Fleetwood Discovery 1998
Model Discovery made in 1998 by Fleetwood got 20 consumer complains there are 2 recalls as well as 1 service bulletin. Consumer complaints with reference, among others things, to electrical system, equipment and exterior lighting. Technical service bulletines regarding fuel system, gasoline. There were some recalls concerningequipment, steering.
Model 1998
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
07V120000 | FLEETWOOD ENTERPRISES, INC. | from 04/01/1997 to 07/31/2003 | V (Vehicle) | 167096 | 05/10/2007 | MFR | FLEETWOOD ENTERPRISES, INC. | 03/19/2007 | 03/20/2007 | |||||||
Defect Summary | Certain motor homes and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present. | |||||||||||||||
Consequence Summary | Release of coolant under certain conditions could ignite and result in a fire. | |||||||||||||||
Corrective Summary | Fleetwood will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or fleetwood at 1-800-322-8216. | |||||||||||||||
Notes | Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
STEERING - HYDRAULIC POWER ASSIST - HOSE, PIPING, AND CONNECTIONS | ||||||||||||||||
00V204000 | FLEETWOOD ENT., INC. | from 06/01/1996 to 08/31/1999 | V (Vehicle) | 4967 | 08/28/2000 | MFR | FLEETWOOD ENTERPRISES, INC. | 07/27/2000 | 07/28/2000 | |||||||
Defect Summary | Vehicle description: motor homes. the power steering gear box hydraulic lines are routed too close to a sharp edge. this can cause the lines to rupture and result in a hydraulic fluid leak. | |||||||||||||||
Consequence Summary | This fluid leakage can cause loss of the power steering assist feature. | |||||||||||||||
Corrective Summary | Dealers will inspect, replace or repair damaged hoses as necessary, and relocate the affected hydraulic lines. | |||||||||||||||
Notes | Owner notification began august 28, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact fleetwood at 1-800-322-8216.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||||
04212008 | 04/21/2008 | 10025322 | Consumer maintenance advisory, generator fuel lines. fleetwood motor home owners. csc was received. *pe | 07/29/2008 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
01/24/2002 | 10/06/1997 | ||
No brake light, check unit found a bad diode in the brake light system wiring. had to remove dash cover and instrument panel to access wire harness. found diode in harness at lower steering column area. remove diode and install new harness assemble and recheck operation all ok at this time. | |||
EQUIPMENT | |||
02/05/2009 | 46000 | 1 | |
Dometic recall refrigerator ref.#26168178 mod: rm3862 ser: 80800266 gas leak/ ammonia leak/ dometic recommends not using as there is a fire / death by gas leaking but will not fix. *tr | |||
EQUIPMENT - RECREATIONAL VEHICLE | |||
Burner on magic chief stove model number llz8502abd, overheated because adjuster knob failed to operate. burner could not be either turned off or turned down, cause unknown. manufacturer has been notified. please give any further details. *ak | |||
03/19/2001 | 1 | 11/01/1999 | |
Front center burner on magic cheff stove got too hot valve that controlled the gas could not be controled. got so hot that it melted plastic on t knob. had to be turned off with a pair of plyers. consumer had replaced valve on his own.*ak | |||
05/25/1999 | |||
Problem with magic chef stove: whenever front burner is used the heat causes the valve to stick and unable to turn off. consumer has to leave vehicle and turn off main gas valve to let it cool off before inside valve can be turned off. dealer notified. *ml | |||
09/15/1999 | |||
When using the magic chief stove front burner heat causes the turn off valve to stick, and consumer is unable to turn off the gas. when this occurs, the main turn off valve, located outside the vehicle, must be turned off until inside valve cools off, and then turns of the valve. manufacturer notified. *ak | |||
When using the stove burners get very hot. the stove will not turn off. consumer has contacted the manufacturer. please provide any further details*ak. | |||
Largest of the three burners on the magic chef ranger is misaligned which heats up the stove surface, causing the knob to become very hot. manufacturer has been notifed about the problem. problem has not been corrected. please provide any further information. *ak | |||
12/01/1998 | 1 | 09/03/1998 | |
Reported a defect conerning front high burner stove manufactured by maytag model #clz8502bd.; whenever a pot is used approximately 10 inches or more, the heat from the pot causes the valve to stick, andconsumer is unable to turn burner off until it cools off. this condition could lead to a possible explosion. can nhtsa help in this matter. *ak not able to shut off the burner 100%, is allowing propane to leak into the motorhome. potential safety hazard. jn | |||
EXTERIOR LIGHTING - HEADLIGHTS | |||
2 | 08/01/1997 | ||
