Dodge Grand Caravan 1996 - Fuel system - car safety information, failing parts, recalls, bulletins, complaints

Dodge Grand Caravan 1996

Recalls
Defect investigations
Consumer Complaints

Recalls

Campaign	Manufacturer	Manufacturing date	Type	# of units affected	Date Owner notified Mfg	Recall Initiated by	Manufacturers of recalled vehicles/products	Report Recieved Date	Record Creation Date
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP
99V216000	DAIMLERCHRYSLER CORPORATION	from 01/01/1995 to 07/31/1996	V (Vehicle)	635469	01/09/2000	ODI	CHRYSLER GROUP LLC	08/09/1999	08/17/1999
Defect Summary	Vehicle description: minivans. fuel can leak from the fuel tank at the interface of the fuel pump module attachment.
Consequence Summary	If a fuel leak occurs in the presence of an ignition source, a fire could occur.
Corrective Summary	Dealers will replace the fuel pump module attaching nut with a nut that includes tighter design tolerances. the sealing o-ring will also be replaced.
Notes	Owner notification began january 9, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-992-1997. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS
95V236000	CHRYSLER CORPORATION	from 01/01/1995 to 08/01/1995	V (Vehicle)	80000	01/02/1996	ODI	CHRYSLER GROUP LLC	12/08/1995	01/02/1996
Defect Summary	The fuel tank rollover valve can allow fuel to pass into the vapor canister resulting in the potential for fuel leakage.
Consequence Summary	Fuel leakage increases the potential for a vehicle fire.
Corrective Summary	Dealers will replace the fuel tank filler tube with a filler tube that has an additional rollover valve. the associated rollover valve vapor hoses will be rerouted.
Notes	System: fuel; vehicle crash; cut off system.vehicle description: passenger mini-vans.note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-853-1403. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM
00V268000	DAIMLERCHRYSLER CORPORATION	from 02/15/1995 to 09/05/1999	V (Vehicle)	1163000	01/25/2002	ODI	CHRYSLER GROUP LLC	09/13/2000	09/14/2000
Defect Summary	Vehicle description: mini vans built with 3.3l and 3.8l engines have fuel rails with nitrole rubber o-ring seals that can degrade over time. fuel leakage from the underhood fuel injection fuel rail could result, increasing the likelihood of a vehicle fire.
Consequence Summary	Fuel leakage in the presence of an ignition source can result in a fire.
Corrective Summary	Dealers will install a seal on the vehicle fuel rails to prevent external leakage of fuel from the fuel rail crossover tube, should the existing o-rings continue to degrade. owner notification began on january 25, 2002. due to the large quantity of vehicles involved in this campaign, the owner notification will be phased over the next several months. however, if a vehicle is leaking fuel from the o-rings, the vehicle should be taken into a dealer to have this repaired as soon as possible. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
Notes	Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP
96V002000	CHRYSLER CORPORATION	from 01/01/1995 to 12/01/1995	V (Vehicle)	265000	02/16/1996	MFR	CHRYSLER GROUP LLC	01/16/1996	01/22/1996
Defect Summary	A static electric charge can build up on the ungrounded metal section of the fuel filler tube.
Consequence Summary	This condition could cause a spark to occur when fueling the vehicle and possibly ignite the fuel vapors.
Corrective Summary	Dealers will install a ground strap for the fuel filler tube.
Notes	System: fuel; fuel tank assembly; pipe; filler; neck.vehicle description: passenger mini-vans. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact chrysler at 1-800-853-1403.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.

Investigations

NHTSA ID	Manufacturer	Date open	Date close	Subject
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP
PE99010	CHRYSLER GROUP LLC	02/03/1999	06/11/1999	POST-COLLISION FUEL SYSTEM INTEGRITY
	The filler tube hose may separate from the fuel tank certain crash modes.

