Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE | ||||||||||||||||
| 93V100000 | FORD MOTOR COMPANY | from 11/01/1991 to 02/01/1993 | V (Vehicle) | 1235 | 10/12/1993 | MFR | FORD MOTOR COMPANY | 06/08/1993 | 06/15/1993 | |||||||
| Defect Summary | The fuel filler hose or fuel filler vent hose was damaged by a drill bit used to install the dso package attaching hardware onto the floor pan. | |||||||||||||||
| Consequence Summary | If either of the hoses was penetrated by the drill bit,fuel leakage could result, particularly during fueling of the vehicle. in thepresence of an ignition source, this could result in fire. | |||||||||||||||
| Corrective Summary | Replace the fuel filler and vent hoses and relocate the mounting hardware in the floor pan. | |||||||||||||||
| Notes | System: fuel system.vehicle description: cargo vans with sears fleet dso package. | |||||||||||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||
| 08/21/1997 | |||
| The fuel pressure regulator malfunctioned, causing fuel to flow into vehicle cylinders/ oil pan/exhaust pipe and muffler systems, resulting in starter lock up. when dealer attempted to replace starter, fuel flowed out of the vehicle. also replaced oxygen sensor. *ak | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
| 09/30/1995 | |||
| Electrical fuel pump inside the 35 gallon fuel tank makes excessive noise. tt | |||
| 03/18/1993 | 8 | ||
| Fuel pump failed, causing vehicle to stall. | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
| 03/01/2001 | 11 | 08/01/2000 | |
| Vehicle stalls in warm weather, at any speed and any time.*ak. consumer stated the dealer discovered the problem as being the coolant sensor, also the fuel filter and drivebelt were replaced.*jb | |||
| 05/22/1998 | |||
| Rubber hose between the fuel tank and the fille neck has rotted and cracked, causing gas leakage. the dealer and manufacturer has been notified. *ak | |||
| 07/01/1997 | 1 | 07/01/1992 | |
| Filler hose failed. | |||
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
| 07/16/2004 | 1 | ||
| I am a detective with the city of bridgeport, wv. on 7/16/04 i witnessed a 1992 ford van vin#: 1fdee14h9nhb05685 on u. s. route 50 traveling at 100 mph and the horn blowing. the vehicle left the roadway and crashed into a building, which myself and another officer attempted to get the driver out of the vehicle, which once with in a few feet the vehicle erupted into flames. through the investigation of this incident it was found that the driver was traveling east on u. s. route 50 from the parkersburg, wv area towards her residence in salem, wv. the driver should have exited u. s. route 50 approximately 15 miles prior to the crash site in bridgeport, wv and did not do so because the accelerator of the vehicle was at full throttle for some reason. the driver was witnessed as far as 8 miles west of the crash site blowing her horn and flashing her lights to warn drivers of her problem. there is a total of 2 witnesses who gave statements to the drivers actions while traveling on u. s. route 50, plus what i witnessed as the vehicle passed my location about 1/2 mile before the crash site. the brakes of the vehicle were examined by myself and two mechanics and were found to be completely worn down and there was some gouge marks in the rotors of the vehicle. when the vehicle passed my location i could hear the engine roaring at full throttle and with the horn blowing constantly that this was more than just a drunk or speeder. the family of the driver stated that the vehicle had brakes put on a few months and the vehicle had been driven only a few times since. i found two recalls on www.alldata.com that i would like to find more information on; 1. speed control - inoperative, 2. accelerator cable -service procedures/tips. any information would be appreciated. *jb | |||
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||
| 10/20/1994 | 0 | ||
| Vehicle hesitates to start and blows out black smoke due to failure of fuel pressure regulator. | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
| 06/15/1996 | 04/16/1992 | ||
| Fuel leaked from weld of the fuel tank. also, fuel vapors/fumes came into vehicle. dealer notified, but repairs were made at an independent repair shop. *ml | |||
| A cracked weld in the gas tank is causing fuel to leak through ,producing strong gas fumes. *ak | |||
| 03/15/1999 | |||
| Experiencing problem with fuel leaking along the seam of the fuel tank. believed this was a manufacturer's defect for a vehicle with 44,000 mile of wear. mfr. notified and informed consumer that vehicle was no longer under warranty and repairs would be at consumer's cost. *ak *ml | |||
| 07/15/1999 | 2 | 11/01/1996 | |
| My wife was driving on 190 headed east and without warning the right rear wheel snapped off, and she spinned around about three times before coming to a halt, facing the flow of oncoming traffic. no other vehicles were involved. date was sept 98 //// 15 jul 99. driving on 195 with my entire family and some friends at about 70 miles per hour the left rear wheel snapped off without warning and we began to skid about 150-200 meters. the van fishtailed. but i compensated it with my steering. after coming to a halt we found out that we were skidding on our gas tank, which was busted at that time. fuel was every where but no explosion. thank the lord! | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
| 01/01/2001 | 1 | ||
| When filling vehicle with gas noticed gas running onto gas tank and ground. dealer stated filler tub needed to be replaced. *ak the dealer failed to install correct part and repair was done. besides, the dealer installs the whole assembly instead of failed part. *yh | |||
| 11/01/2000 | 10/01/1998 | ||
| Rubber re-fuel intake nozzle has rotted and creates a serious fuel leak. *ak | |||
| 09/11/2000 | 1 | 08/01/1993 | |
| The fuel fill rubber tube and vent tube, connecting the exterior nozzel fill to the fuel tank has failed and raw gasoline is pouring out from under the vehicle. the parts have failed from normal wear and tear, no tramatic event cuased failure. ford does not accept responsiblility for such a basic fuel containment system failure, other than to refuse to allow the vehicle to be driven out of their dealership, for fear of immediate fire. this component should not fail on a perfectly maintained 1992 vehicle! i am sure this is not the only failure of this basic safety system. there is an immediate danger to person and property caused by this defect. thank you for following up on this. *ak | |||
| 11/20/1999 | 1 | 05/01/1995 | |
| The fuel filler hose has cracked and leaks about 2 quarts of gas at each fillup. dealer will only sell me a $90.00 hose to repair. notes that the part is not under warranty. *ak | |||
| FUEL SYSTEM, OTHER | |||
| 08/15/1995 | |||
| Abs: when applied, brakes seemed extremely spongy; anti lock brake light came on; speedometer bounced up/down; gas gauge went from half to full. tt | |||
| FUEL SYSTEM, OTHER - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
| 07/01/1997 | 1 | 07/01/1992 | |
| Vent hose failed. | |||