Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| 98246 | 12/07/1998 | 604059 | Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc | 03/16/1999 | |
| ELECTRICAL SYSTEM - WIRING | |||||
| 99222 | 10/18/1999 | 6089681 | Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt | 02/11/2000 | |
| 96246 | 11/18/1996 | 50905 | Wiring - electrical diode identification and service replacements. *tw | 06/17/1997 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||
| PE87028 | FORD MOTOR COMPANY | 05/01/1987 | 01/21/1988 | STALLING | ||
| There is no summary currently available | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 01/01/1986 | 1 | ||
| Air conditioner problems due to electrical problem which resulted in fire. *dsh | |||
| ELECTRICAL SYSTEM - IGNITION | |||
| 10/12/2000 | 3 | 11/01/2097 | |
| Several times over the last few months while driving with the engine temperature in the normal range on the freeway traveling at between 70-75 mph the vehicle stalls and will not restart. when pulled to the side of the road after looking under the hood and removing the timing plug and allowing the ignition module to cool for about 5 minutes the engine restarts. the engine will not restart without removing the timing plug. i have replaced the ignition module and the ignition module pickup with original factory replacement parts. the problem goes away for a short period of time and then resurfaces after about a few weeks after replacement. a californa judge has ordered a recall to repair this problem however ford motor company will not comply unless the nhtsa orders them to do so. i will continue to replace the parts as to not endanger myself or others on the freeway. thank you for your consideration. *ak | |||
| 07/17/1996 | |||
| While driving at 45mph vehicle shuts off with no warning. consumer is unable to get it started. cause unknown. dealer notified.*ak | |||
| 10/12/2000 | 3 | 11/01/1997 | |
| Several times over the last few months while driving with the engine temperature in the normal range on the freeway traveling at between 70-75 mph the vehicle stalls and will not restart. when pulled to the side of the road after looking under the hood and removing the timing plug and allowing the ignition module to cool for about 5 minutes the engine restarts. the engine will not restart without removing the timing plug. i have replaced the ignition module and the ignition module pickup with original factory replacement parts. the problem goes away for a short period of time and then resurfaces after about a few weeks after replacement. a californa judge has ordered a recall to repair this problem however ford motor company will not comply unless the nhtsa orders them to do so. i will continue to replace the parts as to not endanger myself or others on the freeway. thank you for your consideration | |||
| 12/01/1998 | 2 | 05/01/1997 | |
| Ignition module has been replaced twice in 3 years, car was stalling at low speed. the same problem seems to be returning. | |||
| 03/05/1994 | |||
| When slowing down or coming to stop, engine stalls without warning. tt | |||
| ELECTRICAL SYSTEM - IGNITION - MODULE | |||
| 10/12/2000 | 80150 | 3 | 11/01/1997 |
| Several times over the last few months while driving with the engine temperature in the normal range on the freeway traveling at between 70-75 mph the engine stalls and will not restart. when pulled to the side of the road after looking under the hood and removing the timing plug and allowing the ignition module to cool for about 5 minutes the engine restarts. the engine will not restart without removing the timing plug. i have replaced the ignition module and the ignition module pickup with original factory replacement parts. the problem goes away for a short period of time and then resurfaces after about a few weeks after replacement. a california judge has ordered a recall to repair this problem however ford motor company will not comply unless the nhtsa orders them to do so. i will continue to replace the parts as to not endanger myself or others on the freeway. thank you for your consideration. *ak *nlm **dimsii ivoq entry posted after 12/12/02 cut-over to artemis*734328 | |||
| ELECTRICAL SYSTEM - IGNITION - SWITCH | |||
| 09/18/2000 | 1 | ||
| When driving at any speed vehicle will stall and cut off without prior warning. vehicle has stalled out in the middle of an intersection. consumer has contacted dealer. dealer noted that ignition went bad which caused the vehicle to stall . ignition was replaced on a number of occasions.*ak | |||
| 05/02/1996 | |||
| Driven on frwy, parked in parking lot, took vehicle off parking lot, about 1/4 mile later saw flames coming from hood, fire dept arrived & put flames out. *ak | |||
| 01/01/1990 | |||
| Vehicle was parked, turned ignition on and vehicle completely burned, electrical short. *ak | |||
| 07/12/1993 | |||
| The vehicle was parked for three minutes and then it went up in flames. please describe. *ak | |||
| 01/01/1996 | 1 | ||
| Ignition switch failed, preventing starter from engaging. *dsh | |||
| 03/01/1996 | |||
| Was driving to a meeting, parked his vehicle in a parking lot, went to meeting, returned, saw fire dept., saw vehicle engulfed in flames. *ak | |||
| An electrical short or shock caused the vehicle to catch on fire. please describe. *ak | |||
| 12/01/1995 | |||
| Experienced electrical fire in dash and underhood. please give details. *ak | |||
| 03/09/1996 | |||
| Electrical short or shock in the ignition switch causing the vehicle to catch fire around the steering column. *ak | |||
| ELECTRICAL SYSTEM - WIRING | |||
| 03/08/1994 | |||
| Electrical short or chock caused the vehicle to catch on fire. please describe. *ak | |||
| ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
| While driving, noticed smoke under hood, parked vehicle, moments later found vehicle fully engulfed in flames. *ak | |||
| 09/01/1994 | 1 | ||
| Wiring harness failed, causing fire. *skd | |||
| ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
| 12/01/1995 | |||
| Consumer was driving and smoke came from the dashboard and car was on fire. please describe . *ak | |||