Consumer Complaints

Fail date	miles	occurences	Purchase date
FUEL SYSTEM, GASOLINE
06/15/2003	48650
	A/c internal fan switch fails in at least two positions and have had smoke enter inside the van while driving, from i think the fan. once the fan is turned off the smoke goes away.
		3	02/01/2002
	The consumer experienced a strong smell of raw fuel inside the vehicle and the garage possibly caused by a faulty fuel tank. *yh
02/24/2000		1
	While driving, consumer smelled gas, had received recall regarding fuel pump and made an appointment with the dealership after smelling the gas, vehicle experienced fire, claim 20-5211-880. *slc
02/24/2000		1
	Consumer took children to school and could smell gas, consumer had received a recall regarding the fuel pump, however after speaking with the dealer he did not believe this problem had to do with the recall, after package, vehicle went into house, neighbor called her and stated her vehicle was on fire and was totaled, claim 20-5211-880. *slc
12/30/2000
	There is a very strong fuel smell coming into cab of vehicle. consumer is afraid that a fire may start. please provide any further information.*ak
04/23/2002		1	09/01/2000
	The consumer states taking the vehicle in for the fuel leak recall(nhtsa id#00-v-268-000 manufacturer recall id# 895). the vehicle had a leak at the top seam of the fuel tank. the consumer states each time the tank was filled the smell of gas lingered for at least two days. the problem did not start until the recall was performed. the dealer was notified. *jg
02/24/2000		1
	Consumer took children to school and could smell gas, consumer had received a recall regarding the fuel pump, however after speaking with the dealer he did not believe this problem had to do with the recall, after package, vehicle went into house, neighbor called her and stated her vehicle was on fire and was totaled, claim 20-5211-880. *slc
02/24/2000		1
	While driving, consumer smelled gas, had received recall regarding fuel pump and made an appointment with the dealership after smelling the gas, vehicle experienced fire, claim 20-5211-880. *slc
09/09/2001		1	04/01/1999
	Fuel rail was leaking gasoline into engine. consumer felt that vehicle should be included in recall #00v268000 for fuel leakage. dealer has been contacted. ak tt
11/09/2000
	Vehicle experiencing fuel fumes/order leakages coming into the vehicle while driving. vehicle inspected by independent repair shop and unable to locate cause. manufacturer notified, and informed consumer that nothing can be done until consumer received a recall. seeking help from nhtsa on this matter. please feel free to provide any further details. *ak
			08/15/1995
	Fuel system and steering problems.
11/27/1996		1	11/01/1995
	Fuel odor.
FUEL SYSTEM, GASOLINE - DELIVERY
			11/01/2096
	Fuel leaking, dealer says at drain tube/tank interface - new tank assembly required with tubes, not covered under warrenty/recalls. cost to fix $815.00. *ak
03/04/2002
	Fuel rail line is leaking fluid, and could cause a fire. *ak
10/19/2000		1
	While driving, vehicle stalled, consumer exited vehicle to find vehicle on fire, fire seemed to come from the underside of the vehicle and not the engine area, due to the fuel line rubbing against the right frame rail, there was a hole in the fuel line, claim 16-n141-453. *slc
10/30/2000		1
	Consumer was dropping off niece and noticed smoke coming from under the hood, consumer lifted up the hood and thought it was okay, after driving past 4-5 houses, consumer saw orange and stopped, vehicle was on fire, consumer had heard that there was a recall on the fuel line, claim 49-3238-941. *slc
10/19/2000		1
	While driving, vehicle stalled, consumer got out of the vehicle to find it on fire, fire seemed to come from the underside and not the engine area, due to the fuel line rubbing against the right frame rail, this caused a hole in the fuel line, thus causing the fire, claim 16-n141-453. *slc
10/30/2000		1
	Consumer was dropping off niece and noticed smoke coming from under the hood, consumer lifted up the hood and thought it was okay, after driving past 4-5 houses, consumer saw orange and stopped, vehicle was on fire, consumer had heard that there was a recall on the fuel line, claim 49-3238-941. *slc
10/19/2000		1
	While driving, vehicle stalled, consumer got out of the vehicle to find it on fire, fire seemed to come from the underside and not the engine area, due to the fuel line rubbing against the right frame rail, this caused a hole in the fuel line, thus causing the fire, claim 16-n141-453. *slc
10/19/2000		1
	While driving, vehicle stalled, consumer exited vehicle to find vehicle on fire, fire seemed to come from the underside of the vehicle and not the engine area, due to the fuel line rubbing against the right frame rail, there was a hole in the fuel line, claim 16-n141-453. *slc
			08/01/1996
	No summary listed for abov evehicle. *ak
10/01/2001
	A repair shop diagnosed problem as a fuel leak originating from fuel rail. consumer contacted dodge dealership, and was informed that this vehicle was not affected by any recalls. please provide any additional information / attachments.*ak
10/19/1999		1	10/24/1996
	Primary fuel line is leaking. yh
11/11/1996		3	06/01/1996
	The fuel pump problem was diagnosed on 11-27-96, however, the van had been towed into dodge dealerships on two prior occassions, beginning 11-11-96. initially no problem could be found. the van had died while driving on the interstate. about two weeks later, the van died again in city traffic. spark plug wires were replaced. the next day the van died again in city traffic. ultimately, the fuel pump and filter were replaced. each time the van needed towing to the nearest dealership. on 10-14-99, the van made a popping noise while being driven at 40 mph on a country road. i stopped the van and discovered transmission fuid leaking from under the engine. i called a tow truck and had it taken to the dealership. there had been no warning prior to the pop and subsequent leakage. the dealer reported that the transmission needed replacing. there were no obstacles on the road that may have resulted in the problem.
10/10/1998		1	07/01/1995
	Fuel tank dripped gas when filled to top. tired of taking car to dealer and out of warranty anyway, i ran tank empty, dropped tank and found loose hose fitting in top of tank. fitting was loose. cleaned it up and used sealant and reinstalled. concerned about the flimsy way fitting was fastened to plastic tank. you could just yank it out without much effort. *ak
09/22/1998			03/01/1998
	Air conditioning-dealer replaced compresser,condensor and evaporator, we purchased van in march and a/c never worked when the weather warmed up. fuel pump failed and had to be replaced at a cost of $450. tires went next at a cost of $350 for two front tires. transmission is slipping and won't shift consistantly. will cost $1500-$1800 to replace on a two year old van with 45000 miles.( dot number: m30d tire size: 21565r16 )
02/22/1996		1	10/12/1995
	Fuel pump did not fit properly, causing leakage.
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP
01/01/1901		1
	1996 dodge grand caravan with leaking fuel tank. consumer states that she did a search on the internet for recalls and found several for her vehicle. she states that she never received any paperwork from the manufacturer about the recalls. *kb
12/20/2003		2
	While the vehicle was parked, fluid was leaking from underneath the vehicle. the consumer took the vehicle to the dealer for inspection, and the mechanic determined that the fuel pump needed to be replaced, and replaced it. however, the problem recurred. ak the time belt cover was a problem. sc
10/01/2002	84000	2	09/01/2001
	The meter read less than half a tank of gas, the van ran out of gas, then the engine stalled. the consumer started the vehicle and began to drive when soon after the check engine light illuminated. the consumer was told the problem was a misfired cylinder, the fuel fuel pump was buried inside the gas tank, and when the fuel level dropped below the fuel pump, the pump heated up and sucked in air instead of the gasoline. scc jb
10/11/2001		1	04/01/1996
	The original fuel pump failed. replacement oem pump leaked gas out of defective seal when tank was filled, resulting in a significant gas spill and fire hazard. dealed explained that when pump is replaced they do not check for tank seal integrity. replacement pump replaced at no additonal charge. *ak
04/06/2001		1
	Fuel is leaking between interface sensor module subject to recall 99v21600/ manufacturer's recall 845. both independent chrysler and service representatives claimed fuel tank was warped in the area which was leaking fuel. some responsability should be on chrysler. problem doesn't seem like normal wear and tear. this is a great deal of safety concern to consumer.ak consumer states root is the cause of leaking fuel, distortion of molded plastic fuel tank indicates improper manufacturer design. jb

	Consumer told by dealer that recall 99v-216 of the fuel pump module seal does not apply to his particular style of minivan, handicapped conversion created different fuel tank setup. nlm
		1	09/01/1999
	Nhtsa recall 99v216000 and manufacturer's recall 845/ fuel pump. it was repaired on 8 june, 2000 and still is having the same problem. engine warning light comes on.consumer should be able to get 16-17 gallons in gas tank, instead, it only takes 10 gallons. *ak
05/31/2000		2
	Consumer received manufacturer's recall 7567/ fuel pump. vehicle was leaking gasoline, and consumer smelled gasoline inside and outside of garage. smell is still there. dealership replaced it twice. ak ml

	Recall 99v216000 daimlerchrysler/fuel pump; after having rcall work peformed engine check light came on. owner did not have any problems with engine check light until recall work was performed. engine check light came on the day after recall repairs were performed. dealer stated that the problem was not a part of recall, and would not be serviced free. *ak

	Nhtsa recall 99v216000 and manufacturer's recall 845. no parts were available. *ak
09/01/1999		1
	Fuel leaked at the interface of the fuel pump prior to recall notice 99v-216. nlm
		1	09/01/1995
	The fuel pump module failed prior to recall notification. (99v-216) *mjs
03/30/2000
	Recall 99v216/fuel pump. dealer will not repair the vehicle. *ak
		1
	Fuel pump failed prior to recall (99v-216). yh
03/17/2000		2
	Received recall notice & contacted dealership. took vehicle for repairs, but fuel still leaked out. contacted dealer & was informed o rings were not part of recall repair kit sent out, the repair remedy for fuel pump failed. vehicle sent back to dealer 2 more times, problem still uncorrected. *ak

	Recall 99v216000/ fuel pump. fuel is leaking from the fuel tank at the interface of the fuel pump module attachments. remedy did not correct recall problem. please give any further details. *ak

