 mph. i started breaking so i could turn right into my office parking lot. as i started to turn right, the engine just turned off - there were no idiot lights on the dash. i restarted the car and was able to drive the car with no problems. gas gauge showed a little above one-quarter. there were 16,630 miles on car on 7/27/11. my husband's 2010 challenger with low mileage, has stalled twice - most recently on 7/25/12. *tr | |||
| 07/27/2011 | 16630 | ||
| My 2009 challenger has stalled twice when making a right-hand turn. 4/11/11 - i was driving between 30-35 mph. i started braking so i could turn right into my office parking lot. as i started to turn right, the engine just turned off - there were no idiot lights on the dash. i restarted the car, but i could not get it to move - drive would not work - reverse would not work - still no idiot lights on the dash. i turned the car off and restarted it again - and was able to drive the car. 7/27/11 - same right-hand turn - i was driving between 30-35 mph. i started breaking so i could turn right into my office parking lot. as i started to turn right, the engine just turned off - there were no idiot lights on the dash. i restarted the car and was able to drive the car with no problems. gas gauge showed a little above one-quarter. there were 16,630 miles on car on 7/27/11. my husband's 2010 challenger with low mileage, has stalled twice - most recently on 7/25/12. | |||
| 07/02/2012 | 50000 | 1 | |
| Car suddenly dies/stalls - warning lights come on (various speeds from 20 to 70 mph) most often associated with a small bump in the road restarts easily, but occasionally with difficulty has happened many times (50+) have been to dealer 4 times in the last several months - reprogrammed once, but problem persists and the dealer says cannot duplicate - this is a dangerous loss of control and power. *tr | |||
| 07/02/2012 | 50000 | ||
| Car suddenly dies/stalls - warning lights come on (various speeds from 20 to 70 mph) most often associated with a small bump in the road restarts easily, but occasionally with difficulty has happened many times (50+) have been to dealer 4 times in the last several months - reprogrammed once, but problem persists and the dealer says cannot duplicate - this is a dangerous loss of control and power | |||
| ENGINE AND ENGINE COOLING | |||
| 10/14/2011 | 15481 | ||
| Overview: my 2009 dodge challenger r/t, with the 5.7l hemi engine and manual 6-speed transmission, has an excessive delay between pressing the throttle and achieving engine response. this occurs only in gears 4-6, and is the result of a powertrain control module (pcm) update. background: this vehicle has an electronic throttle (drive by wire) system, where throttle response is controlled by the pcm and not via a throttle cable. history: on october 14, 2011, i brought my vehicle to my local dodge/chrysler dealership due to a rough engine idle. they informed me that a pcm update was available, based on technical service bulletin (tsb) 18-014-10. this update changed the engine calibration id from 05187899ae to 05187899ag. ever since this update was performed, the vehicle has a significant (and unsafe) throttle delay while in gears 4-6. basically, when the throttle is depressed, it takes about 2 seconds for the engine to respond. this has resulted in several near-collisions, during times where acceleration is expected to avoid an unsafe road condition but the vehicle fails to respond in a timely manner. to demonstrate the problem, you could actually rapidly pulse the throttle repeatedly without having any engine response at all. this issue affects all owners of 2009-2010 dodge challenger r/ts with the 05187899ag calibration id. as of this date, no pcm update has been released to correct this unsafe condition. | |||
| 05/20/2011 | 28000 | ||
| Took my car into dealership for warranty work on trim and window switch. car was fine. had owned it for 2.5 years. dealer performed flash on pcm per chrylsers information. when i left the dealer, i noteced a 1.5 second delay when gas pedel is depressed. found out when trying to pass slower traffic. human nature causes you to press if more. then all of the sudden, the power comes on hard. took it back, and had chryler tech test drive with service mgr. they saw the problem with the scan tool hooked up. was told that there was a 1.4 second delay. tech said he made changes in program and took it to .7 seconds. i do not see a differance in performance. called contact at chrysler. and was told that it falls within factory standards. there is no way this is right. car was fine untill they flashed it. i am unable to get any paperwork from chrysler stating the problem is normal. this is very dangerous. at 55 or 70mph 1.4 seconds can be a lifetime. if a time delay is normal for the fly by wire systems, then i am glad i am not a pilot of a fighter aircraft or new comercal air liner. | |||
| 02/07/2011 | 12000 | ||
| Vehicle has a severe throttle lad when in 4 to 6 gear when letting off pedal then returning back into throttle | |||
| 05/20/2011 | 28000 | ||
| Took my car into dealership for warranty work on trim and window switch. car was fine. had owned it for 2.5 years. dealer performed flash on pcm per chrylsers information. when i left the dealer, i noteced a 1.5 second delay when gas pedel is depressed. found out when trying to pass slower traffic. human nature causes you to press if more. then all of the sudden, the power comes on hard. took it back, and had chryler tech test drive with service mgr. they saw the problem with the scan tool hooked up. was told that there was a 1.4 second delay. tech said he made changes in program and took it to .7 seconds. i do not see a differance in performance. called contact at chrysler. and was told that it falls within factory standards. there is no way this is right. car was fine untill they flashed it. i am unable to get any paperwork from chrysler stating the problem is normal. this is very dangerous. at 55 or 70mph 1.4 seconds can be a lifetime. if a time delay is normal for the fly by wire systems, then i am glad i am not a pilot of a fighter aircraft or new comercal air liner. | |||
