Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| EQUIPMENT - MECHANICAL - JACKS | ||||||||||||||||
| 03V344000 | FLEETWOOD ENTERPRISES, INC. | from 09/06/2002 to 07/22/2003 | V (Vehicle) | 1100 | 10/03/2003 | MFR | FLEETWOOD ENTERPRISES, INC. | 09/16/2003 | 09/26/2003 | |||||||
| Defect Summary | On certain motorhomes built on workhorse chassis, the hydraulic hose operating the leveling jack system was routed so it places the hose too close to the engine exhaust. the hot exhaust can cause the hydraulic hose to melt or abrade, releasing hydraulic fluid. | |||||||||||||||
| Consequence Summary | If the hydraulic fluid should ignite by an exhaust gas recirculating tube or other heat source, this could cause a fire. | |||||||||||||||
| Corrective Summary | Dealers will inspect and replace damaged hoses and relocate the affected hydraulic lines. owner notification is expected to begin october 3, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact fleetwood at 1-800-322-8216. | |||||||||||||||
| Notes | Fleetwood recall no. 30908.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
| 04V087000 | FLEETWOOD ENTERPRISES, INC. | from 05/07/2003 to 01/23/2004 | V (Vehicle) | 735 | ODI | FLEETWOOD ENTERPRISES, INC. | 02/18/2004 | 03/03/2004 | ||||||||
| Defect Summary | On certain motor homes equipped with polar mach and polar cub air conditioners, the solar panel rubber well nuts could fracture the plastic shroud in the immediate area of the attachment hole. | |||||||||||||||
| Consequence Summary | The rubber well nuts could pull out of the plastic shroud, causing the solar panel to leave the top of the motor home, and increasing the risk of a road hazard or a crash. | |||||||||||||||
| Corrective Summary | Airxcel will reinforce the solar panels with metal mounting brackets free of charge. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact airxcel at 719-676-2326 or fleetwood at 1-800-322-8216. | |||||||||||||||
| Notes | Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
| 08V320000 | FLEETWOOD ENTERPRISES, INC. | from 04/01/2003 to 11/30/2006 | V (Vehicle) | 70101 | 10/24/2008 | ODI | FLEETWOOD ENTERPRISES, INC. | 07/15/2008 | 07/15/2008 | |||||||
| Defect Summary | Fleetwood is recalling 70,101 my 2003-2007 southwind, pace arrow, bounder, flair, storm, fiesta, terra gas class a motor homes; bounder, discovery, providence, excursion, expedition, revolution, american eagle, american heritage, american tradition diesel class a motor homes; jamboree tioga class c motor homes; and prowler, wilderness, terry, mallard, pioneer, pride and triumph conventional and fifth wheel travel trailers equipped with a two-door refrigerators manufactured by the dometic corporation. the refrigerator may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. | |||||||||||||||
| Consequence Summary | If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire. | |||||||||||||||
| Corrective Summary | Fleetwood is working with dometic to repair these refrigerators (please see 08e032). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
| 03V452000 | FLEETWOOD ENTERPRISES, INC. | V (Vehicle) | 60877 | ODI | FLEETWOOD ENTERPRISES, INC. | 11/04/2003 | 11/14/2003 | |||||||||
| Defect Summary | On certain travel trailers equipped with samsung microwave ovens, these ovens were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a jumper or jump wire. this may cause the oven to activate without pressing any key pads. | |||||||||||||||
| Consequence Summary | An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire. | |||||||||||||||
| Corrective Summary | Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or fleetwood at 1-800-629-8454. | |||||||||||||||
| Notes | Customers can also contact the national highway traffic safety administration | |||||||||||||||
| 07V120000 | FLEETWOOD ENTERPRISES, INC. | from 04/01/1997 to 07/31/2003 | V (Vehicle) | 167096 | 05/10/2007 | MFR | FLEETWOOD ENTERPRISES, INC. | 03/19/2007 | 03/20/2007 | |||||||
| Defect Summary | Certain motor homes and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. | |||||||||||||||
| Consequence Summary | Release of coolant under certain conditions could ignite and result in a fire. | |||||||||||||||
| Corrective Summary | Fleetwood will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216. | |||||||||||||||
| Notes | Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||
| PE06005 | FLEETWOOD ENTERPRISES, INC. | 01/20/2006 | 05/02/2006 | INADVERTENT SLIDE-OUT EXTENSION MOVEMENT | ||
| This investigation was opened based on odi's receipt of a congressional letter on behalf of a constituent.the constituent reported incidents where the slide out room of his motor home would inadvertently move (extend) during highway use.odi was concerned that a fully extended slide out would degrade the vehicle's dynamic handling characteristics and/or possibly impact an object or another vehicle, resulting in a crash.odi contacted fleetwood and discovered that slide out rooms were installed in motor homes, travel trailers and folding trailers. as part of the investigation odi visited a rv show and the fleetwood paxinos plant to examine slide outs in various new make and model vehicles and gain an understanding of how the systems work.during the investigation odi learned that there are two methods used to extend slide out rooms.some manufacturers use hydraulic systems and others, such as fleetwood, use an electric motor. (continued on page 2) | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| EQUIPMENT | |||
| 05/25/2010 | 1 | 07/01/2004 | |
| 2004 fleetwood bounder 34 f. consumer requests reimbursement for refrigerator failure issues*tgw the consumer stated the norcold refrigerator stopped cooling and all of the refrigerant leaked out due to fatigue failure.. the consumer was informed his rv was not covered by the norcold recall, because his model was not on the list. *jb | |||
| EQUIPMENT - RECREATIONAL VEHICLE | |||
| 05/25/2010 | 1 | 07/01/2004 | |
| 2004 fleetwood bounder 34 f. consumer requests reimbursement for refrigerator failure issues*tgw the consumer stated the norcold refrigerator stopped cooling and all of the refrigerant leaked out due to fatigue failure.. the consumer was informed his rv was not covered by the norcold recall, because his model was not on the list. *jb | |||