	Recall # 99v216000//fuel pump; after having recall campaign, fuel started leaking. dealer stated that they were not familar with a new tool to correct campaign, which caused the problem. finally, dealer has corrected the problem.
02/24/2000			08/01/1996
	Consumer received recall letter 99v216/fuel pump failure. contacted dealer. was notified that parts were not available. ak ml
02/18/2000		1
	Transmission malfunctioned. then,consumer took vehicle to a technician who stated that there was a transmission fluid leakage, and transmission needed to be replaced. currently, consumer received a recall on fuel pump. ak ml

	Consumer received recall letter 99v216000 concerning the fuel pump failure. contacted dealr, no parts were available to correct the recall prob please give any further details. *ak
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS
04/12/2006	130000	1	04/12/2004
	Tl*the contact owns a 1996 dodge grand caravan. the contact had the vehicle repaired according to recall nhtsa campaign id number 00v268000 (fuel system, gasoline:fuel injection system) in 2005. while driving approximately 35 mph, he smelled a mild burning odor. minutes later, he noticed smoke rising from the front end of the vehicle. seconds later, the vehicle was engulfed in flames. the fire department arrived and extinguished the fire. the majority of the vehicle was destroyed and it was towed to his residence. an investigator from the fire department concluded that the fire began near the fuel lines. the manufacturer has not been notified. the contact still has possession of the vehicle. the failure and current mileages were 130,000.
01/02/2007	140000	2
	Tl* - the contact's vehicle was taken to the dealer for recall 00v268000 repairs. the dealer told the contact that the recall repairs had already been made on the vehicle per recall requirements. this repair was done on december 11, 2006. on january 2, 2007 after driving approximate 6 miles the driver smelled gas fumes so he drove the vehicle back home. the contact stated that the gas fumes killed 14 of the birds that were housed in his garage. the contact opened the hood and gas was leaking. the contact stated that he had noticed the vehicle was using more gas than it had previously. the vehicle was still slowly leaking gas 24 hours after he originally noticed the leak. the contact stated that the vehicle was not drivable and he has not yet contacted the dealer. the contact stated the check engine light was on. ak updated 2/6/2007 - nm updated 03/21/07
01/16/2003	93662
	Consumer smelled fuel while driving, vehicle was towed to repair shop. mechanic determined a flexible fuel line is porous from frame to fuel rail, spraying fuel over engine. ts
11/01/2000
	Vehicle experienced an o-ring fuel leakage. manufacturer notified, and informed that part was not covered under a recall. feel free to provide any further details on this matter. *ak
05/13/1999
	There is a leakage within the gas tank, and consumer can smell gas within the vehicle. rollover valve is allowing fuel to pass into the vapor canister, resulting in a leakage from the gas tank. *ak
11/04/1996
	Took vehicle to the dealer 3 times for repairs and the vehicle is still leaking gas which poses a potential fire hazard. *ak
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM
01/02/2007	140000	2
	Tl* - the contact's vehicle was taken to the dealer for recall 00v268000 repairs. the dealer told the contact that the recall repairs had already been made on the vehicle per recall requirements. this repair was done on december 11, 2006. on january 2, 2007 after driving approximate 6 miles the driver smelled gas fumes so he drove the vehicle back home. the contact stated that the gas fumes killed 14 of the birds that were housed in his garage. the contact opened the hood and gas was leaking. the contact stated that he had noticed the vehicle was using more gas than it had previously. the vehicle was still slowly leaking gas 24 hours after he originally noticed the leak. the contact stated that the vehicle was not drivable and he has not yet contacted the dealer. the contact stated the check engine light was on. ak updated 2/6/2007 - nm updated 03/21/07
10/14/2003	172000	1
	While fueling gasoline spilled out from the bottom portion of the fuel tank. an independent mechanic determined that the o-ring snapped off, causing the gasoline to leak. *ak
		1
	After the recall was performed regarding the fuel rail seal, the vehicle started to misfire, the dealer refused to look at the vehicle without charging consumer. *jb
03/28/2002
	Vehicle is leaking fuel from the sealing o ring. dealer was not notified at this time. feel free to provide any further information.*ak
04/10/2002		1
	Consumer received recall (00v268000) notice for fuel rail replacement. recall notice stated that replacement would take up to 1 and 1/2 hours, however, dealership took up to 6 hours to repair. also consumer is requesting paper work for state inspection that was performed on vehicle. *tt
02/27/2002		1
	The consumer received a recall notice (00v268000) but parts were not available and the dealer had no idea when the parts would be available. *yh
		1
	The consumer received a recall notice on the fuel rail, but the parts were on back order and the dealer could not complete recall repairs. *yh
06/01/2001		1
	Consumer received recall 00v268, however vehicle had failures prior to receiving the notification, consumer states vehicle started losing power and would not go over 20 mph, dealer informed consumer that not only did the fuel rail assembly need replacing, but the engine needed to be replaced as well. *slc

	Even after fuel rail recall 00v268000 and replacement of fuel line at elbo, more items of replacement, including tank, were necessary to stop leaks. please describe details. *ak
05/06/2002
	Vehicle was leaking fuel in driveway. consumer received recall 0v26800 for fuel leak. took vehicle to dealer ,and they replaced seal. , but recall letter stated if fuel was leaking fuel rail assembly would be replaced. please provide any further information.*ak
02/25/2002		1
	Recall 00 v 268 000/fuel leakage: dealer: ed moses dodge, scottdale, az; phone 480-607-8584 was unable to honor recall repairs, no parts available.ak. consumer stated the parts were finally replaced on may 16, 2002.jb
03/28/2002		1	10/01/1999
	Nhtsa 00 v 268 000/ manufacturers recall 895 concerning fuel leakage. dealer, super store greenville, greenville, mi, phone# 616/754-3635 unable to honor manufacturers recall, no parts available. ak yh
			08/01/2099
	I was notified of recall the forst week of march. i have been calling since then to schedule repair. local dealer name above has not received parts needed to make repair. i call daimler chysler who contacted dealer. daimler told me the dealer had been ordering incorrectly and it would be corrected. the dealer now tells me the parts are on back order with no expected release date available. the recall notice i received said to : simply contact your dealer right away that after extended use, the fuel rail crossover tube o-rings on your minivan may leak fuel...can result in an engine compartment fire. they made the repair sound terribly important yet i can't get the repair scheduled.
			12/01/1995
	On waiting list for more than 48 days for fuel rail crossover tube o-rings replacement. dealer cannot say where we are on the list, just that you are in the pile. notified daimlerchrysler customer service, no assistance. now turning to nhtsa for assistance.*ak

