Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
041601 | 11/14/2005 | 05228 | 10018745 | Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt | 01/12/2006 |
04228 | 12/27/2004 | 04254 | 10013403 | Hard start or no start. *eh | 04/18/2005 |
17079 | 08/01/2003 | 10003178 | Water pump pulley bolts loosening. *tt | 10/09/2003 | |
0361 | 03/31/2003 | 10001855 | Malfunction indicator lamp on with or without rough running, lack of power, surge or poor fuel economy with diagnostic trouble codes p0401, p0402, p1400, p1401. *tt *jb | 07/23/2003 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
16407 | 11/01/2002 | 10008337 | Water pump pulley bolts loose. *mj | 07/28/2004 | |
15398 | 11/01/2001 | 630414 | Some vehicles may exhibit a coolant leak due to a broken radiator hose clamp. *tt | 04/17/2002 | |
15397 | 11/01/2001 | 630412 | Some vehicles may exhibit a condition of oil contamination in cooling system. *tt | 04/17/2002 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
TSB-11-11-21 | 11/17/2011 | 10042864 | Ford: the blower motor on some vehicles are operating either incorrectly or not operating or just functioning on one speed. *pe | 01/20/2012 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
TSB-11-11-21 | 11/17/2011 | 10042864 | Ford: the blower motor on some vehicles are operating either incorrectly or not operating or just functioning on one speed. *pe | 01/20/2012 | |
07212 | 10/01/2007 | 10023943 | Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe | 02/20/2008 | |
031404 | 08/23/2004 | 04161 | 10011162 | Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04. | 01/06/2005 |
16403 | 11/01/2002 | 10008334 | Engine-light tick or rattle type noise from engine after cold start. *mj | 07/28/2004 | |
02227 | 11/11/2002 | 10008310 | Engine-cylinder head deck leak-4.6 and 5.4l engines-new service-only gasket and cylinder head kits availability. *mj | 07/27/2004 | |
02221 | 11/11/2002 | 10008304 | Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application. *mj | 07/27/2004 | |
03256 | 12/22/2003 | 10008278 | Engine-romeo built 4.6l 2v-tick noise from engine-engines built before 9/17/2003. *mj | 07/26/2004 | |
17259 | 10/01/2003 | 10004913 | Rough idle and/or misfire with diagnostic trouble code p0316 after an overnight soak in extreme cold and high humidity conditions. *tt | 01/20/2004 | |
03206 | 10/13/2003 | 10004889 | Some dedicated cng vehicles may exhibit various driveability conditions due to a loss of injector performance, resulting from fuel quality. loss of power at heavy load, diagnostic trouble codes (dtcs) for lean fuel, rough idle, hard start, | 01/14/2004 | |
16589 | 10/30/2003 | 10004882 | Gradual loss of power at cruise. ford special service message. various models including 2003 super duty f series. *tt | 01/13/2004 | |
032145 | 10/30/2003 | 02204 | 10004856 | External oil leak diagnosis for 7.3l dit engines. various models including 2003 super duty f series. *tt | 01/12/2004 |
032146 | 10/30/2003 | 02205 | 10004857 | Engine oil pan corrosion on vehicles equipped with the 7.3l diesel engine. various models including 2003 super duty f series. *tt | 01/12/2004 |
032151 | 10/18/2004 | 04202 | 10004862 | Some 7.3l diesel turbocharger pedestals may leak oil around the exhaust back pressure actuator (ebp). *tt this article supersedes tsb 03-21-51 dated 10/30/2003. *tt | 01/12/2004 |
032150 | 03/08/2004 | 0444 | 10004861 | High pressure oil pump leak on vehicles equipped with 7.3l diesel engine. *tt | 01/12/2004 |
03171 | 09/01/2003 | 10004023 | 7.3l diesel high pressure oil pump leak. *tt | 11/14/2003 | |
03144 | 07/21/2003 | 10003744 | Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt | 10/29/2003 | |
03164 | 08/18/2003 | 10003118 | Some vehicles, equipped with the 4.6l 2v engine, with an engine build date prior to 8/29/03 may exhibit an engine tick noise that is present at all temperatures during idle. 2004 models included. *tt | 10/08/2003 | |
0322 | 02/03/2003 | 10002472 | Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401, or runs rough, lacks power, surge, poor fuel economy, and the above listed dtcs without | 09/03/2003 | |
870197 | 10/22/2002 | 10000592 | Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt | 03/25/2003 | |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
03192 | 09/29/2003 | 031410 | 10004032 | Leak oil around the exhaust backpressure actuator (ebp) - 7.3l diesel turbocharger pedestals. *tt | 11/14/2003 |
031410 | 07/21/2003 | 10003750 | Turbo pedestal seal oil leak around the exhaust back pressure (ebp) actuator. 2003 super duty f series included. *tt | 10/29/2003 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
15761 | 03/01/2002 | 636408 | Some dedicated cng vehicles may exhibit driveability conditions of hard start / no start / rough running. *tt | 11/08/2002 | |
02108 | 05/27/2002 | 636083 | Some vehicles equipped with the 5.4l 2v engine may exhibit a whistling noise fromthe formed nylon tube inthe idle-air bypass flow circuit. *tt | 11/05/2002 | |
01246 | 12/10/2001 | 630515 | Engine oil system priming procedures, service tips for reports of premature engine failure. *tt | 04/18/2002 | |
0214 | 01/21/2002 | 630001 | Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt | 04/11/2002 | |
01205 | 10/15/2001 | 627927 | Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt | 02/26/2002 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
05417 | 03/07/2005 | 10014666 | Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. *tt | 05/05/2005 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||||
0554 | 03/21/2005 | 10014685 | Use of stainless steel exhaust studs in service for 5.4l 2v engine. *tt | 05/05/2005 | |
17320 | 11/01/2003 | 10008169 | Broken exhaust manifold studs. *tt | 07/22/2004 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||
DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi | ||||||
ENGINE AND ENGINE COOLING - ENGINE | ||||||
DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi | ||||||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | ||||||
DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||
03/23/2005 | 70150 | 1 | 06/11/2003 |
Driving on primary road way when i heard a loud pop. sounded like an exhaust leak. pull off to side of road, turn off engine to check to see what the problem was.checked exhaust ok. removed engine cowling, found spark plug ejected itself. spark plug was missing, cop coil mounting broke, boot burnt. had vehicle towed to ford dealer after being told it would be covered under warranty. dealer refused to repair under warranty. talk to another dealership,an was told this a common problem in the triton engines. no repair has been made. i still have the cop coil. *jb |