Ford E-250 2002
Model E-250 made in 2002 by Ford got 1 consumer complain, 2 investigations there are 4 recalls as well as 2 service bulletins. Consumer complaints with reference to engine and engine cooling. . Technical service bulletines regarding exterior lighting, service brakes, air. The car had one investigation (electrical system). There were some recalls concerningexterior lighting, vehicle speed control.
Model 2002
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| EXTERIOR LIGHTING - BRAKE LIGHTS | ||||||||||||||||
| 11V352000 | FORD MOTOR COMPANY | V (Vehicle) | 26715 | MFR | FORD MOTOR COMPANY | 07/13/2011 | 07/13/2011 | 571 | 108 | |||||||
| Defect Summary | Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. a multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate. | |||||||||||||||
| Consequence Summary | Non-functioning lights could increase the risk of a crash. | |||||||||||||||
| Corrective Summary | Dealers will replace the switches free of charge. the safety recall is expected to begin on or about august 15, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332. | |||||||||||||||
| Notes | Ford's safety recall no. 11c18.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| VEHICLE SPEED CONTROL | ||||||||||||||||
| 07V336000 | FORD MOTOR COMPANY | from 04/09/1996 to 08/02/2002 | V (Vehicle) | 3600000 | 08/13/2007 | ODI | FORD MOTOR COMPANY | 08/03/2007 | 08/03/2007 | |||||||
| Defect Summary | On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn. | |||||||||||||||
| Consequence Summary | This could result in an underhood fire. | |||||||||||||||
| Corrective Summary | Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751. | |||||||||||||||
| Notes | Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
| 09V399000 | FORD MOTOR COMPANY | V (Vehicle) | 4500000 | 10/27/2009 | ODI | FORD MOTOR COMPANY | 10/13/2009 | 10/13/2009 | ||||||||
| Defect Summary | Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the scds may leak internally and then overheat, smoke, or burn. | |||||||||||||||
| Consequence Summary | A vehicle fire could occur with or without the engine running. | |||||||||||||||
| Corrective Summary | Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751. | |||||||||||||||
| Notes | Ford's recall campaign number is 09s09.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| VEHICLE SPEED CONTROL - CRUISE CONTROL | ||||||||||||||||
| 08V051000 | FORD MOTOR COMPANY | from 09/03/1991 to 09/15/2003 | V (Vehicle) | 225000 | 02/18/2008 | MFR | FORD MOTOR COMPANY | 02/04/2008 | 02/04/2008 | |||||||
| Defect Summary | Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. the affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity. | |||||||||||||||
| Consequence Summary | As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground. | |||||||||||||||
| Corrective Summary | Dealers will install a new wiring harness, or replace the mating electrical component. the recall began on february 18, 2008. owners may contact ford at 1-800-392-3673. | |||||||||||||||
| Notes | Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| EXTERIOR LIGHTING - HEADLIGHTS | |||||
| 19527 | 12/01/2006 | 10022232 | Headlight adjustment needed. *kb | 07/23/2007 | |
| SERVICE BRAKES, AIR | |||||
| 071110 | 10022675 | Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes. *nj | 09/19/2007 | ||
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | ||||||
| EA10003 | FORD MOTOR COMPANY | 04/13/2010 | 03/05/2012 | HVAC Switch Failures | ||
| This investigation was opened based on one complaint and reports from four transportation fleets alleging 182 blower motor control switch failures.odi was concerned that these melting and burning switches could lead to an open flame that could spread throughout the vehicle.after a comprehensive review of all data related to overheating blower motor control switches in the subject vehicles, odi did not identify the existence of a safety defect trend.odi reviewed 1,036 complaints, claims, and field reports of failed blower motor control switches and determined that only two fires were likely to have been caused by a failing subject blower motor control switch.this represents a failure rate of 0.2 r/100k on a population of 1,076,975 vehicles that have been in service for up to 14 years.odi has found that when the subject switches do fail and begin to melt, they are constructed in a manner that typically prevents the failing switch from igniting and developing into an open flame.ford motor company has agreed to take two actions to further reduce the likelihood an overheated blower motor switch in the subject vehicles.ford informed odi that it has implemented a series of design changes to the subject switch that will help prevent it from developing internal high resistance short circuits.ford has also informed odi that it would release a technical service bulletin (tsb-11-11-21) instructing subject vehicle owners to replace the electrical connector at the same time a failed switch is replaced.in light of the low rate of failure resulting in open flame and fire spread on the subject vehicles, and ford's actions to reduce the likelihood of a switch failure through switch design changes and a tsb, further use of agency resources does not appear to be warranted.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.the odi complaints cited above can be reviewed at www-odi.nhtsa.dot.gov/complaints under the following (odi) numbers: 10427875, 10114393, 10257890for additional information, see the attached closing report. | ||||||
| EA10003 | FORD MOTOR COMPANY | 04/13/2010 | HVAC Switch Failures | |||
| Odi has received 1 complaint and reports from 4 transportation fleets alleging 182 switch failures.each fleet operates mini buses built on a ford e350 or e450 cutaway chassis.the oem hvac blower switches have melted, smoked, burned or experienced open flame and become inoperable on vehicles in each fleet.some drivers have reported a burning smell or smoke coming from the dash.one fleet reported a vehicle fire.no injuries were sustained.however, the bus was carrying special needs children when the driver noticed smoke coming from the dash.the driver was able to evacuate the children prior to the vehicle becoming engulfed in flames.the 55 fires referred to in the manufacturers column is based on the early warning reporting definition of fire, which is as follows: fire means combustion or burning of material in or from a vehicle as evidenced by flame. the term also includes, but is not limited to, thermal events and fire-related phenomena such as smoke and melt, but does not include events and phenomena associated with a normally functioning vehicle such as combustion of fuel within an engine or exhaust from an engine.this engineering analysis (ea) has been opened to determine if the blower motor switch failures create a situation where a vehicle fire is possible and presents a safety risk to the driver and other passengers. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 05/13/2009 | 117715 | 1 | |
| I own a ford f-250 with a 5.4 motor. this truck blew a spark plug out of the motor on 4-15 -2008 and it blew a different spark plug out of the motor on 5-13-2009. ford needs to recall this truck and other vehicles and correct this defect. i will be talking with a lawyer in the next few days in hopes of getting my truck repaired and to recover the money i have already spent for repairs.i f safercar.gov will check with parts houses such as auto zone and repair shops you will find this is a very big problem, a very very big problem. i pull a horse trailer and if this spark would have blew out while pulling out into traffic me or my daughter could have been killed !!!!!! *tr walter glenn johnson byram,ms | |||