	Got recall notice 00v268000/ manufacturer's recall 895 concerning fuel leakage. called dealer to make an appointment. was put on a waiting list because dealer stated manufacturer did not sent out more than 3 parts per month to fix recall. *ak
02/25/2002		0
	Leakage in fuel rail. had contacted dealer, but problem still there, and could not be fixed. please provide more information.*ak
02/25/2002		2
	Consumer had taken vehicle to dealer for replacement of malfunctioned fuel injector. had to be replaced twice. please provide more information.*ak
02/02/2002		1	11/01/2001
	I discovered a leak on the front fuel rail on my 1996 dodge grand caravan. was informed prior to purchase in november 2001 that all recall issues had been resolved on this vehicle. the repair had never been done to the van, and i discovered the leak as the van idled in my driveway on 2-2-2002.*ak
12/10/2001			12/01/1999
	Fuel leakage via cracked fuel rail and o rings. dealer states no recall so no free repairs.*ak
12/15/2001		1	03/01/1999
	Contacted local dealer and they did not want to fix problem under recall even though aware recall notice coming out in january. due to extreme hazardous conditions with planned trip of boy scouts immediate repairs necessary by local mechanic.
01/03/2001		1	08/25/1999
	There is a gas smell inside the vehcle. consumer feels this is dangerous because gas is leaking all over engine and could catch on fire. there is a recall for the fuel rail, however consumer has yet to contact the dealer. ak yh
12/01/2001
	Vehicle is leaking fuel can smell inside the vehicle. took vehicle to mechanic, and mechanic stated that fuel rail needed to be fixed. please provide more information.*ak
12/19/2001		1	08/01/1995
	This component has a recall at nhtsa site but chrysler has not recalled, it will cost 443.00 to fix, i do not have the money this close to christmas. when is chrysler required to recall. *ak
11/02/2001		5	06/01/1995
	Had dealer complete recall # 99v216000 in early 2000, upon driving home and filling the fuel tank noticed large amount of fuel leaking under vehicle. dealer towed vehilce back to dealership (their expense), and replaced cracked attaching nut from recall work. drove home (70 miles) and discovered small quantity of fuel still leaking from tank fittings. returned vehicle to dealer (my expense). shop advised they tightened loose attaching nut from previous recall. still noticed odor of fuel consistantly but could not see any leaks as previous. due to concerns about fire safety (i'm the fire chief in homer) i took vehicle to local garage (my expense). they found this same attaching nut and fuel pump module assemble leaking and referred me back to the dealership. returned vehicle to dealership on november 27, 2001 and picked it up on december 5 after they replaced sealing o-ring and attaching nut from previous recall (almost $100.00 of my expense). filled fuel tank on dec. 6 and discovered large quantity of fuel leaking from same area under vehicle. reported problem to dealship and they advised to return vehicle to them for further repair, with them recommending and ordering replacement fuel tank. i suspect a combination of poor quality work and possible design flaws with the tank and fuel pump module assembly, nut and o-ring.*ak
08/30/2001
	Vehicle was leaking fuel from o-rings as described in recall 00v268000. manufacturer has informed consumer that his vehicle was not included in recall. please provide any additional information/attachments.*ak
08/24/2001		1	10/01/1995
	O-ring connection between fuel rail leaks gasoline onto valve cover and then exhaust manifold. leaks most before engine warms up. strong gas smell outside car warned of problem.*ak
08/01/2001
	Fuel rail is leaking gasoline onto engine, causing vehicle to smoke. dealer has been contacted. manufacturer informed consumer that they are aware of the problem, but cannot issue a recall until the parts are made. please provide further details.*ak

	Recall number 00v268000. vehicle is experiencing recall problem, but not selected for manufacturer's recall. fuel is leaking from fuel injection fuel rail. please give any further details.*ak
06/15/2000			06/01/1998
	During a vehicle repair, non-dealer repair shop discovered leaking fuel injector rail and o-rings. local dealership and manufacturer contacted but both stated there was no recall and refused to provide repairs at no cost. your nhtsa campaign id number 00v268000 identifies a recall that is not being honored by the manufacturer or the local dealership. fuel leakage is present currently. dealer says owner must pay for repairs and may receive reimbursement at a later date. complaint was given telephonically to daimlerchrysler on june 15, 2000 and received confirmation of daimlerchrysler's complaint reference number is 8765666. dealer says no recall appears for this vehicle when search is by vin number. *ak
03/19/2001		1
	Consumer has fuel leaking from fuel rails at o ring. it's a 3.8l engine. consumer is contacting manufacturer to see if recall 000v268000/ manufacturer's 895 applies to this vehicle. ak slc
10/01/2000		1	09/03/2000
	Vehicle is leaking fuel. dodge dealership informed consumer that there was a defective fuel rail in vehicle. consumer was informed vehicle was not part of any current recalls. there was a fuel smell when consumer was inside vehicle,. also, a small fire began from overheating of manifold. ak slc
03/07/1997		2
	Consumer smelled fumes in car. then, consumer received recall00v26800 for fuel pump seal leakage. took vehicle into dealer, and it was replaced. however, problem still occurred. presently, can see gasoline leakage on pavement.ak slc
12/23/2000		0
	Consumer started to smell fumes very strongly. took vehicle to mechanic, and mechanic said it was the fuel rail. also, there was recall 00v268000 which dealt with same problem. consumer felt ths vehicle should have been included in recall. *ak
		1	01/03/1997
	Consumer received recall 00v268 and went to the dealer to have repairs completed, however the dealer stated that the fuel tank would have to be replaced before the recall could be completed due to the fuel tank being warped, consumer feels the dealer should be responsible for the faulty fuel tank. *slc
09/10/2000		1	12/01/1998
	Replaced complete air condition system, front and rear, transmission, fuel injection, cv joints, fuel tank leaks, the list goes on and on. *ak
10/14/2000		1
	Consumer had recall 00v268 repair completed on vehicle, however the gas tank bursted into flames a few months after the repair was done. *slc
06/11/2000		1	04/01/1999
	The fuel rail started leaking after removal; trying to change valve cover gaskets & using a certified auto mechanic, he verified the proper instructions for removal w/ the mitchell's service manual & now they are leaking fuel that could cause a fire; talked to dodge parts counter & they are aware of problem & said they have modified the part but will cost me $160 for replacement of their poorly designed part. no recalls are listed and now a small job has turned into an expensive one. *ak
05/28/2000		0
	Fuel line that goes into fuel injector tube, was leaking. this can cause a fire. also, front brake pads broke off inside of brake holder, and consumer has no front brakes.*ak

