Fleetwood Bounder 2001
Model Bounder made in 2001 by Fleetwood got 20 consumer complains there are 5 recalls as well as 1 service bulletin. Consumer complaints with reference, among others things, to electrical system, engine and engine cooling and equipment. Technical service bulletines regarding engine and engine cooling. There were some recalls concerningequipment, service brakes, air and service brakes, hydraulic.
Model 2001
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
08V240000 | FLEETWOOD ENTERPRISES, INC. | from 12/28/2000 to 05/25/2001 | V (Vehicle) | 1263 | 09/25/2008 | MFR | FLEETWOOD ENTERPRISES, INC. | 06/03/2008 | 06/03/2008 | |||||||
Defect Summary | Fleetwood is recalling certain class a gas and diesel motor homes, class c motor homes, conventional and fifth wheel travel trailers equipped with norcold refrigerators. a low cycle fatigue failure in the section of the cooling unit which generates the refrigerant could allow the liquid solution to slowly leak. | |||||||||||||||
Consequence Summary | Extended operation of a leaking cooling unit could lead to a fire from gas which might escape. | |||||||||||||||
Corrective Summary | Fleetwood is working with norcold to repair these refrigerators. norcold will provide thermal switch kits to owners along with the necessary forms and instructions. the recall is expected to begin during june 2008. owners may contact norcold at 1-800-767-9101 or fleetwood at 1-800-509-3418. | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
03V452000 | FLEETWOOD ENTERPRISES, INC. | V (Vehicle) | 60877 | ODI | FLEETWOOD ENTERPRISES, INC. | 11/04/2003 | 11/14/2003 | |||||||||
Defect Summary | On certain travel trailers equipped with samsung microwave ovens, these ovens were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a jumper or jump wire. this may cause the oven to activate without pressing any key pads. | |||||||||||||||
Consequence Summary | An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire. | |||||||||||||||
Corrective Summary | Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or fleetwood at 1-800-629-8454. | |||||||||||||||
Notes | Customers can also contact the national highway traffic safety administration | |||||||||||||||
07V120000 | FLEETWOOD ENTERPRISES, INC. | from 04/01/1997 to 07/31/2003 | V (Vehicle) | 167096 | 05/10/2007 | MFR | FLEETWOOD ENTERPRISES, INC. | 03/19/2007 | 03/20/2007 | |||||||
Defect Summary | Certain motor homes and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. | |||||||||||||||
Consequence Summary | Release of coolant under certain conditions could ignite and result in a fire. | |||||||||||||||
Corrective Summary | Fleetwood will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216. | |||||||||||||||
Notes | Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
SERVICE BRAKES, AIR | ||||||||||||||||
09V198000 | FLEETWOOD ENTERPRISES, INC. | V (Vehicle) | 509 | 05/01/2009 | ODI | FLEETWOOD ENTERPRISES, INC. | 06/02/2009 | 06/01/2009 | ||||||||
Defect Summary | Fleetwood is recalling 509 my 2001-2008 class a motor homes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. when combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. this can result in abnormal heat generation at the wheel end causing brake drag. the driver would normally have warning of the brake drag if undetected by the driver. | |||||||||||||||
Consequence Summary | The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash. | |||||||||||||||
Corrective Summary | Dealers will inspect and replace the necessary components free of charge. workhorse is handling the remedy for this campaign please see 09v-110. the manufacturer has not yet provided an owner notification schedule. owners may contact workhorse at 1-877-246-7731. workhorse will conduct the owner and dealer notification. | |||||||||||||||
Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE WARNING | ||||||||||||||||
03V066000 | FLEETWOOD ENTERPRISES, INC. | from 09/17/1999 to 08/30/2001 | V (Vehicle) | 11194 | 04/07/2003 | MFR | FLEETWOOD ENTERPRISES, INC. | 03/04/2003 | 03/17/2003 | 571 | 105 S5.3 | |||||
Defect Summary | Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, hydraulic and electric brake systems. the brake system warning indicator may not function as required by standard. | |||||||||||||||
Consequence Summary | In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the brake system warning indicator. | |||||||||||||||
Corrective Summary | Dealers will repair these vehicles. owner notification began april 7, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact fleetwood at 1-800-445-3307. | |||||||||||||||
Notes | Fleetwood recall no. 30312.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||||
0251 | 12/01/2004 | 10014720 | Air intake baffle procedure/installation which may be susceptible to stalling or sputtering during heavy rains or when water is sprayed directly at the front end. the check engine light may illuminate also. various models including fleet | 05/06/2005 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
01/13/2001 | 44 | 06/13/2001 | |
Oil leaked onto brakes, causing erratic braking, dealer repaired vehicle. on numerous occasions while driving vehicle will stall, causing loss of vehicle control. dealer has inspected and repaired vehicle. *akthe shower was very inconvenient. the walls were not fastened to the studs and the floor was not fastened to the frame. the tv antenna controls fell out. the 30 amp system can not operate the coach in a safe manner. the shore cord melted, none of the ground wires were tight. the rubber roof came off. *yh | |||
