Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| EXTERIOR LIGHTING | ||||||||||||||||
| 06E060000 | AAI MOTORSPORTS USA, LLC | E (Equipment) | 87745 | 08/01/2006 | OVSC | CHRYSLER GROUP LLC | 06/29/2006 | 06/29/2006 | 571 | 108 | ||||||
| Defect Summary | Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. | |||||||||||||||
| Consequence Summary | Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash | |||||||||||||||
| Corrective Summary | Aai motorsports will notify owners and replace the lamps free of charge. the recall began on august 1, 2006. owners may contact aai motorsports at 909-923-9188. | |||||||||||||||
| Notes | This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled lamp model numbers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
| 09E012000 | SABERSPORT | E (Equipment) | 16270 | 05/11/2009 | OVSC | CHRYSLER GROUP LLC | 04/07/2009 | 04/07/2009 | 571 | 108 | ||||||
| Defect Summary | Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. these lamps do not contain the required amber side reflectors. | |||||||||||||||
| Consequence Summary | Decreased lighting visibility may result in a vehicle crash. | |||||||||||||||
| Corrective Summary | Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589. | |||||||||||||||
| Notes | This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under document search located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| EXTERIOR LIGHTING - HEADLIGHTS | ||||||||||||||||
| 09E025000 | DOPE, INC. | E (Equipment) | 42540 | 07/28/2009 | OVSC | CHRYSLER GROUP LLC | 05/11/2009 | 05/11/2009 | 571 | 108 | ||||||
| Defect Summary | Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. these lamps do not contain the required amber side reflectors. | |||||||||||||||
| Consequence Summary | Decreased lighting visibility may result in a vehicle crash. | |||||||||||||||
| Corrective Summary | Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798. | |||||||||||||||
| Notes | This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under document search located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| 08E050000 | K2 MOTOR CORPORATION | E (Equipment) | 1921 | 12/17/2008 | OVSC | CHRYSLER GROUP LLC | 08/11/2008 | 08/14/2008 | 571 | 108 | ||||||
| Defect Summary | K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. | |||||||||||||||
| Consequence Summary | Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash. | |||||||||||||||
| Corrective Summary | K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992. | |||||||||||||||
| Notes | This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| EXTERIOR LIGHTING | |||
| 02/13/1997 | 1 | ||
| Hood light flashes on and off when driving due to short. | |||
| 1 | |||
| Light switch failed. | |||
| 03/10/1997 | 1 | ||
| Clearance lights shorted. | |||
| EXTERIOR LIGHTING - HAZARD FLASHING WARNING LIGHTS | |||
| 07/07/2003 | 53000 | 1 | 05/01/1996 |
| While driving, the vehicle shut down completely. dealer notified. *ak. it was determined the fuel pump failed which caused the vehicle to stall. also the rear hazard lights did not work. *jb | |||
| EXTERIOR LIGHTING - HEADLIGHTS | |||
| 07/11/2005 | 2 | 11/01/2003 | |
| Dt: consumer states: the headlight switch keeps burning up in his 1996 dodge ram truck. it is burning the wire harness that goes to the headlight switch. it could go out at any time. he had it replaced about 3-4 months ago and it is out again. he has talked to the dealer and they have made a special wire harness to splice into the wiring on the truck. they have had a lot of problems with this same thing. the dealer said chrysler was aware of the problem. he can be going down the road, and the lights will just go out. you can park it for a while, when you come back to start the car and switch on the headlights the headlights will not work. the last time he had it replaced, the wiring had melted the insulation. *nm | |||
| 02/01/2001 | |||
| Headlights don't work when steering wheel is in a downward driving position. if steering wheel is pushed all the way up headlights come on. consumer received a recall 00v135000/ manufacturer's recall 875. when vehicle was taken into dealer's repair shop, dealer wasn't sure if recall was for that specific problem. dealer didn't fix it under recall.*ak | |||
| 05/09/2000 | 5 | 02/01/1998 | |
| During failure all of the warning lights flash the transmission goes haywire and the tachometer goes haywire. this truck has been at three different shops, we have changed out the transmission relay, the headlight lamp, serviced the transmisison and still cannot find the cause. in addition, we have replace a radio which has shorted out and the fuel indicator doesn't work. both of which failed before the truck was three years old, unfortuneately just out of warranty. *ak | |||
| 04/19/2000 | 1 | 03/01/1996 | |
| Headlamp switch and connector melted, amperage overload, reinstalled relay assembly and headlamp switch, notified by dealer that there is no recall on this, yet they are aware of the problem because they have redesigned the relay assembly | |||
| 11/24/1999 | 6 | 10/01/1995 | |