	Due to the location and the design of the fuel line vent tube/clip and o ring the o ring has corroded, creating a fuel leakage. consumer has contacted the dealer, dealer has yet to replace parts. please provide any further details. *ak
11/16/1999			09/01/1995
	This fuel rail was recalled on the 3.5 engine in the dodge caravan but not on the 3.8 the fuel rail is the exact same part as was recalled on the 3.5 but was not recalled on the 3.8 i had top repalce the fuel rail on my 3.8 with the same part as was recalled on the 3.5 engine. i feel that chrysler should be made to recall the fuel rail on the 3.8 engine just as it had to on the 3.5 wengine. i do not believe i should have to pay for this repair which was just under $325. it is unbeleivable that i should have to replace a bad part on the 3.8l engine with the exact same part as was recalled on the 3.5l: engine. please contact me about this. *ak
12/01/1998		1	08/01/1995
	Defective roll over valve caused the gas tank to leak gasoline.
03/01/1996
	While driving the vehicle stalls intermittently which can cause an accident. dealer cleaned out the throttle body 3 times due to carbon build up which hasn't solved the problem. *ak
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - FUEL RAIL
12/29/2004		1
	1996 dodge grand caravan caught on fire. *no answer required. mr feul rail leak caused the vehicle to catch on fire while driving. *nm
02/15/2004	90000	2
	Fuel rail leaked. recall 00v26800 repairs were performed; however problem still exists. *ak
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS
03/19/2001		1
	Consumer has fuel leaking from fuel rails at o ring. it's a 3.8l engine. consumer is contacting manufacturer to see if recall 000v268000/ manufacturer's 895 applies to this vehicle. ak slc
FUEL SYSTEM, GASOLINE - STORAGE

	The van had been driven 2-3 hours prior and parked. at 3:00 am while parked, the van caught fire in the front more so to the left side. the steering wheel was melted along with the front tires, dashboard, etc. diamler chrysler is sending a representative out to diagnose the van. this van has a 3.3 litre engine as stated in the recall for the fuel rail cross over tube -o- ring; nhtsa recall campaign 02v293000, which the owner has yet to find out if actual recall affects her van. please describe details ts
07/01/2001		1	10/01/1998
	When parking on a steep incline two weeks ago, i noticed the smell of gas. i looked at the gas tank and saw significant leakage. i took the vehicle to the chrysler dealer where i have my service done. i was told by bob leland that the cause of the lead was the rollover valve on top of the tank, and that the only remedy was a complete gas tank replacement at a cost of $809, plus tax. he said there is another rollover valve on this vehicle that was subject to a recall, but that this is a different rollover valve. i contacted two persons at daimler-chrysler customer service (using the number that bob leland gave me). both person, ryan and jule at 800 992 1997 indicated that the part was not subject to recall, was not under warranty, and therefore they would not pay for repair--or contribute to the expense of repair. i was told by bob leland that there was no good reason for the rollover valve to crack, i.e. there was no sign of any trauma to vehicle or any indications of an accident. i had the vehicle inspected by renton chrysler before i purchased it from the orignal owner, and they confirmed that it had never been in a wreck. i have had no wrecks since owning the vehicle. i took the vehicle to a goodyear service center in town (new concepts auto at 509.747.2164). they pulled up the technical service bulletin, showing numerous problems with the fuel tank, rollover valve, and fuel lines. they were unsure whether the tsb referred specifically to the top valve. because they had a lower estimate to repair ($720 including tax), i gave them the go ahead to repair today. i cannot drive the van with a fuel leak, especially with my infant and toddler iusing car seats. this is a serious hazard, and i believe that chrysler should pay for the repair. i have instructed the goodyear shop to inspect for any trauma to the tank and car, and i am sure they will find none. i will also have them keep the tank so that it can be inspected asap. leland aware of 2 similar cases.
FUEL SYSTEM, GASOLINE - STORAGE - AUXILLARY TANK - SELECTOR DEVICES
07/23/1999		2	07/29/1995
	The fuel tank rollover valve can allow fuel to pass into the vapor canister. recall remedy did not correct the problem. recall number 95v236000.at 27000 miles with fuel tank leaking profusely, after recall performed while putting gas into vehicle the gas poured out on the ground, replaced gas tank and o-ring to solve problem. *ak.
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY
01/01/1901		1
	1996 dodge grand caravan with leaking fuel tank. consumer states that she did a search on the internet for recalls and found several for her vehicle. she states that she never received any paperwork from the manufacturer about the recalls. *kb
10/24/2005	83000	1
	Dt: the contact stated that gas tank had to be replaced. it was falling apart at the top of the tank. when filling the vehicle up with gas it spilled everywhere. the gas was seeping out of the top. he called the dealer and it was not under recall.ak updated 11/29/05. jb
09/25/2005	131000	5	04/10/2002
	1994 dodge caravan le, v6, 3.8 l. leaking fuel tank. fuel leaks when vehicle
08/30/2005	85000	1	04/28/1995
	Occasional fuel smell from car for many months. after filling and parking car with rear end on up hill incline noticed gas pouring out from under car from top of gas tank. took to dealer they said all recalls were performed. they dropped tank and informed me the plastic tank was splitting at the seam on top. not a dodge problem . my cost to replace $900.00. i think this is a manufacturer defect since i have been informed by several outside mechanics that they have replaced quite a few of these chrysler fuel tanks. the potential for fire is great for some one passing by and flipping a cigarette. *jb
07/21/2005		1	11/01/1995
	Dt: the consumer stated vehicle was leaking fuel from fuel tank, and has already had three fuel related recalls. there was a defective roll over valve. the vehicle is currently at the dealership. they have not stated why the problem was happening. also called the manufacturer. the fuel leaked when the tank was relatively full. the problem was noticed four or five months ago. on july 21, 2005 there was fuel under the vehicle. consumer stated it was his wife's vehicle.ak jb
05/01/2002		1
	The consumer requested reimbursement for fuel tank replacement.mr. the consumer noticed a leak under the van, and seeing the leak become worse after filling up the vehicle, the consumer discovered the van was leaking gasoline. the fuel tank was replaced. ts *jb
02/10/2003	55000	1	03/01/1996
	The fuel tank cracked and leaked fuel. *jb the consumer was told that the problem was due to the fuel tank assembly which had additional brackets. the consumer felt that this was a design flaw. scc
10/02/2000		1
	While traveling on highway there was a fuel smell coming from inside of the vents, and fuel was leaking from underneath the vehicle. built in check on top of fuel tank was cracked and leaking. .jb. ak
09/24/2002		1	04/01/2002
	Fuel tank leaked profusely when full. tank had a leaky vent on top repaired cost $300. i noticed several of these tanks setting around the dealers repair area that have been replaced. dt
08/01/2002	115000	1	11/20/2002
	The fuel tank was leaking fuel. ts tt jb
07/17/2002		1
	Fuel tank developed a crack and caused fuel leakages. dealer notifed. feel free to provide any further information.*ak
06/22/2001
	Recall 99-v2-216-000/ manufacturer 'sid recall 895 concening fuel leak from tank immediately after it was filled. consumer never got a chance to pull off from the gas station after paying, and noticed at least half was on the ground. dealer was notified, and never located cause of problem.vehicle was previously serviced for a recalls in january and april of 2002 for fuel leakage. please provide more information.*ak
05/15/2002
	Vehicle has a hole on top of gas tank, and tank is leaking gasoline. dealership is aware of problem.*ak
06/07/1996		7	04/11/1996
	Consumer stated gas tank would only hold 14 gallons, dealer replaced gas tank, approximately 3000 miles later, consumer complained that the tank was only holding 16 gallons, dealer replaced the tank leveler and new gauge, however in doing so a plug had been overlooked and caused a fuel leak when consumer attempted to fill the tank, around 6000 miles later, consumer stated again that the tank was only holding 16 gallons, dealer stated that when tank was on empty it still had 2-3 gallons in reserve, dealer later replaced gas tank for the second time along with o-rings and a nut lock spacer. *slc
07/05/2001
	After filling up fuel tank consumer was driving up an upgrade when front seam on gas tank split and allowed gas to leak out, putting vapors in passenger compartment. took vehicle to dealer, and they replaced fuel tank. please provide any further information.*ak

