Bulletins

BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
POWER TRAIN - AUTOMATIC TRANSMISSION
9915207/26/1999608431Information on the new flush and fill tool available through rotunda. *tt01/05/2001
001501/10/2000612203Information regarding the new transmission cooler flusher- service tip. *mjs06/06/2000
9816704/07/2000609736Transmission-e40d-no 2-3 upshift. some vehicles may exhibit a no 2-3 upshift condition. *ak04/07/2000
9816804/07/2000609737Transmission- e40d/4r100-1989-99-main controls, separator plates and separator plate gaskets usage chart. yd04/07/2000
9812301/19/1998605599Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62, 628, and / or 1728 may be stored in memory. *tt07/13/1999
988804/27/1998601238Information on a new transmission fluid usage chart. *yc07/10/1998
9751103/03/199751945Fluid- transmission fluid usage charts. *jd07/17/1997
BC432195070507/01/199545059Vehicles experiencing occasional harsh reverse engagement concerns. *tw11/01/1995
95111306/01/199545086Delayed forward engagement and/or heat stained forward clutch plates after installing center support service. *tw11/01/1995
95111206/01/199545085Revised design transmission rear case bushing. *tw11/01/1995
9521201/01/199539125Vehicles may exhibit a shift concern. *tw03/17/1995
94231811/01/199437741Transmission overheating, converter cover discoloration, clutches burned and burnt fluid *tw01/06/1995
94241511/01/199437765Upgrade kit for the e40d transmission. *tw01/06/1995
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES
0314807/21/200310003748New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt10/29/2003
00231011/13/2000616522Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt03/05/2001
003802/07/2000612343Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs06/07/2000
POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER
9624911/18/199650908Torque converter - leak test procedure - service tip. *tw06/17/1997
96261212/16/199650997Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw06/17/1997
POWER TRAIN - AXLE ASSEMBLY
98307402/27/1998607369Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers. *tt09/21/1999
1290506/01/1999606937Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt09/08/1999
BC013196010212/01/1995464384x4 front axles must use hypoid 4x4 gear oil p/n f1tz-19580-a & high temp 4x4 front axle & wheel bearing grease when servicing. it is not recommended to use heavier weight lubes in these front axles.04/25/1996
POWER TRAIN - CLUTCH ASSEMBLY
9672803/25/1996613350Service tip information regarding the reverse clutch piston and piston seal usage. *tt06/22/2000
POWER TRAIN - CLUTCH ASSEMBLY - PEDAL/LINKAGE
BC328797020602/06/199751883The clutch may be hard to depress due to dust/contamination entering the slave cylinder. *tw07/17/1997

Consumer Complaints

Fail datemilesoccurencesPurchase date
POWER TRAIN
08/04/1994
 Brake and transmission failure, four wheel drive malfunction, and an inaccurate speedometer.
POWER TRAIN - AUTOMATIC TRANSMISSION
05/01/2000103/01/2000
 Owned 5 bronco's and 3 out of the 5 all had a gas tank leakage problem. this should be investigated.
POWER TRAIN - AUTOMATIC TRANSMISSION - GEAR POSITION INDICATION (PRNDL)
09/21/1996102/01/1992
 Transmission gear shift slipped into reverse, causing accident/injury.
POWER TRAIN - MANUAL TRANSMISSION
02/04/2005107000309/09/2004
 About two months ago my transmission went out in my 92 ford bronco on my way to work with a co-worker with me, i was pulling up to a red light and went to downshift to first but it wasn't there, tried second not there either,i has to gimp me bronco home in third gear there by smoking and burning up the clutch,after getting the pos(piece of ?!@#$%) home i called a few shops and found this to be a common problem with all ford trucks using a mazda manual transmission,being a mechanic myself i proceeded to buy a rebuilt transmission and install it myself, now it is out again with the same problem no first or second. now until i bought this pos i have always been a ford man but now i don't know what manufacturer to trust, chevy has problems with their blazer transmissions too. i bought this car used with less than a hundred thousand on the odometer and found that the transmission was not original when i changed it last time now after i fix it i will sell it a drive it through the local ford dealership show room,maybe that would make them answer for all the problems everyone has with these problems. maybe what my brother says is true ford means f%*@ed over rebuilt dodge. *jb
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE)
08/04/1994
 Brake and transmission failure, four wheel drive malfunction, and an inaccurate speedometer.

Some parts © 2024 Advameg, Inc.
Based on public records. Inadvertent errors are possible.
This web site is not associated with, endorsed by, or sponsored by and has no official or unofficial affiliation with the vehicle's manufacturer.