Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||||
031514 | 08/04/2003 | 99105 | 10003193 | The malfunction indicator lamp (mil) may be illuminated and diagnostic trouble codes (dtcs) p1380, p1381, p1383, and/or p0340 may be stored in memory. *tt | 10/10/2003 |
03103 | 05/26/2003 | 10002767 | Vehicles without the coolant lock-off may exhibit a no start condition. *tt | 09/16/2003 | |
14355 | 09/01/2000 | 618630 | Information pertaining to duratec oil pan investigation. *jb | 04/18/2001 | |
13468 | 11/01/1999 | 6092221 | Some vehicles equipped with 2.0l engine may exhibit a timing belt shredding or timing belt striking the front cover. *tt | 11/28/2000 | |
7451 | 11/01/1999 | 610829 | Some vehicles equipped with 2.0l engine may exhibit a timing belt shredding or timing belt striking the front cover. *tt | 05/15/2000 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
16028 | 07/01/2002 | 636219 | Some vehicles equipped with a 2.5l engine may exhibit multiple misfire diagnostic trouble codes with no driveability concerns noted. *tt | 11/06/2002 | |
01246 | 12/10/2001 | 630515 | Engine oil system priming procedures, service tips for reports of premature engine failure. *tt | 04/18/2002 | |
0214 | 01/21/2002 | 630001 | Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt | 04/11/2002 | |
01205 | 10/15/2001 | 627927 | Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt | 02/26/2002 | |
14401 | 01/01/2000 | 620436 | Some vehicles equipped with 2.5l engine may exhibit multiple misfire diagnostic trouble codes (dtcs) with no driveability concern noted. *tt | 08/07/2001 | |
0147 | 03/05/2001 | 619424 | Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt | 05/30/2001 | |
00186 | 09/04/2000 | 618595 | Vehicles may experience no start condition when the wiper switch is in the intermittent or low-speed setting during vehicle start-up. *jb | 04/17/2001 | |
0114 | 01/22/2001 | 618069 | Experiencing a spark knock or pre-ignition condition on vehicles with an automatic or manual transmission during steady cruise driving or under light acceleration. *tt | 04/03/2001 | |
13830 | 01/01/2000 | 612885 | Some vehicles equipped with a 2.5l engine and built after may 5, 1999 may exhibit an intermittent hard/no start, rough idle or hesitation after a hot soak of approxinately 30 minutes. *mjs | 06/13/2000 | |
8334 | 03/01/2000 | 612760 | Some vehicles equipped with a 2.5 engine and built after may 25, 1999 may exhibit an intermittent hard / no start, rough idle or hesitation after a hot soak of approximately 30 minutes. *tt | 06/12/2000 | |
13386 | 10/01/1999 | 609662 | Information on investigating hard start / no start conditions accompanied by overfueling in ambients below 32f/0c, on vehicles with vct equipped 2.0l zetec engines. *tt | 04/05/2000 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
17174 | 09/01/2003 | 10004066 | Malfunction indicator lamp on and diagnostic trouble codes p0171/p0174 or p1072/p0175 stored in memory or as hard faults. hesitation, lack of power or runs rough condition. *tt | 11/17/2003 | |
00252 | 12/11/2000 | 616819 | On some vehicles, an objectionable exhaust, sulfur, or rotten egg odor following aggressive driving, such as full-throttle acceleration may occur. *tt | 03/13/2001 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||||
CSP-08B01 | 05/16/2008 | 10026389 | Ford: certain 1999-2001 model year vehicles up to 6000 lb gvwr registered in new york and certain 2001 vehicles up to 6000 lb gvwr registered in the state of maine, certified for sale in california-federal emission warranty refund. *pe | 10/23/2008 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
15390 | 11/01/2001 | 630408 | Some vehicles may exhibit a check engine light and/or egr diagnostic trouble codes 332, p0401, p1407 (lackof egr flow). *tt | 04/17/2002 | |
14877 | 05/01/2001 | 620202 | Some vehicles may illuminate the malfunction indicator lamp or run rough after the catalyst is removed and / or replaced. this may be due to vacuum leaks as a result of tolerance stackup within the exhaust / egr / intake system. | 07/20/2001 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
02/28/2007 | 121359 | 15 | 02/21/2003 |
