Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||||
050399 | 04/23/1999 | 604710 | Information regarding front brake caliper mounting to steering knuckle thread repair. *tt | 05/10/1999 | |
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||||
050395 | 03/01/1995 | 39987 | Slight front brake lead/drift. *tw | 11/01/1995 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SERVICE BRAKES, AIR - ANTILOCK | |||
12/04/1998 | 12/01/1997 | ||
Driver tried to apply brakes, they failed then driver applied emergency brake, skidded into another vehicle hitting windshield due to airbag not deploying causing injury. | |||
SERVICE BRAKES, AIR - ANTILOCK - INTERCONNECTING ASSEMBLY(WIRING) | |||
11/13/1997 | 1 | 07/01/1996 | |
While traveling down the road at night, all lighting systems went out with no warning. the headlights, tail lights, and side marker lights went out. *ak consumer states the tachometer stopped working and the gas mileage dropped from 24.5 mpg to 18 mpg after he fabricated repair parts, the cause of failure was due to a wiring harness plug connector not being sufficiently waterproofed, water, road salts, and minerals collected at the wiring side of the connector and caused three electrical spades in the connector to short out, burning one spade out completely, consumer had not heard back regarding the shipment of the wiring harness, however was told it would only take approximately 7 days. *slc | |||
SERVICE BRAKES, HYDRAULIC | |||
11/15/2002 | 90000 | ||
This is just a run down on repairs i made to my vehicle, but they are problems that should have been taken care of at the factory. first of all, the brake problem still exists. this is the only vehicle that i know of that has to have air in the front caliphers to work. i had to put bearings in both front and rear differential assemblies. the front one came from the factory without a bearing in the left side of the differential assembly. | |||
SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
07/15/1999 | |||
Got a new battery for the vehicle and started the vehicle. noticed the abs light come on. took it to dealer, and they indicated that the abs module and pressure limit valve needed to be replaced. this has happened two times. the other time the abs light came on, took it to the dealer and was told that the wiring harness was pinched between the speed sensor and frame. *ak | |||
08/01/1999 | |||
The abs circuit board and rear abs sensor and harness malfunctioned, causing the abs system to be inoperative, and resulted in extended stopping distance which could result in a crash. *ak | |||
When attempting to slow/stop to avoid hitting a deer, experienced abs failure, upon appying, brakes, they grabbed and did not release right away, causing wheels to lock up, skidded and then vehicle rolled over. *ak | |||
09/09/1996 | 2 | 11/05/1994 | |
During impact driver's side air bag did not deploy and when applying abs brakes, the brakes locked up.*ak | |||
01/16/1996 | |||
The front wheels lock up while braking, vehicle is equipped with rear abs brakes. tt | |||
12/29/1995 | |||
Abs brake system failure, vehicle surges on its own. tt | |||
06/26/1995 | |||
Driver's side abs system failure, total loss of brakes. tt | |||
08/22/1995 | |||
The truck has abs system when you apply the brakes the vehicle veers to left or right into the next lane. please describe. tt | |||
06/08/1995 | 4 | ||
The rear brakes have been corrected four times and they are grinding. they are abs brakes. *ak | |||
SERVICE BRAKES, HYDRAULIC - ANTILOCK - CONTROL UNIT/MODULE | |||
07/01/1995 | 1 | ||
Anti lock brake sensor failed, causing accident. *tt | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
1 | |||
The entire braking system except for the brake cables had to be replaced in july. two weeks after the vehicle had been sitting for about four hours, the emergency brake cable caught on fire and burned from the handle down about 12 inches, which made the battery fail. consuemr called sears, who did the brake job, and they are not taking responsibility for the cable fire. there was brake fluid leaking onto consumers driveway and the vehicle was put back in the shop for replacement of all the brake cables. *jg | |||
03/12/1996 | |||
While driving his brakes went out. *ak | |||
11/23/1994 | 3 | ||
Right rear brakes failed. | |||
04/05/1996 | |||
Driver experienced total brake pedal, excessive brake pedal travel. *ak | |||
11/25/1995 | 5 | ||
Brakes failed, causing accident. *sd | |||
12/13/1994 | |||
While at stops and foot on the brakes vehicle surge forward almost hitting people passing. tt | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||
06/02/2002 | |||
When applying brakes there is squeaking and jerking. took vehicle to dealer and they stated rotors/ disc, and calipers need replacing. please provide any further information.*ak | |||
While driving experienced intermittent front brake failure, when braking front brakes pull to extream right, also right front brakes lock up.*ak | |||
01/16/1996 | |||
The front wheels lock up while braking, vehicle is equipped with rear abs brakes. tt | |||
12/29/1995 | |||
The truck has rear abs brakes. the front brakes lock up and the pedal goes to the floor when applied. please describe. tt | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||
05/01/1996 | 2 | 01/01/1996 | |
Piston in caliper is made of a phonalic material and freezes up after getting hot, causing the disc brakes to stick and destroy the brake pads and rotors. | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||
03/22/2001 | 1 | ||
Consumer having problems with warped rotors, consumer was advised there was a recall, but when he called manufacturer he was advised there was no recall on rotors. *jb | |||
1 | 09/28/1995 | ||
Brake rotors are grooved and out of round. | |||
05/28/1997 | 2 | 02/07/1995 | |
Front rotors warped, causing vibration. | |||
06/17/1996 | 1 | 05/12/1995 | |
Brake rotors replaced. | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - MASTER CYLINDER | |||
02/15/1996 | 1 | 05/01/1995 | |
Master cylinder leak. |