| The headlights went out when i changed to high beams. i pulled off and cycle the switch and they came on. this happened several times. i continued to drive with just the low beams. the dealer said the multi-function switch had failed and replaced it. i think it is only fortunate that an accident did not occur. | |||
| 11/15/1998 | 1 | 03/01/1998 | |
| Spent $1200 to rebuild entire front end of car due to excessive clunking and looseness after only 40,000 miles of lite street use. factory installed componants obvoiusly inferior quality or defective. dailmer chrysler was willing to assist in the costs of the repair until the bills came in. daimler chrysler walked away from the issue. rear window water leak - suggest other owners to look on passenger side for water ponding adjacent to sill plate at rear of seat. rear factory sliding window defective. must replace with alternate selection. headliner will not fit properly on alternate selection - beware. dodge ram owners beware. this owner jumping ship from dodge/chrysler products. only owned this vehical for 11 months. | |||
| 09/24/1998 | 1 | 02/25/1997 | |
| While driving with the signal lights on, they may go off, also experience problems with high beams and the low beams.*ak *jb | |||
| EXTERIOR LIGHTING - HEADLIGHTS - HIGH/LOW BEAM DIMMER SWITCH | |||
| 12/29/1998 | |||
| While driving driver smelt something burning and the compartment filled up with smoke, and the headlight switch burned up. owner replaced headlight switch himself. problem was reported to chrysler. *ak | |||
| 04/26/1998 | 1 | 05/01/1996 | |
| Low beam headlight failed. | |||
| EXTERIOR LIGHTING - HEADLIGHTS - SWITCH | |||
| 04/02/2007 | 9900 | 12 | |
| Tl*- the contact owns a 1996 dodge ram pickup. while driving at 55 mph the lights turned off. the contact was forced to stop the vehicle while it cooled off, and after approximately 15 minutes, the vehicles lights illuminated. also, the failure caused the wiring harness to melt. the contact stated that this failure occurred too frequently . it began to occur 1 year after purchasing the vehicle, and he replaced the headlight switches over 12 times. daimler/chrysler stated that the vehicle had too many miles on it and that it was not related to recall #99v024000 due to the vin. the contact was aware of the safety risk involved. the failure mileage was 9,900 and the current mileage was 177,000. *ak | |||
| 11/28/2006 | 134000 | 5 | 10/01/1998 |
| Dt*: the contact stated while driving at night, the headlights failed intermittently without warning. the vehicle was driven to the dealer on four occasions and the ignition switch was replaced each time. however, the problem recurred. there was a nhtsa recall, # 99v024000, regarding the headlight switch. the vehicle was not included in the recall due to the vin. | |||
| 04/28/2002 | 1 | ||
| While driving at night, the headlights went out. dealer determined the headlight switch burned out.*ak *cb *jb | |||
| 05/25/2001 | 1 | 06/01/1996 | |
| Headlights failed at night. cycled switch several times before lights came back on. repaired at dealer on 06/08/01. dealer found some burnt wires from headlight switch, thru plastic multipin connector, to firewall. 1st report to dodge via internet on 06/05/01, ref # 8723405; ticket # 369336. dodge response on 06/06/01, take it to the dealer for evaluation. on 06/08/01 dealer had to replace headlight switch and some of the wiring harness because of burnt wires, going thru connector to the dash. on 06/11/01, re-notified dodge via internet of this potential safety/fire issue since no fuse opened to prevent the burnt wires under the dash. and the fact that dealer personnel (mechanic) said they've seen this before but have had no problems with replacement switches. no response from dodge. called 1-800 number 06/26/01 and was told there was only one message in file, customer service rep (derek) would not acknowledge 2nd msg inspite of fact i have automated response confirmation of receipt on 6/11/01. derek? said if its part of a recall, i am contacting the wrong department and if its not part of recall, its a five year old truck, its customer responsibility. there is a recall (#819) on dodge ram 3500 for exactly the failure i experienced (eg overheat headlamp switch can cause fire and or cause sudden loss of headlights...). cust omer service rep (derek) refused to discuss further...its a customer responsibility..help | |||
| 06/01/1996 | 1 | 06/01/1996 | |
| When switching from high beam to low beam headlights go out completely. after wiggling switch lights come back on. problem has been mentioned to the dealership. headlight switch was replaced 6 months ago under recall. *ak the problem reoccured recently. the customer thinks the dimmer switch failure is the cause not off-on switch. *yh | |||
| EXTERIOR LIGHTING - TURN SIGNAL - SWITCH | |||
| 11/24/1999 | 6 | 10/01/1995 | |
| The headlights went out when i changed to high beams. i pulled off and cycle the switch and they came on. this happened several times. i continued to drive with just the low beams. the dealer said the multi-function switch had failed and replaced it. i think it is only fortunate that an accident did not occur. | |||