Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - WIRING | ||||||||||||||||
88V091000 | FORD MOTOR COMPANY | from 05/01/1985 to 03/01/1988 | V (Vehicle) | 60000 | 07/01/1988 | ODI | FORD MOTOR COMPANY | 06/06/1988 | 06/09/1988 | |||||||
Defect Summary | Vehicles equipped with trailer tow package have a trailer taillight relay assembly that contains wires of smaller gauge than the fuse link which protects the circuit. | |||||||||||||||
Consequence Summary | Should a short circuit occur in the wiring within therelay or if water intrusion occurs the smaller gauge wire in the relay willfunction as a fuse link and overheat. the possibility exists for a fire if thewires are exposed to combustible materials. | |||||||||||||||
Corrective Summary | Installation of a relay with wires of gauge adequate to protect the circuit. | |||||||||||||||
Notes | System: electrical.vehicle description: multi purpose vehicle van, equipped with optional trailertow package. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM | |||||
98246 | 12/07/1998 | 604059 | Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc | 03/16/1999 | |
ELECTRICAL SYSTEM - WIRING | |||||
99222 | 10/18/1999 | 6089681 | Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt | 02/11/2000 | |
96246 | 11/18/1996 | 50905 | Wiring - electrical diode identification and service replacements. *tw | 06/17/1997 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ELECTRICAL SYSTEM | ||||||
EA88033 | FORD MOTOR COMPANY | 05/11/1988 | 01/23/1989 | UNDER SEAT FIRES | 88V145000 | |
There is no summary currently available | ||||||
EA88030 | FORD MOTOR COMPANY | 04/19/1988 | 07/13/1988 | ELECTRICAL FIRES | 88V091000 | |
There is no summary currently available |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||
05/19/1999 | 1 | ||
Had service done on vehicle & replaced the old battery. was driving when smoke started under the hood. pulled over & parked. lifted hood & noticed fire under the hood. fire department called & put flames out. had indicated it was electrical wiring for the alternator. the insurance inspector checked vehicle out & indicated wires to alternator burned & totaled out vehicle. *ak | |||
05/01/1997 | |||
While parked, the alternator wire plug caught on fire. cause unknown . please provide details. *ak | |||
01/31/1996 | 0 | ||
While driving vehicle, fire would occur in alternator area. had taken to dealer; mechanic noticed wires had been replaced due to warning sticker found. but vehicle experiencing other problems. *ak | |||
08/12/1995 | 2 | ||
Vehicle fire caused by an alternator connector failure. *ak | |||
07/01/1993 | |||
Alternator caught fire, had replaced burned again. tt | |||
06/29/1994 | 1 | ||
Electrical short in alternator resulted in a fire. *ak | |||
ELECTRICAL SYSTEM - BATTERY - CABLES | |||
04/11/1996 | 1 | ||
Driving vehicle, smelled something burning, went into store, was informed by another customer vehicle was engulfed in flames. *ak consumer states vehicle would not start someeime battery cable was replaced.*jb | |||
ELECTRICAL SYSTEM - IGNITION | |||
1 | |||
Vehicle keeps stalling intermittently and without warning. consumer tried to restart vehicle, but smoke was coming out from underneath hood. *ak | |||
06/20/1997 | 1 | 06/01/1987 | |
Vehicle's ignition switch shorted out and caused steering column to catch fire spreading to the dashboard. *ak *slc | |||
ELECTRICAL SYSTEM - IGNITION - MODULE | |||
05/12/2000 | 5 | 11/01/1994 | |
We have had the control module replaced a minimum of 5 time (receipts on hand), each time the van stalls out while driving. this has caused many near crashes and much fustration only the alertness that the van stalls prevented any bodily harm. several ford dealerships deny any problem with the control module on this van and no recalls for this problem. the part has been replaced by the dealer. *ak | |||
08/31/1998 | 2 | ||
Accelerator makes squeaking sound & would stick . also, had to have seat belts replaced due to a malfunction. in addition, the emission light keeps coming on/the computer chip shorted out. *ak | |||
ELECTRICAL SYSTEM - IGNITION - SWITCH | |||
06/20/1997 | |||
While driving down the road, vehicle caught on fire in the ignition switch due to an electrical short. vehicle was totaled. *ak | |||