While driving at night, headlights are malfunctioning, causing a decrease in lighting on road for oncoming traffic. dealer has been notified.*ak consumer states that fleetwood purchased a headlight unit used on ford pickups, the lexon lez cover has clouded over blocking light intensity, consumer feels the lights were flawed and should be recalled. *slc | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
Vehicle leaks fuel, due to faulty hose/ fuel pump. dealer noted problem with diesel fuel system. problem has occurred three different times. cause of leak cannot be found. leaking in engine compartment housing. *ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
Vehicle leaks fuel, due to faulty hose/ fuel pump. dealer noted problem with diesel fuel system. problem has occurred three different times. cause of leak cannot be found. leaking in engine compartment housing. *ak | |||
FUEL SYSTEM, OTHER | |||
02/05/2009 | 46000 | 1 | |
Dometic recall refrigerator ref.#26168178 mod: rm3862 ser: 80800266 gas leak/ ammonia leak/ dometic recommends not using as there is a fire / death by gas leaking but will not fix. *tr | |||
STEERING - HYDRAULIC POWER ASSIST - HOSE, PIPING, AND CONNECTIONS | |||
03/19/2005 | 1 | 07/28/1998 | |
1998 discovery fleetwood motorhome power steering hose failed. *mr the consumer experienced what is explained in recall campaign# 00v204000. the hose ruptured. the dealer suggested that the vehicle was out of warranty and they would do nothing to remedy the problem. the consumer felt that the initial repair was not completed properly. *sc *jb | |||
STRUCTURE - BODY - DOOR | |||
12/01/1997 | 3 | 12/01/1997 | |
Door designed whereas a vaccum is created outside the entry door due to wind flow. when traveling, high pressure sucks the door outward. door vibrates on top inside half and flutters. if door is accidently opened or latch mechenism fails, the door is sucked outward with tremendious force creating great danger to passengers. door has been repaced 3 times, modified twice. manuf has added modifications to reduce wind noise and flutter but the outward sucking pressure remains. great danger exists. manuf unable to correct safety defects. | |||
STRUCTURE - FRAME AND MEMBERS | |||
06/01/2003 | 1 | ||
1998 discovery motorhome nar 06/26/2003 *mr consumer received a recall to have the welding done on the frame to the sub flooring. *ph *cb | |||
TIRES | |||
10/15/2003 | 1 | ||
While driving at 60 mph and with no warning right front tire sidewall separated, causing the tire to blow out. consumer had to pull over. michelin, xrv, size 235/80r222.5, dot#unknown . *ak | |||
05/19/2001 | 15 | 04/01/1998 | |
There are approx 200 members in our rv motorhome club. at least 25 have experienced blowouts. michelin blames this on incorrect pressure or you must have hit something. but none of this is true. all of the tire failures are a zipper type blowout, and almost all of the tires were produced prior to may, 1998 when michelin alledgedly had a redesign to the tire sidewall. many, many other people that do not belong to our club report similar tire failures. it appears that this michelin tire problem is affecting a much higher percentage than the recent firestone passenger car tire fiasco. most of us owners would really like to have this looked into before any more people get hurt or killed. please help us! the problem appears to be the tires, not the particular brand of rv motorhome. *ak (tiresize: 23580r22.5) | |||
02/23/2001 | 3 | 11/01/1997 | |
This was the third tire failure in the past year. on each occasion the sidewall blew out, and at the end of the blowout location, the steel belt was very rusty. in all 3 cases michelin would not examine the tire. on the first blowout they had none of these tiresd in stock in the usa and i had to replace the two front tires with the xze style. the rated pressure on the tire is only 90psi, instead of the 100psi on the xrv style. michelin advised me to add 10 more ppsi to these tires exceeding the recommended pressure, so i could get above the 60mph rating of these tires. they only agreed to go 50% cost on replacement of the 4 other xrv tires and refused to replace the substitute tires that were put on earlier. i feel michelin has made some defective tires, and will refuse to admit it, to me or the chassis manufacture. michelin keeps claiming the vehicle is overweight or the tires are under pressure. these 2 factors do not occur. i sent my weight certification into freightliner, which was over 2000 lbs. under and i maintain tire pressure at 100psi. their latest excuse on the failure was that maybe the transporter who transported the vehicle from the manufacture to the dealer ran the tires low for a smoother ride. i find that hard to beleive, as the tire pressure was correct on me taking delivery. i think michelin is always finding excuses instead of admitting fault.*ak (tiresize: 235r8022.5)( dot number: tire size: 235r8022.5 ) | |||
TIRES - TREAD/BELT | |||
03/15/2004 | 60000 | 1 | |
Steel belt rusted and as a result the front driver's side tire blewout while driving 65 mph . *ak *nm |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
FL | SEFFNER | 33584 | LAZY DAYS RV SUPERCENTER |