ELECTRICAL SYSTEM - WIRING | |||
06/01/2002 | 2 | 06/13/2001 | |
Short cord melted due to loose ground wires. dealer has replaced short cord. *ak this vehicle has had 156 repairs done so far and there are still 27 unresolved issues. the shower was installed upside down, the front air/heat was controlled by the back controls and vice versa. the 30 amp system doesn't support the coach system, the shore cord melted, none of the ground wires were tight. the walls were not fastened to the studs, the floor was not fastened to the frame, the tv antenna controls fell out and the washer had one of four braces left in. the roof came off, the absence of sealer allowed rain to seep inside of the vehicle, there are engine problems, the chassis has air leaks and the wheel seal needed repairing. *jg | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
01/13/2001 | 44 | 06/13/2001 | |
Oil leaked onto brakes, causing erratic braking, dealer repaired vehicle. on numerous occasions while driving vehicle will stall, causing loss of vehicle control. dealer has inspected and repaired vehicle. *akthe shower was very inconvenient. the walls were not fastened to the studs and the floor was not fastened to the frame. the tv antenna controls fell out. the 30 amp system can not operate the coach in a safe manner. the shore cord melted, none of the ground wires were tight. the rubber roof came off. *yh | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
01/13/2001 | 44 | 06/13/2001 | |
Oil leaked onto brakes, causing erratic braking, dealer repaired vehicle. on numerous occasions while driving vehicle will stall, causing loss of vehicle control. dealer has inspected and repaired vehicle. *akthe shower was very inconvenient. the walls were not fastened to the studs and the floor was not fastened to the frame. the tv antenna controls fell out. the 30 amp system can not operate the coach in a safe manner. the shore cord melted, none of the ground wires were tight. the rubber roof came off. *yh | |||
On numerous occasions while driving vehicle will stall out and die, causing loss of vehicle control. dealer has inspected and repaired vehicle. please provide further information.*ak | |||
06/01/2002 | 2 | 06/13/2001 | |
Short cord melted due to loose ground wires. dealer has replaced short cord. *ak this vehicle has had 156 repairs done so far and there are still 27 unresolved issues. the shower was installed upside down, the front air/heat was controlled by the back controls and vice versa. the 30 amp system doesn't support the coach system, the shore cord melted, none of the ground wires were tight. the walls were not fastened to the studs, the floor was not fastened to the frame, the tv antenna controls fell out and the washer had one of four braces left in. the roof came off, the absence of sealer allowed rain to seep inside of the vehicle, there are engine problems, the chassis has air leaks and the wheel seal needed repairing. *jg | |||
EQUIPMENT | |||
06/01/2002 | 2 | 06/13/2001 | |
Short cord melted due to loose ground wires. dealer has replaced short cord. *ak this vehicle has had 156 repairs done so far and there are still 27 unresolved issues. the shower was installed upside down, the front air/heat was controlled by the back controls and vice versa. the 30 amp system doesn't support the coach system, the shore cord melted, none of the ground wires were tight. the walls were not fastened to the studs, the floor was not fastened to the frame, the tv antenna controls fell out and the washer had one of four braces left in. the roof came off, the absence of sealer allowed rain to seep inside of the vehicle, there are engine problems, the chassis has air leaks and the wheel seal needed repairing. *jg | |||
01/13/2001 | 44 | 06/13/2001 | |
Oil leaked onto brakes, causing erratic braking, dealer repaired vehicle. on numerous occasions while driving vehicle will stall, causing loss of vehicle control. dealer has inspected and repaired vehicle. *akthe shower was very inconvenient. the walls were not fastened to the studs and the floor was not fastened to the frame. the tv antenna controls fell out. the 30 amp system can not operate the coach in a safe manner. the shore cord melted, none of the ground wires were tight. the rubber roof came off. *yh | |||
EQUIPMENT - ELECTRICAL - RADIO/TAPE DECK/CD ETC. | |||
01/13/2001 | 44 | 06/13/2001 | |
Oil leaked onto brakes, causing erratic braking, dealer repaired vehicle. on numerous occasions while driving vehicle will stall, causing loss of vehicle control. dealer has inspected and repaired vehicle. *akthe shower was very inconvenient. the walls were not fastened to the studs and the floor was not fastened to the frame. the tv antenna controls fell out. the 30 amp system can not operate the coach in a safe manner. the shore cord melted, none of the ground wires were tight. the rubber roof came off. *yh | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
07/12/2003 | 12127 | 2 | 11/19/2001 |
The rear end around the fuel tank, disintegrated and separated. dealership had been contacted. serial #f739s1715341. multiple defects had been found. there were leaks, faulty door latches, a cracked dashboard, window frame fell off the wall. the dealer stated the warranty had expired. *ak the rv also had excessive rust *cb *jb | |||
