Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION - GEAR POSITION INDICATION (PRNDL) | ||||||||||||||||
90V101000 | FORD MOTOR COMPANY | to 10/01/1989 | V (Vehicle) | 111000 | 07/17/1990 | ODI | FORD MOTOR COMPANY | 06/01/1990 | 06/14/1990 | |||||||
Defect Summary | Under certain conditions, the snap ring that locates the park gear on the output shaft of the transmission may fracture. | |||||||||||||||
Consequence Summary | When the gear is placed in park, the park gear would notengage, allowing the truck to roll freely if the parking brake is not properlyset. this could result in an accident. | |||||||||||||||
Corrective Summary | Install improved snap ring and revised transmission extension housing. | |||||||||||||||
Notes | System: park gear snap ring.vehicle description: 4 x 2 light trucks and vans equipped with one-piecedriveshaft and an e40d transmission. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
99152 | 07/26/1999 | 608431 | Information on the new flush and fill tool available through rotunda. *tt | 01/05/2001 | |
0015 | 01/10/2000 | 612203 | Information regarding the new transmission cooler flusher- service tip. *mjs | 06/06/2000 | |
98168 | 04/07/2000 | 609737 | Transmission- e40d/4r100-1989-99-main controls, separator plates and separator plate gaskets usage chart. yd | 04/07/2000 | |
98123 | 01/19/1998 | 605599 | Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62, 628, and / or 1728 may be stored in memory. *tt | 07/13/1999 | |
9888 | 04/27/1998 | 601238 | Information on a new transmission fluid usage chart. *yc | 07/10/1998 | |
97511 | 03/03/1997 | 51945 | Fluid- transmission fluid usage charts. *jd | 07/17/1997 | |
95619 | 03/01/1995 | 39913 | New design transmission range sensor. *tw | 11/01/1995 | |
951112 | 06/01/1995 | 45085 | Revised design transmission rear case bushing. *tw | 11/01/1995 | |
9568 | 03/01/1995 | 3055200 | Unknown | 11/01/1995 | |
95212 | 01/01/1995 | 39125 | Vehicles may exhibit a shift concern. *tw | 03/17/1995 | |
942415 | 11/01/1994 | 37765 | Upgrade kit for the e40d transmission. *tw | 01/06/1995 | |
942318 | 11/01/1994 | 37741 | Transmission overheating, converter cover discoloration, clutches burned and burnt fluid *tw | 01/06/1995 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||||
002310 | 11/13/2000 | 616522 | Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt | 03/05/2001 | |
0038 | 02/07/2000 | 612343 | Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs | 06/07/2000 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER | |||||
96249 | 11/18/1996 | 50908 | Torque converter - leak test procedure - service tip. *tw | 06/17/1997 | |
962612 | 12/16/1996 | 50997 | Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw | 06/17/1997 | |
POWER TRAIN - CLUTCH ASSEMBLY | |||||
96728 | 03/25/1996 | 613350 | Service tip information regarding the reverse clutch piston and piston seal usage. *tt | 06/22/2000 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||
1 | |||
When first starting vehicle defect within ignition switch will cause entire electrical system to become inoperative. this is intermittent problem. *ak sometimes vehicle will not shift into overdrive or will not want to shift out of first gear. air conditoner failed. power window malfunctions. brake light inoperable. cruise control malfunctions. *yh | |||
08/16/1996 | |||
During operation , the vehicle experienced sudden acceleration. the brakes were applied.*ak | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - GEAR POSITION INDICATION (PRNDL) | |||
Gear shift indicator shows that the vehicle is engaged in park, but the vehicle still rolls as if not completely in gear. dlr has seen 4 times, and cant find the cause. *ak |