Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN | |||||
| 042516 | 12/27/2004 | 10014269 | Malfunction indicator lamp (mil) illuminated with diagnostic trouble code (dtc) p0756, p0761 or p0771 after overhaul or installation of 2005 torqshift transmission. *tt | 04/29/2005 | |
| 04B24 | 08/18/2005 | 10012944 | Low/reverse gear set pinion shaft(s) that may walk out, causing metallic particle contamination. customer satisfaction program 04b24. transmission reverse planet replacement. *tt supplement #1 and #2. *tt supplement #3. *tt | 04/04/2005 | |
| 18051 | 08/01/2004 | 10011180 | Delayed/harsh forward or reverse engagements. *tt | 01/07/2005 | |
| 18250 | 10/01/2004 | 10010743 | Intermittent clunk on 3-2 downshift during coastdown/tip-in. oasis. to include 2005 f-150, e-series and expedition. *tt | 12/07/2004 | |
| 17874 | 06/01/2004 | 10008265 | Delayed/harsh forward or reverse engagements. *tt | 07/23/2004 | |
| 17727 | 04/01/2004 | 10008228 | Clunk or pop on initial engagement from reverse to drive at approximately 2-3 mph. various modles including 2004 econoline. *tt | 07/23/2004 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 18822 | 09/01/2005 | 10018070 | Torqshift transmission - intermittent clunk when shifting from reverse gear or drive gear to park. multiple vehicles. ford oasis. to include 2006 ford f-53. *tt | 12/14/2005 | |
| 18376 | 01/01/2005 | 10013316 | A cold weather reverse engagement stall. *tt | 04/14/2005 | |
| 03261 | 01/05/2003 | 10008279 | New service part - number 5 needle bearing and race kit - 4r70w transmission - service tip. *tt | 07/26/2004 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
| 042107 | 12/13/2004 | 042414 | 10014086 | General (pcm) power train control module programming procedures. *tt | 04/28/2005 |
| POWER TRAIN - AXLE ASSEMBLY | |||||
| 17905 | 07/01/2004 | 10009332 | Multiple vehicles using fehp rear axle fluid. fluid usage change. *tt | 09/23/2004 | |
| POWER TRAIN - DRIVELINE | |||||
| 04266 | 01/01/2005 | 052610 | 10014275 | A driveline clunk or bump when starting from a stop. *tt | 04/29/2005 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN | |||
| 09/12/2007 | 100699 | 1 | |
| I have a ford e-350 super duty van that has had drivable problems since it was new. after many trips to dealerships i was told that there was no fix at this time and ford should come out with a fix in the future. the engine dies when hot at times causing hard braking and loss of steering. at 100699 miles, just 699 miles out of warranty the engine quite running when hot. if it sits for 6 or more hours it will restart and run for only 20 minutes. ford told me it was no longer under warranty and would provide no assistance. *tr | |||
| 09/24/2005 | 20 | 7 | 03/14/2005 |
| 2004 ford wagon e350 with floor lowered by vantage mobility int. for handicap people. during stop and go driving like traffic jams while pulling a trailer the floor between front seats gets more than hot enough to burn your foot. sliding door opener has broken 6 times leaving the door free to slide open and shut. i keep a bungy cord to tie it up but interior lights come on and off when using bungy cord. the original latch by ford was removed to install the door opener. split drive shaft installed to make room for under vehicle lift by braun corp has a low roar to it. bicycle type chain for the sliding door opener at wheelchair lift drags across part of door jamb.(no pulley or sprocket). paid $48,000 for this new 2004 model in april, 2005 i'm asking for my money back. please help us. *nm | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 08/15/2004 | 2200 | 1 | |
| 5 speed automatic transmission occasionally jumps out of drive during normal operation of vehicle, engine revs for a second or two, then transmission slams back into drive. *tr | |||
| 01/25/2007 | 3 | 06/29/2004 | |
| Automatic transmission will slip out of gear without warning during on-road operation. *tr | |||
| POWER TRAIN - DRIVELINE | |||
| 02/05/2004 | 500 | 1 | 02/02/2004 |
| 2004 ford f350 this ford truck wanders, there is play in the steering wheel. truck does not go straight down the road. wanders back and forth, have to keep minding the wheel. cruise control decreases 10-12 mph for no reason. both of these problems are serious safety defects. there is a driveline vibration that is continuing to get worse. ford is unwilling and unable to repair these problems. *jb | |||