Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||||||||||||
06E024000 | K&N ENGINEERING, INC. | E (Equipment) | 44386 | 04/20/2006 | MFR | CHRYSLER GROUP LLC | 03/15/2006 | 03/17/2006 | ||||||||
Defect Summary | Certain replacement k&n fuel performance kits, p/nos. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, and 57-1530. also, a small percentage of these kits were sold under the mopar performance parts brand name (p/nos. p5007069 and p5007070). all kits were manufactured from april 20, 1999, through september 23, 2004. these assemblies were manufactured as replacement equipment for certain dodge pickup trucks and suvs. a small piece of material from the tube wall could be sucked into the engine throttle body, which could cause the throttle to become jammed in the open position. | |||||||||||||||
Consequence Summary | A jammed open throttle could cause unintended acceleration of the vehicle, possibly resulting in a crash or increased stoping distances when braking. | |||||||||||||||
Corrective Summary | K&n will provide owners with a free repair kit along with repair instructions. the recall began on april 20, 2006. | |||||||||||||||
Notes | This recall only pertains to replacement k&n fuel performance kits and has no relation to any original equipment installed on dodge vehicles manufactured by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
05002 | 04/28/2005 | 10015075 | New water pump for 3.7l engine - no longer common with 4.7l. advanced service information #05-002. *tt | 05/17/2005 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
07 | 06/01/2005 | 10016905 | Emissions recall e07-canister purge hoses. the canister purge hoses on about 7,800 of the above vehicles may develop cracks over time and release evaporative hydrocarbon (hc) which could exceed federal emission standards. *sc | 10/14/2005 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
06/04/2003 | 65000 | ||
Tl- the contact owns a 2002 dodge ram 2500. =the contact was driving approximately 70 mph when the vehicle experienced an abnormal reduction in engine power. the vehicle was turned off and the battery cables were disconnected. after waiting ten minutes, the battery cables were reconnected and the vehicle resumed as normal. the erratic failure recurred fifteen times. the vehicle had not been diagnosed or repaired. the manufacturer was not notified of the problem. the approximate failure mileage was 65,000. kmj | |||
06/04/2003 | 65000 | ||
Tl-the contact owns a 2002 dodge ram 2500. while the contact was driving approximately 70 mph, suddenly there was a complete loss of the engine power. the ignition was turned off and the battery cables were disconnected. after waiting ten minutes, the battery cables were reconnected and the vehicle resumed as normal. the erratic failure occurred fifteen times. the vehicle had not been diagnosed or repaired. the manufacturer was not notified of the problem. the approximate failure mileage was 65,000. js | |||
07/29/2009 | 69000 | 1 | |
My 2002 dodge ram 2500 is having problems with its vp-44 engine pump. it gets a dead pedal and in traffic it suddenly stops. there isn't anything you can do but pull over until it comes back on. this isn't a good thing in heavy traffic, especially on a 4 line road in the left lane. this almost caused an accident with a speeding semi (he almost rear ended me!). *tr | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
01/01/1901 | 1 | ||
2002 dodge 2500 has problems with the diesel flow fuel problem. *ts since 48,500 miles the engine periodically loses power and drops to 1500 rpm's. this failure mostly occurs with a load on board and when in traffic. the engine regains full power within 2-5 miles. a computer scan at a local repair facility indicated a possible problem in the injector timing circuit or in the pump system. *nm | |||
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||
04/12/2002 | 1 | 04/10/2002 | |
Consumer states that the crankcase oil fumes enter the cab at idle or slow speed when the air conditioner is set on outside air settings, when the air conditioner is set on recirculated or cab air only, this condition does not happen. *slc | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||
07/10/2004 | 50000 | 15 | 06/27/2004 |
Dt: 2002 dodge ram 2500 hd quad cab 4 wheel drive slt. the truck has been in the repair shop at least 15 times for not having any power. this happened mainly when towing a trailer. prior to purchasing the truck the dealer replaced the fuel injection pump and fuel pump. they have been replaced 3 times last year. the dealer said that transmission was not programmed for the size tires that were on the vehicle. also, turbo- charger was bad, and they replaced it, but, it did not work. took back vehicle o dealer, and they replaced all parts again. the last time that consumer took vehicle to dealer, the dealer stated there was nothing else to be done. this vehicle has a 5.9 liter ho cummings engine, turbo diesel, manual transmission. the truck has no power when pulling a trailer.*ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
07/28/2005 | 45276 | 1 | 01/25/2002 |
Canister purge hoses and vapor harness hoses have cracked and dry rotted. there is an emissions recall listed on your web site for this problem but the dealer is saying there is no recall listed thru daimler chrysler for my specific vehicle. *nm |