OTHER | |||
01/13/2001 | 44 | 06/13/2001 | |
Oil leaked onto brakes, causing erratic braking, dealer repaired vehicle. on numerous occasions while driving vehicle will stall, causing loss of vehicle control. dealer has inspected and repaired vehicle. *akthe shower was very inconvenient. the walls were not fastened to the studs and the floor was not fastened to the frame. the tv antenna controls fell out. the 30 amp system can not operate the coach in a safe manner. the shore cord melted, none of the ground wires were tight. the rubber roof came off. *yh | |||
SERVICE BRAKES, AIR | |||
01/13/2001 | 44 | 06/13/2001 | |
Oil leaked onto brakes, causing erratic braking, dealer repaired vehicle. on numerous occasions while driving vehicle will stall, causing loss of vehicle control. dealer has inspected and repaired vehicle. *akthe shower was very inconvenient. the walls were not fastened to the studs and the floor was not fastened to the frame. the tv antenna controls fell out. the 30 amp system can not operate the coach in a safe manner. the shore cord melted, none of the ground wires were tight. the rubber roof came off. *yh | |||
STEERING - LINKAGES - KNUCKLE - SPINDLE - ARM | |||
07/05/2001 | 1 | 07/01/2001 | |
Motoring at 50 mph heard a hard slam on left side front,pulled me across center lane was able to stop safely pulled into a driveway called dealership.mechanic said we averted what could have been a fatal disaster.afraid to accept in repaired condition without factory rep on hand during repairs. *ak | |||
STRUCTURE | |||
07/12/2003 | 12127 | 2 | 11/19/2001 |
The rear end around the fuel tank, disintegrated and separated. dealership had been contacted. serial #f739s1715341. multiple defects had been found. there were leaks, faulty door latches, a cracked dashboard, window frame fell off the wall. the dealer stated the warranty had expired. *ak the rv also had excessive rust *cb *jb | |||
06/01/2002 | 2 | 06/13/2001 | |
Short cord melted due to loose ground wires. dealer has replaced short cord. *ak this vehicle has had 156 repairs done so far and there are still 27 unresolved issues. the shower was installed upside down, the front air/heat was controlled by the back controls and vice versa. the 30 amp system doesn't support the coach system, the shore cord melted, none of the ground wires were tight. the walls were not fastened to the studs, the floor was not fastened to the frame, the tv antenna controls fell out and the washer had one of four braces left in. the roof came off, the absence of sealer allowed rain to seep inside of the vehicle, there are engine problems, the chassis has air leaks and the wheel seal needed repairing. *jg | |||
STRUCTURE - BODY | |||
01/13/2001 | 44 | 06/13/2001 | |
Oil leaked onto brakes, causing erratic braking, dealer repaired vehicle. on numerous occasions while driving vehicle will stall, causing loss of vehicle control. dealer has inspected and repaired vehicle. *akthe shower was very inconvenient. the walls were not fastened to the studs and the floor was not fastened to the frame. the tv antenna controls fell out. the 30 amp system can not operate the coach in a safe manner. the shore cord melted, none of the ground wires were tight. the rubber roof came off. *yh | |||
UNKNOWN OR OTHER | |||
04/22/2008 | |||
Refrigerator failed to cool on start up. found cooling unit had lost charge. chance of fire with these units... a recall was put on these mounths ago but i w es not aware of it , i did not recieve one recall no. 06e-076 i got a recall after i called dometic. as stated in the recall , item # 7 they refuse to help, keep giving me the run around... | |||
VEHICLE SPEED CONTROL | |||
01/01/1901 | 1 | ||
2001 fleetwood bounder motorhome with speed control recall. consumer states that the dealer unplugged the speed control switch. he was told parts would be in, in january. he was informed in march parts still weren't available. *kb | |||
09/15/2007 | 0 | 0 | 09/08/2001 |
Tl*the contact owns a 2001 fleetwood bounder rv. he received a ford recall notice for the vehicle speed control. none of the dealers in the area have the part. he spoke with a dealer today and they advised him that when ever they order the parts ford continually stated that they are not available. the dealer didn't give him a date of availability. the rv does not have antilock brakes or an engine size. the current mileage was 31,000. there are no failures at this time. updated 01-29-08. *kb | |||
WHEELS | |||
06/01/2002 | 2 | 06/13/2001 | |
Short cord melted due to loose ground wires. dealer has replaced short cord. *ak this vehicle has had 156 repairs done so far and there are still 27 unresolved issues. the shower was installed upside down, the front air/heat was controlled by the back controls and vice versa. the 30 amp system doesn't support the coach system, the shore cord melted, none of the ground wires were tight. the walls were not fastened to the studs, the floor was not fastened to the frame, the tv antenna controls fell out and the washer had one of four braces left in. the roof came off, the absence of sealer allowed rain to seep inside of the vehicle, there are engine problems, the chassis has air leaks and the wheel seal needed repairing. *jg |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
IL | ATKINSON | SHAVNARH CREEK RV | ||
MI | DEARBORN | FRANK LIGON FORD | ||
MO | KANSAS CITY | 64129 | NAYLOR RV INC | 816-721-0065 |