| 02/07/2011 | 12000 | ||
| Vehicle has a severe throttle lad when in 4 to 6 gear when letting off pedal then returning back into throttle | |||
| 05/20/2011 | 28000 | ||
| Took my car into dealership for warranty work on trim and window switch. car was fine. had owned it for 2.5 years. dealer performed flash on pcm per chrylsers information. when i left the dealer, i noteced a 1.5 second delay when gas pedel is depressed. found out when trying to pass slower traffic. human nature causes you to press if more. then all of the sudden, the power comes on hard. took it back, and had chryler tech test drive with service mgr. they saw the problem with the scan tool hooked up. was told that there was a 1.4 second delay. tech said he made changes in program and took it to .7 seconds. i do not see a differance in performance. called contact at chrysler. and was told that it falls within factory standards. there is no way this is right. car was fine untill they flashed it. i am unable to get any paperwork from chrysler stating the problem is normal. this is very dangerous. at 55 or 70mph 1.4 seconds can be a lifetime. if a time delay is normal for the fly by wire systems, then i am glad i am not a pilot of a fighter aircraft or new comercal air liner. | |||
| 02/07/2011 | 12000 | ||
| Vehicle has a severe throttle lad when in 4 to 6 gear when letting off pedal then returning back into throttle | |||
| 05/20/2011 | 28000 | ||
| Took my car into dealership for warranty work on trim and window switch. car was fine. had owned it for 2.5 years. dealer performed flash on pcm per chrylsers information. when i left the dealer, i noteced a 1.5 second delay when gas pedel is depressed. found out when trying to pass slower traffic. human nature causes you to press if more. then all of the sudden, the power comes on hard. took it back, and had chryler tech test drive with service mgr. they saw the problem with the scan tool hooked up. was told that there was a 1.4 second delay. tech said he made changes in program and took it to .7 seconds. i do not see a differance in performance. called contact at chrysler. and was told that it falls within factory standards. there is no way this is right. car was fine untill they flashed it. i am unable to get any paperwork from chrysler stating the problem is normal. this is very dangerous. at 55 or 70mph 1.4 seconds can be a lifetime. if a time delay is normal for the fly by wire systems, then i am glad i am not a pilot of a fighter aircraft or new comercal air liner. | |||
| 02/07/2011 | 12000 | ||
| Vehicle has a severe throttle lad when in 4 to 6 gear when letting off pedal then returning back into throttle | |||
| 05/20/2011 | 28000 | ||
| Took my car into dealership for warranty work on trim and window switch. car was fine. had owned it for 2.5 years. dealer performed flash on pcm per chrylsers information. when i left the dealer, i noteced a 1.5 second delay when gas pedel is depressed. found out when trying to pass slower traffic. human nature causes you to press if more. then all of the sudden, the power comes on hard. took it back, and had chryler tech test drive with service mgr. they saw the problem with the scan tool hooked up. was told that there was a 1.4 second delay. tech said he made changes in program and took it to .7 seconds. i do not see a differance in performance. called contact at chrysler. and was told that it falls within factory standards. there is no way this is right. car was fine untill they flashed it. i am unable to get any paperwork from chrysler stating the problem is normal. this is very dangerous. at 55 or 70mph 1.4 seconds can be a lifetime. if a time delay is normal for the fly by wire systems, then i am glad i am not a pilot of a fighter aircraft or new comercal air liner. | |||
| 02/07/2011 | 12000 | ||
| Vehicle has a severe throttle lad when in 4 to 6 gear when letting off pedal then returning back into throttle | |||
| 07/11/2011 | 5605 | ||
| Car periodically stalls when coming to a stop. dealer does not know the cause- may be computer-related. friends having the same dodge vehicle have had their car stall in heavy high speed traffic. this could cause a serious or fatal crash. | |||
| 02/26/2011 | 15539 | ||
| The dealership flashed the pcm as detailed in service bulletin 18-021-09 rev. a. immediately after that i noticed an intermittent throttle lag. when pressing the gas pedal, the car will wait 1/2 to 3/4 second, then the engine will respond and the car will go. merging into highway traffic is now dangerous as the car will not always respond to the pedal input. when it finally does respond the car will surge forward (since i'm pushing down more on the pedal trying to get the car to move). this is dangerous as the rear tires can lose traction on wet roads. the dealership hooked up a portable data logger and road tested the vehicle. they were able to verify the complaint. they sent the results to chrysler's engineers. those engineers reviewed the data and said, the vehicle is operating as designed, delay is normal, we see nothing wrong. i had the car for 22 months prior to this update and never had the problem before. | |||
| 09/07/2010 | 31706 | ||
