Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
STEERING - HYDRAULIC POWER ASSIST - HOSE, PIPING, AND CONNECTIONS | |||||
BC1383950906 | 09/01/1995 | 45748 | Vehicle may exhibit a moan when turning - to correct this condition, replace the high pressure hose with a tuned hose. *tw | 04/25/1996 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
STEERING | ||||||
PE89092 | FORD MOTOR COMPANY | 02/23/1989 | 07/20/1989 | POWER STEERING LOCKING | ||
There is no summary currently available |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
STEERING - HYDRAULIC POWER ASSIST - HOSE, PIPING, AND CONNECTIONS | |||
Power steering fluid is leaking , transmission needed to be replaced and the blower for heat and air conditioner and the rack and pinion steering were bent . *ak | |||
STEERING - HYDRAULIC POWER ASSIST SYSTEM | |||
11/05/2001 | 2 | 01/01/1995 | |
The alternator failed short circuit. massive amounts of current passed from the battery through the alternator, which burst into flames. the fault caused the engine to stall due to lack of ignition and it was extremely difficult to steer and stop the vehicle as a result of loss of power steering and power brakes. smoke was pouring from the front of the vehicle. when i managed to stop and open the hood, the alternator, which was glowing red inside, burst into flames and set fire to cables and rubber hoses around it. i received burns to my hands trying to put the fire out. lucky for me another motorist stopped and he had an extinguisher. i have now had two fires of this type, one on each of my vehicles. yesterday i went to an alternator remanufacturing company here in monterrey, and the manger told me that he has had five engine bay fires in aerostar minivans in recent months. in the 'good old days' understand there was a fusible link between the alternator charging line and the battery + terminal. there should be a fuse in this circuit because it is connected directly to the battery!! not only is the fire a very serious problem, but there is a serious risk in the event of this fault, that the overload on the battery will cause it to burst, showering everything and everyone around it with hot sulfuric acid. please note although the vehicle was purchased in the usa i am currently living in monterrey, mexico. my phone is 01152-8-349-7152 and email is oldvinyl@hotmail.com. *ak | |||
STEERING - LINKAGES | |||
06/27/1995 | |||
Front tie rod disconneted, the other side detached 3 months later. *ak | |||
STEERING - LINKAGES - TIE ROD ASSEMBLY | |||
01/20/1998 | 2 | 05/24/1989 | |
Consumer reporting an ongoing problem with engine acceleration intermittently approximately six months. problem still occurring. dealer was notified and repairs/inspection was made continually, but the problem was never resolved. *ak consumer states vehicle is experiencing electrical problems and can smell something like wires burning, consumer states that the radio, fan blower, and dash lights go on and off, at times the radio will not work at all, battery failed and was replaced, low oil sensor failed and was replaced. vehicle has experienced several brake problems, brakes pulsate, master cylinder leak, proportioning valve leak, brakes grab, and were not stopping the vehicle. several engine related problems, consumer states the engine was noisy, oil was leaking from both sides of engine, the thermostat, gasket seal, main seal, rear main seal, pan gasket, belts, and other engine components have been replaced. the left door corroded and rusted. fuel filter was replaced, exhaust system was replaced, iac and throttle body were replaced, consumer states she would have to constantly keep foot on brake due to high rpms and loud whining, consumer states vehicle would accelerate suddenly if foot were off the brake, there were times when the brakes were not stopping vehicle. right front tire separated, causing steering wheel to wobble, front bearing needed packed, right rear axle was loose. differential carrier assembly was out, causing a loud ticking and thud noise. air conditioner was blowing hot air, the heater mode selector is slow to return from the vent when changed. outer tie rod ends needed replaced. *slc | |||
05/31/1996 | 2 | ||
Tie rod ends wore out and were replaced. *ak | |||
STEERING - RACK AND PINION | |||
Power steering fluid is leaking , transmission needed to be replaced and the blower for heat and air conditioner and the rack and pinion steering were bent . *ak | |||
STEERING - WHEEL AND HANDLE BAR | |||
01/09/1997 | |||
Experienced fire in steering column area. *ak |