	Fuel tank leaks when filled full with fuel and has a strong odor of gasoline inside and outside. fuel odor is nauseatng.*ak
01/27/2002			07/01/1996
	This is a followup on odi 757393 submitted on 1/24/2002 and amended 1/27/2002. upon towed return of vehicle to service agent repair shop, service agent investigated visible gasoline leak. upon careful examination of the replacement vent assembly, service agent reported that while the part looked like the right part; it indeed was an incorrect part. the service agent said the part was previously packaged and shipped in a box with the correct part number; however in conversations with daimlerchrysler, it was only then determined to be an incorrect part. they could only distinquish the part by its vendor manufacturer's casting number cast into the assembly. chrysler verified that this was indeed an incorrect part; and a replacement vent assembly was ordered and replaced. this alleviated the prevous leak. service agent reports his technician could not distinguish the incorrect part from the real part, and felt it was securely tightened, but the apparent clearances and slight size differences allowed the gasoline leak to develop. no leak was further noted with the complete fill-up of the gas tank by the owner. it is noted that the service agent had no special procedure for testing the gas-tightness of the gas tank as he had not previously filled the tank to overflow to check same. this appears to be a deficiency in tank replacement procedure, as it was only when the owner subsequently filled the tank that the original leak was ever detected.*ak
01/17/2002		1	07/01/1996
	Owner reported raw fuel odor after filling fuel tank. previous tsb #845 recall (o-ring) was performed 04/21/2000 and verified ok. service agent reports vent assembly on gas tank defective and leaking. fix involved complete replacement of gas tank with new model, as present vent assembly is no longer manufactured nor compatible with original tank. dodge post warranty participated for 50% of matl cost of tank only. dissatisfied owner made to incur $302 matl/$100 labor + tax to incur fix. owner requested defective part; dodge service agent refused citing not applicable to extended post warranty offer and need for service rep to account for same. would only release part if owner fully paid for fix. (sounded like a ruse.) owner was forced to accept offer in light of safety concerns. suggest investigation of defective part, as currently held by service agent and why original part is no longer available to accommodate repair making the fix to manufacturer's new designs(desires)? owner has expressed his total dissatisfaction to service agent with no results, short of suggested withdrawal of offer. service manager suggested if owner did not wish to participate in the fix he would suggest that the owner not completely fill up the gas tank. owner notes an extremely close proximitiy of the defective original (and replaced) plastic vent assembly to rear muffler assembly. the replacement tank is also plastic. the original gas tank was reported to be good at time of recall, and at time of replacement. service manager alluded to free replacement of tanks shown to buckle or bow at time of recall #845. similar offer was not extended at present time of replacement of gas tank.*ak
02/23/2001		1	09/01/2000
	Plastic fuel tank ruptured for no apparent reason-gasoline leaked into garage. *ak
05/01/2001		1	07/24/1995
	When vehicle was parked on a decline, fuel would leak out when it was full or 3/4 full. mechanic indicated ball unit that prevents fuel from leaking out of the tank convertor was failing and not sealing it off.ak jb
06/07/1996		7	04/11/1996
	Consumer stated gas tank would only hold 14 gallons, dealer replaced gas tank, approximately 3000 miles later, consumer complained that the tank was only holding 16 gallons, dealer replaced the tank leveler and new gauge, however in doing so a plug had been overlooked and caused a fuel leak when consumer attempted to fill the tank, around 6000 miles later, consumer stated again that the tank was only holding 16 gallons, dealer stated that when tank was on empty it still had 2-3 gallons in reserve, dealer later replaced gas tank for the second time along with o-rings and a nut lock spacer. *slc
02/01/1999		1	08/01/1998
	No summary listed in above vehicle. *ak
09/28/2001
	Fuel gauge fluctuates, within a period of 10 minutes it will show 1/2 a tank, then almost empty.*ak
			07/01/1995
	Gasoline leakage from fuel tank. when the tank was full, parked on an incline, or upon braking a steady stream of gasoline would run out of the vehicle. i took the van to the dealer, and despite several recalls for fuel system problems with the vans, i was told my problem was the bleeder value, which was not a recall item. the fuel tank would have to be replaced for $930. naturally, i had to have the problem corrected. has this been a common problem? could this have actually been one of the recall problems? do i have any recourse? thank you.
			07/01/1996
	In october of 1999, our van was overheating and we had to have the radiator fan relay replaced. two weeks later we received a recall notice and were reimbursed by daimler chrysler. in february 2001 our airbag indicator light came on and the horn stopped working. we replaced the clock spring. in june 2001 we had to replace our fuel tank because it was cracked. we continued to smell gas and had to have our fuel rail replaced because it was leaking fuel onto the engine. we were told not to drive it because it could catch on fire.*ak
10/15/2000		1	04/21/1998
	Fuel leakage from top of fuel tank. dealer / manufacturer notified, and informed consumer no recall on that part, and any repairs would be at consumer's expense. please feel free to provide and further details on this matter . *ak the vehicle is experiencing fuel odor inside the vehicle especially at fill up, the consumer believes this may be related to recall work performed several months prior, the dealer noticed leak at the top of the tank but stated that it was not related to prior recall repair (o-ring replacement), fule filter was replaced, air bag light is on. nlm
03/12/2001		3
	Airbag light is on, dealer found clock spring assembly needed to be replaced. ak consumer states that he had to make 3 different trips to the dealer due to the first 2 trips did not resolve the problem. brakes failed. collapsing gas tank. door locks inoperable. slc
		1	01/03/1997
	Consumer received recall 00v268 and went to the dealer to have repairs completed, however the dealer stated that the fuel tank would have to be replaced before the recall could be completed due to the fuel tank being warped, consumer feels the dealer should be responsible for the faulty fuel tank. *slc
09/10/2000		1	12/01/1998
	Replaced complete air condition system, front and rear, transmission, fuel injection, cv joints, fuel tank leaks, the list goes on and on. *ak
07/15/2000		1	08/01/1995
	A crack was found in the top of the gas tank by the dealer when i brought the vehicle in for correction of a fuel system related recall. either they cracked the tank during the repair or it was already cracked. it makes no sense that a gas tank should crack. i have had no accident with this vehicle and it is driven carefully. i asked the dealer if this was a recall item and they said no. however, after having the tank replaced i found out that a new tank has been designed for replacement. why would dodge need to redesign the tank if it was designed properly in the first place? if other tanks have this problem of cracking, there is certainly a major safety problem for owners of these vehicles. please investigate the ocurrence of this problem with these vans. thanks.*ak
08/22/2000
	Consumer has taken vehicle to dealer 3-4 times. original owner showed that recalls were taken care of. consumer has had other dealer to verify that work was done right. fuel tank leaked & had a odor that came from it. problem was intermittent. a mechanic was going to change purged canister to rectify the problem. manufacturer believed that could be the problem. previous owner could have over filled the tank which could have been the reason.*ak
06/01/1999		1	01/01/1996
	This defect in my opinion represents a serious possibility of causing a fire. gasoline is leaking on to the road surface below the car especially when the tank is over half full. chrysler yesterday declined to replace the gasoline tank due they said to the vehicle's high mileage. a fire could easily start by a spark or a thrown cigarette. the local dealer said the the cost to replace would be around $450.00. i don't think i should pay for this as i have done nothing to cause it. the failed part is located on top of the fuel tank such that it is protected from road rocks, debris, or just about any conceivable hazard that would be encountered in normal or even harsh driving conditions. this car is never taken off the hard road. thank you. *ak
11/10/1995		3	07/01/1995
	I question the need for a new fuel tank i paid for - 594.31 parts and labor. the tank only leaked when it was full, and when i questioned the service rep, he replied that the tank is made of plastic and can crack just from the sloshing of fuel. not a good reason. and now i have a recall for the same problem i described to the service rep. i thought the known problem with the windshield wipers was fixed when the dealer replaced a windshield that had been scratched by impulsive wipers. not so. they still misbehave and i'm told it will be $280 to repair, out of warranty. three rack and pinions right off the bat. i am told that this vehicle qualifies as a lemon - but i like it and just want to be treated fairly as to need for repairs and their cost.
		1
	The fuel tank leaked fuel from the seam and is a serious defect,because it is located near the exhaust pipe. yh
09/08/1999		1	10/01/1996
	A hole developed on top of fuel tank. exact thing happened to friend w/ same vehicle, same year, and about the same milage. would leak gas and create strong fumes when tank was fairly full. *ak