My 2000 ford contour se starting acting like there was no gas at around 1/4 tank. this continued every time my car got to 1/4 tank. mechanic replaced fuel filter $54.90 for filter and diagnostic on 3/13/07. it still stuttering, hesitated and now was stalling. mechanic replaced fuel pump $297.22 on 3/28/07. the problem persisted and now it was happening at 1/2 tank. once summer hit, it was worse with the a/c. between march and june 2007, mechanic replaced pump once and filter twice. on 6/27/07, car stalled and would not restart, tank was at 1/2. mechanic replaced intake manifold runner control unit and the problem remained. the problem continued with hesitating and stalling especially uphill. on 8/21/07 replaced all the spark plugs and wires $234.90. the problem continued. my mechanic is at his wits end. the code on the check engine light is always the same. on 10/26/07, took the car back to my mechanic who had to replace the intake manifold runner control unit again. decided to take my car to a different mechanic due to my current one not finding the problem. replaced 2 oxygen sensors this week (11/7 and 11/9) one upstream and one downstream. the check engine light has come back on once again. if this is an intake manifold runner control unit problem then everyone that has had fuel pumps replaced will have to have them replaced again. this is not enjoyable since i drive 40 miles a day to work and halfway there i have to pull over and wait for the car to idle down before i can drive again or it will stall. this is not safe as this happens while people are driving and for no reason the car stalls in mid drive. someone will get hurt and then there will be a recall. there were no events leading up to the failure except for taking my car for inspection which it passed. two days later my car starts stalling and losing power. in 9 months i have spent close to $1000 to try and fix a problem that still is not fixed. *tr | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
03/01/2004 | 3 | 01/05/2000 | |
Dt: the contact stated the plastic dashboard delaminated from the foam. the dashboard laminate was pushing upward, thus hindering the contact's vision through the front window. he contacted the manufacturer, and they said it was under review, and that it was cosmetic. also, he is also experienced fuel pump and water pump problems. under hard acceleration the fuel pump shut off. the dealership stated the contact's vehicle needed a new fuel pump. the bearings on the water pump failed and the vehicle overheated. *ak. | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
09/24/2004 | 53000 | 1 | 04/01/2004 |
The car makes a humming sound all the time from the intake system. *jb | |||
12/12/2003 | 75014 | 1 | 08/09/2000 |
Vehicle's engine blew up. vehicle was 14 miles out of warranty, however the vehicle was purchased with 28 miles on it. *la *jb | |||
1 | |||
The vehicle stalled, and lost power. *jb | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
03/10/2005 | 40000 | 1 | 01/10/2000 |
The dashboard, which was once recalled, the recall has since expired. is delaminating off the foam , preventing proper defrosting of windshield and hindering view out of front window. the fuel pump which was recalled on other ford models for exactly the same problem, fails, preventing acceleration onto highways. the water pump, which is plastic, disintergrates in the motor.*jb | |||
05/30/2002 | |||
While driving vehicle died out/stalled. took vehicle to dealer. engine failure. dealer replaced engine.*ak | |||
03/10/2002 | 10 | ||
While driving at 45mph vehicle loss power and consumer was forced to pull over, the vehicle surges when stopped and at times when shifting the gears will jump, the dealer has been unable to remedy the problem. *ak *nlm | |||
01/01/2002 | 20 | 12/01/2000 | |
While driving rpms on the vehicle will start to rise on its own and consumer can not shift vehicle when this happens, will usually happen when the temperature is over 80 degrees. contacted dealer. *ak the dealer was unable to correct the problem. *yh | |||
10/01/2000 | |||
Defective fuel pump and check engine light on. | |||
02/08/2002 | |||
While driving at any speed vehicle stalls without warning, cause unknown. please give any further details.*ak | |||
05/05/2001 | 02/01/2001 | ||
No summary listed for above vehicle. *ak | |||
01/01/2001 | 4 | ||
Engine check light has been on, and vehicle runs roughly. took vehicle to dealer 4 times. dealer stated that catalytic converter needed to be replaced. *ak | |||
05/10/2000 | 03/01/2000 | ||
No summary listed for above vehicle. *ak |