| Tl-the contact owns a 2009 dodge challenger. while approaching a stop sign driving 25 mph the vehicle stalled. the contact stated all the lights of the dashboard flashed. the contact placed the vehicle in park and the vehicle restarted as normal. the vehicle was taken to an authorized dealer and the dealer was unable to duplicate the failure. the contact continued to experience the failure and the vehicle was taken to another authorized dealer. this dealer also was unable to locate the failure but noticed that there was a kill switch on the vehicle. the vehicle was taken to a third dealer and this dealer removed the anti theft device installed by another dealer on the vehicle. the contact was still experiencing the failure. the vehicle has not been repaired. the failure mileage was 31,706 and the current mileage was approximately 33,000. vwb | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 07/22/2011 | 23114 | ||
| While driving home from work coming to the turn and slowing down the car literally just died while oncoming traffic was coming down the road. all lights came on and car was dead. put in park and restarted with no cel. dealership has no idea why its doing this. | |||
| 07/12/2011 | 23012 | ||
| 2009 dodge challenger rt auto, while driving along at highway speed the car literally just died, no rime or reason. pulled off the highway and restarted the car, check engine light came on, went to boerne dodge and they couldn't figure out the problem. said the light just went away. and if it happens again to bring it back. | |||
| 07/22/2011 | 23114 | ||
| While driving home from work coming to the turn and slowing down the car literally just died while oncoming traffic was coming down the road. all lights came on and car was dead. put in park and restarted with no cel. dealership has no idea why its doing this. | |||
| 07/12/2011 | 23012 | ||
| 2009 dodge challenger rt auto, while driving along at highway speed the car literally just died, no rime or reason. pulled off the highway and restarted the car, check engine light came on, went to boerne dodge and they couldn't figure out the problem. said the light just went away. and if it happens again to bring it back. | |||
| 07/22/2011 | 23114 | ||
| While driving home from work coming to the turn and slowing down the car literally just died while oncoming traffic was coming down the road. all lights came on and car was dead. put in park and restarted with no cel. dealership has no idea why its doing this. | |||
| 07/12/2011 | 23012 | ||
| 2009 dodge challenger rt auto, while driving along at highway speed the car literally just died, no rime or reason. pulled off the highway and restarted the car, check engine light came on, went to boerne dodge and they couldn't figure out the problem. said the light just went away. and if it happens again to bring it back. | |||
| 07/22/2011 | 23114 | ||
| While driving home from work coming to the turn and slowing down the car literally just died while oncoming traffic was coming down the road. all lights came on and car was dead. put in park and restarted with no cel. dealership has no idea why its doing this. | |||
| 07/12/2011 | 23012 | ||
| 2009 dodge challenger rt auto, while driving along at highway speed the car literally just died, no rime or reason. pulled off the highway and restarted the car, check engine light came on, went to boerne dodge and they couldn't figure out the problem. said the light just went away. and if it happens again to bring it back. | |||
| 07/22/2011 | 23114 | ||
| While driving home from work coming to the turn and slowing down the car literally just died while oncoming traffic was coming down the road. all lights came on and car was dead. put in park and restarted with no cel. dealership has no idea why its doing this. | |||
| 07/12/2011 | 23012 | ||
| 2009 dodge challenger rt auto, while driving along at highway speed the car literally just died, no rime or reason. pulled off the highway and restarted the car, check engine light came on, went to boerne dodge and they couldn't figure out the problem. said the light just went away. and if it happens again to bring it back. | |||
| 10/12/2009 | 7000 | ||
| Tl- the contact owns a 2009 dodge challenger . the contact stated that while driving 75 mph the vehicle stalled and was able to pull it over to the side of the ride. the vehicle was then turned back on and the drove it to his local dealer. the dealer diagnosed it stating that there were no codes and could not duplicate the problem. the has occurred one additional time. the vehicle was not repaired. the failure mileage was 7000 and the current mileage was 14600.cv | |||
| 08/11/2010 | 26586 | ||
| Issue # 1) i have an automatic transmission 2009 dodge challenger rt. so i was driving under normal conditions accelerating normally and the engine coughs...strange. then it does it again, a very sudden cough like it is struggling for air, the vehicle almost shudders too. engine code pops up. head to auto zone and have it checked - p0730 gear ratio incorrect. this has happen a few time within the past few weeks . to car to the dealership- they saw the same code . becasue the car was drving normal again they did nothing . pling to take it back in so they can pulll the trans. iusse # 2) today 8/11/10 - i was driving on the express way with an over a 1/2 tank of gas, doing about 60 to 70 mph. about 30 min into my drive, suddenly all my dashboard light/symbols pop on and my car lost all power. to avoid get rear ended i had to pull over on the side of the road. | |||
| 01/26/2009 | 1000 | 1 | |
| 2009 dodge challenger r/t loses power while under load such as going up hills or passing; and the rpm pulsates. this condition appears to occur more in hot weather. upon deceleration, transmission shifts so roughly that vehicle lost traction in slippery road conditions, and nearly resulted in a crash. these appear to be two separate conditions that make the vehicle extremely unsafe. *tr | |||