	Front rotors warped or flawed. heavy steering wheel and front end vibration during downgrade slow braking. fuel tank is collapsed which will hold only about 13 gallons. wipers coming on intermittently and gets worse when climate gets hot. belt tensioner failed which can hit and break the main crankshaft pulley.
11/16/1999		1	10/01/1995
	Strong gas smell in garage. tank 3/4 full. dealer said tank leaking from vent tube access cover and could not be repaired. no indication of damage to tank; lea caused by natural flexing. mechanic said he had replaced several tanks and new tanks re-designed to solve problem. this is dangerous problem - fire hazard. re-design indicates chrysler has acknowledged problem but has not initiated recall action.
11/16/1999		1	10/01/1995
	I noticed a strong gasoline smell after van had been parked on garage over night. the tank was about 3/4 full. the repairing dealer said the tank was leaking at a vent tube access panel and could not be repaired.
10/01/1999		2	07/01/1995
	Fuel tank leaks from top if filled completely.
08/02/1999
	Had filled vehicle with fuel, drove home & parked vehicle. had noticed fumes coming from inside of garage. the fuel had leaked out of fuel tank. notified fire department of fumes & leaking gas. was informed to dry vehicle & take vehicle out of garage.

	Vehicle had defective fuel tank, resulting in fuel leakage. consumer had tank replaced . *ak
06/01/1999		2	07/01/1995
	When filled fuel tank around the top seam began to leak. dealer contacted and could not remedy problem. repairwork done at owner's expense. ak ml

	Fuel tank cracked at the seam, causing fuel leakage. the dealer will be notified. *ak
08/17/1999
	The top of the fuel tank which is also attached to the vehicle cracked, resulting in a fuel leak which may cause a fire. dealer need to replaced fuel tank. please provide further information. *ak
07/20/1999			09/01/1995
	Ea99013, the valve located on top of the gas tank leaks, which may cause a fire if there is a source of ignition. tank replaced by dealer, at half cost to the owner. *ml
08/11/1999		2	08/01/1995
	Consumer noted fumes/ gas smell within the vehicle when exiting and entering, further inspection of vehicle indicated fuel leaking. consumer contacted the dealer, dealer determined the cause of the problem to be the gas tank which was split at the seam, dealer has replaced the fuel tank. ak ml
10/02/1998			09/01/1995
	Fuel tank leaked and dodge would not replace as the vehicle was out of warrenty
09/22/1997		1	10/01/1995
	I purchased this vehicle october of 1995, in march of 96 the fuse block had to be replaced along with a multi function switch because the wipers would come on by themselves while i was driving, a contact and plunger kit because the right sliding door would not always unlock when using the unlock button, the fuel tank was replaced because it only held 12 gallons of gas when it was supposed to hold 18 - 20, the tank was installed so that the tank was bowed in the middle and the front door panel was reattached to the door and the left sliding door was repaired because it would not unlock with the key. in august of 1997 the switch for the interior lights was replaced because the lights would flicker, the left side sliding door lock was replaced again along with the rear door latch. in sept. 0f 97 a gear was replaced for the power steering, the left sliding door had moulding replaced because the clips were broken. in august of 98 the stereo was replaced because the treble would fade, the vehicle shut off while i was driving no one could explain this phenomenon, the relay switch was replaced and the rack and pinion was replaced also the multi-function switch was replaced again. in sept. of 98 the car was back in the shop because the air bag light came on. evidently when they replaced the relay switch just 7 days earlier things in the dash started working that had not worked up til that point for instance i was not aware that the chime would go off if the blinker was left on for over a mile. it took 7 days to get my car back because they found out that there were never any screws holding the air bag in the module so as far as i know for the two years that my husband and i were driving this car there was no protection by and air bag. this past week july 1, we were on vacation and we had to replace the transmission to the tune of $l771. the car is back in the shop today (7/6) because it appears that the transmission continues to slip and run at high rpm.please help!!
05/13/1999
	There is a leakage within the gas tank, and consumer can smell gas within the vehicle. rollover valve is allowing fuel to pass into the vapor canister, resulting in a leakage from the gas tank. *ak
			08/01/1998
	We had noticed the smell of gasoline for some time. informed by carmax that this was a common problem with dodge caravan; i.e. fuel tank develops a leak. finally noticed it leaking fuel in a steady stream when we parked it facing downhill. leak stopped when car parked at an angle facing uphill, or when level. fuel tank is being replaced now. *ak
08/22/1998		0	09/06/1995
	Fuel is leaking from fuel tank. *ak
10/20/1998
	When getting into the vehicle consumer can smell vapors. also transmission leaks. in addition, when putting gas into the vehicle, consumer should be able to put 15 to 16 gallons into the tank, but can only put 12 to 13 gallons into the tank. *ak
		1
	Gas tank was leaking from the vents in the tank, resulting in strong gas fumes inside and outside vehicle. dealer replaced the gas tank. *ak
06/01/1998
	Ongoing problem with fuel tank leaking. dealer notified and replaced tank at owner's expense. *ak
		1	07/31/1995
	After filling vehicle with gas it leaks fuel due to a bad gasket. manufacturer has subsequently redesigned the gas tank to correct this problem. *ak
			09/05/1995
	Front windshield wipers come on without activating them. in addition, bench passenger seatbelt disconnects when buckled; brakes wore out when the car had 32,000 miles; left front tire blew out on the freeway at 7,000; transmission overhauled at 44,000 miles; passenger's sliding door locks do not open when unlocked, and gas tank was leaking. *ak