06/20/1997 | 1 | 06/01/1987 | |
Vehicle's ignition switch shorted out and caused steering column to catch fire spreading to the dashboard. *ak *slc | |||
10/29/1996 | |||
Electrical short in the ignition switch, causing the vehicle to catch on fire in the steering column (the vehicle was in the off position). *ak | |||
12/01/1995 | 1 | ||
Ignition switch fire. | |||
07/23/1996 | 1 | 09/01/1986 | |
The vehicle was parked for several hours and then went up in flames due to the ignition switch failure. *ak | |||
01/07/1996 | 7 | ||
Ignition switch shorted, causing wiring to melt. *dh | |||
07/23/1996 | |||
The vehicle was parked for several hours and then went up in flames due to the ignition switch. please describe. *ak | |||
07/14/1996 | |||
Electrical fire suspected to have started with ignition switch. *ak | |||
06/08/1995 | 8 | ||
Ignition switch fire. *sd | |||
05/03/1996 | |||
Electrical fire, source unknown, suspected to have started from ignition switch. *ak | |||
01/12/1995 | |||
Drove vehicle, smelled smoke, arrived home, light on snow sparkling electricity, soon afterwards flames engulfed entire front of vehicle. *ak | |||
04/11/1996 | 1 | ||
Driving vehicle, smelled something burning, went into store, was informed by another customer vehicle was engulfed in flames. *ak consumer states vehicle would not start someeime battery cable was replaced.*jb | |||
04/11/1996 | |||
Driving vehicle, smelled something burning, went into store, was informed by another customer vehicle was engulfed in flames. *ak | |||
ELECTRICAL SYSTEM - WIRING | |||
07/01/1996 | 1 | 12/20/1994 | |
Electrical wiring fire. | |||
10/22/1996 | |||
Vhicle parked in driveway and caught on fire. owner states it melted side of the house. *ak | |||
While driving van down street it all of a sudden it started to smoke, then came the fire-there was no warning. all the wiring burned. no injuries. *ak | |||
02/10/1995 | 0 | ||
Wiring to alternator shorted out due to being routed incorrectly up against engine compartment, causing alternator/digital speedometer to fail. | |||
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
08/31/2001 | |||
While driving smelled something burning. pulled over and lifted up hood. noticed flames coming from steering wheel wiring. before fire was extinguished, entire engine compartment was in flames. front of vehicle/ inside and outside was totaled.*ak | |||
03/27/2001 | |||
Vehicle was parked with engine off when it caught on fire. fire department determined fire started on left hand side of engine. vehicle was totaled. *ak | |||
02/16/2001 | 08/01/1987 | ||
Van caught fire and was a total loss. *ak | |||
1 | |||
Vehicle keeps stalling intermittently and without warning. consumer tried to restart vehicle, but smoke was coming out from underneath hood. *ak | |||
10/12/1999 | |||
When vehicle was stopped ,and the hood was opened, consumer noticed sparks and lots of smoke coming from under the hood. recall 88vo91000. *ak | |||
Parked vehicle at home and smelled smoke, consumer stated that it was a fire under the hood. the radiator hose burst and put out the fire. the wires were damaged. had vehcle towed to a mechanic, but it was too much damage for the mechanic to repair. consumer has contacted the dealer. *ak | |||
06/25/1996 | 1 | ||
Parked vehicle funny odor and vehicle caught on fire underneath the hood. *ak consumer had driven vehicle approximately 1 mile and smelled an odor, she thought her brakes were hot, consumer then pulled to the curb, while consumer was calling for a tow truck the vehicle caught fire, consumer contacted manufacturer but they were unwilling to help.*jb | |||
12/14/1995 | |||
While driving, vehicle caught on fire under the hood. please describe. *ak | |||
03/09/1996 | |||
While driving, vehicle caught fire in the wiring under the hood. please describe. *ak | |||
04/25/1994 | |||
Vehicle caught on fire in engine compartment right after being turned off and parked. tt | |||
ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
09/21/1996 | |||
Vehicle fire took place. the vehicle had been parked for about ten minutes. fire originated in the dash area. | |||
05/29/1996 | |||
Experienced fire underdash. please give more details. *ak | |||
07/28/1995 | |||
Under the dash compartment fire, through the steering while driving. tt |