	Consumer complains that the vehicle he purchased from the dealer had apatch on the gas tank that just failed. dealer ordering part to fix it. consumer inquires about course of action that he might be able to take.
		1	10/01/1995
	Fuel gauge and tank failed.
10/16/1997		2	07/15/1995
	Fuel tank leaking at the top of the tank where sending unit is located.
05/08/1997		2	10/01/1995
	Gas tank collapsed, tank reading said zero, with gas in tank, dealer replaced tank, subsequently, tank fitting became loose, causing gasoline spillage on vehicle/onto ground, could smell gas fumes. ak slc
06/01/1997			05/19/1996
	Fuel tank leaked at top of tank where it was molded to a hose outlet. fuel leaked when tank was full. also transmission gasket leak. *ak
01/01/1996		1	05/01/1995
	Gas tank door occasionally does sticks.
08/13/1997		1	07/01/1996
	Gas tank leaks gas . the fuel tank split on top. ak dealer found the plastic tank had split on top, consumer had to wait for 2 weeks for replacement due to national back order. slc
05/18/1996		1
	Fuel gauge inaccurate.
01/01/1997		1	03/01/1996
	Gas tank leaks when filled beyond 3/4 tank.
			07/06/1995
	Battery blew up, resulting in an accident. also fuel tank leak. *ak
12/04/1996		1	05/01/1995
	Fuel tank defective.
07/29/1996		1	06/28/1996
	Gas tank failed.
12/25/1996		1	12/01/1995
	Fuel tank leak.
12/27/1996		1	01/01/1996
	Gas tank buckled to the point of only taking 75 percent of capacity.
03/01/1996		1	10/01/1997
	Gas tank ring failed, causing gas smell.
03/01/1996		1	01/10/1996
	Gas tank replacement due to inoperative gas gauge.
		1	12/01/1996
	Gas tank seal leaks.

	Experienced raw gas fumes coming into vehicle interior, found gas tank had split open underneath along seam, no accident.*ak
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP
11/08/2005	191000	1	06/25/1995
	1996 dodge grand caravan fuel filler neck- rusted through and leaking when refueling.*jb
09/15/2002		1
	The fuel tank pipe filler neck has broken. dealer has been notified. mr one or more of the plastic hoses exiting the plastic fuel tank were leaking. the replacement parts are no longer available. daimler chrysler replaced with steel tank and fuel lines. the consumer states that he had to replace at a price of $740.78. daimler chrysler refused to reimburse. the consumer feels that the leaking fuel in the garage was a major fire hazard. scc
10/14/2000		1
	After receiving the first recall notice (96v-002) the repairs were made at the dealer, approximately 5 months later the fuel tank caught fire while being driven, and the consumer believes that the initial repair was done incorrectly or was not done at all the consumer is requesting compensation for the losses sustained. nlm
06/07/2000		1	03/01/1998
	Chrysler corp notified me to return my dodge van for fuel filler tube recall service. i made an appointment with arrigo dodge, an authorized dodge dealer, to perform the service. after three months waiting, mark norman scheduled my recall service. mechanic number 269 performed the recall service on 6/7/2000. i received my van on 6/7/2000 and proceded to fill up an empty fuel tank. when the pump's auto shutoff engaged, heavy fuel overflowed under my van. i looked under and saw fuel spilling from a juncture of the fuel tube and two connecting lines from the fuel tube to the main gas tank. this has never happened before during my ownership. i immediately returned to arrigo dodge's mark norman to complain. he allabied with ...let everthing seat into place. drive it for several tanks of gas. the leaking never corrected itself and the fumes radiating from the fuel filler valve continued. excuses have continued for 17-months. i have been passed back and forth between arrigo dodge and chryler corp's customer relations for months after i realized arrigo dodge was stonewalling. arrigo dodge also fired my first service writer, mark norman. i went and paid for an independent chrysler dealer to locate the problem area, just to have confirmation where the leak was originating. i have dates & summaries of my honest efforts to resolve this service fault. on 11/8/2001, i was blatantly lied to by service manager, orlando ferrer, and decided to use other alternatives to correct this service blunder.*ak
07/24/1999
	Filled the gas tank, drove home and parked vehicle in the garage. smelled gas, pushed car out of the garage and ther ewas no evidence of gasoline leakage. took car to the dealer, and was told that the nipple to the feeder line had disintegrated.*ak

	Vehicle was recalled for the fuel filter and the fuel pump. the vehicle has been leaking fuel . the dealer has been made aware and has replaced the fuel tank. (95v-234). *ak
08/13/1997			07/21/1996
	Fuel tank split, causing fuel to leak out prior to after recall repairs. also windshield wipers would go on intermittently bythemselves. (95v-236). *ak
11/02/1996		2	07/03/1995
	Cap on fuel tank leaks.
12/04/1996		1	05/01/1995
	Fuel filler failed.
03/16/1997		1	06/01/1995
	Gas tank filler tube leaks.
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - MOUNTING
03/16/2001		0
	After a strong smell of fuel consumer opened hood and fond out a fuel leakage. then took vehicle to dealer where they said that fuel was leaking from rail cross over tube and was replaced.*ak
FUEL SYSTEM, OTHER

	Horn ,cruise control,does not work and the gas light will come on and make a beeping sound for no reason. *ak
05/01/1996		1	05/01/1996
	Fuel gauge failed.
FUEL SYSTEM, OTHER - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS
12/05/2002	190000	0	01/09/1999
	On december 05/2002 my 1996 dodge grand caravan caught on fire. the car was just warming up prior to being used to take my kids to school. the fire was extinguished by the dekalb county, georgia fire department. i learned after the fire that chrysler had a recall related to a fuel rail/system defect. i have all major mechanic work done at the authorized chrysler dealership and was never told of this recall.

	Fuel roller valve that shuts the fuel off in case of an rollover accident is leaking. dealer has been contacted.*ak
FUEL SYSTEM, OTHER - STORAGE
03/22/1996		1	10/12/1995
	Fuel tank leaks.
10/01/1996		1	09/01/1995
	Gas leak after fuel tank recall repair.