Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | ||||||||||||||||
92V117000 | FORD MOTOR COMPANY | from 04/22/1991 to 08/30/1991 | V (Vehicle) | 22000 | 11/06/1992 | ODI | FORD MOTOR COMPANY | 08/19/1992 | 08/26/1992 | |||||||
Defect Summary | Fatigue cracks can develop in the solder joint between the fuel return tube and the fuel pump sending unit located at the top of the fuel tank. | |||||||||||||||
Consequence Summary | Should a crack develop, fuel vapor can escape from thetank when the tank is full, and a small amount of fuel can leak from the crack.fuel leaks can result in fire when exposed to a source of ignition. | |||||||||||||||
Corrective Summary | Install a new fuel pump sending assembly. | |||||||||||||||
Notes | System: fuel system.vehicle description: passenger vehicles equipped with fuel pump sendingassemblies produced by ford electrical and fuel handling division (fehd). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||||
96225 | 10/21/1996 | 50944 | Mass air flow sensor - replacement as an assembly - service tip. *tw | 06/17/1997 | |
FUEL SYSTEM, OTHER | |||||
94253 | 12/01/1994 | 38055 | Fuel gauge always reads full. *tw | 02/07/1995 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE | |||
08/13/2009 | 131000 | 1 | 08/10/2009 |
Tl*the contact owns a 1992 ford escort. after filling up the vehicle with fuel, the contact drove to his residence and parked. one hour later, he noticed a small puddle of gasoline on the garage floor. he stated that the leak was coming from the fuel line or fuel tube. the vehicle has not been inspected by a dealer. through research, the contact found nhtsa campaign id number 92v117000, nhtsa action number ea92012 (fuel system, gasoline). the manufacturer stated that the vin was not included in the recall. the contact believes that the vehicle should be included because the failures were identical. the current and failure mileages were 131,000. updated 11/03/09 *bf updated 11/03/09.*jb | |||
05/15/2006 | 139000 | 1 | 05/15/2006 |
Dt*: the contact stated the day the vehicle was purchased, there was a smell of fuel in the cabin. after doing some research on the nhtsa website the contact became aware of a nhtsa recall #92v117000 pertaining to the fuel system. the vehicle was taken to the dealer, who determined it was not included in the recall due to the vin. the manufacturer was contacted who confirmed that the vehicle was not included in the recall. the contact was the second owner of the vehicle. the original owner also noticed the smell of fuel in the vehicle but chose to drive it at less than a full tank. | |||
11/19/2005 | 74838 | 1 | 11/17/2005 |
Gasoline leaks from top of gas tank when filled. there is a recall (nhtsa# 92v-117, ford # 92s54 ) i contacted the dealer and they had no record of recall, and told me it was to old to check. i then called ford's customer service dept, and was told the recall had been closed. *nm | |||
07/10/2000 | |||
There is a fuel odor inside passenger's compartment. also, recall 92v117000 was issued for same problem. however, this vehicle was not included in recall due to vin. please provide any further details. *ak | |||
1 | |||
When filling the gas tank there is a gas smell, consumer thinks that this is the same as in the recall # 92v117000, dealer said it was not in recall . *ak *jb | |||
06/05/1996 | 5 | ||
Vehicle has strong gas odor whenever tank is filled. *dh | |||
While parked overnight, vehicle caught fire, totaled. cause unknown by city fire marshall. please describe details. tt | |||
04/01/1994 | 1 | ||
Fuel odor prior to/ after replacement of gas tank seal. *ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
11/18/2003 | 136000 | 1 | |
Recall 92v117000 concerning fuel pump failure. anytime the consumer gets into the vehicle there is a strong odor of gasoline. consumer is not sure if her vehicle is included in the recall. *ak | |||
There was a recall on electrical harness in fuel system, this vehicle was not involved in recall; however, has experienced the same problem. has contacted ford, manufacturer stated that because vehicle did not apply with recall there was nothing that could be done.*ak | |||
03/25/2002 | 1 | 09/01/1992 | |
Fuel is leaking from the top of the tank, the consumer can smell fuel inside the vehicle and the consumer noticed a puddle of fuel on the ground when exiting the vehicle, this problem only occurs when the rear tank is full, the manufacturer has been contacted. nlm there is a recall 92v117000 to replace fuel pump sending unit. consumer replaced 4/7/1994. *tt | |||
Gas guage on the dash console did not work, and vehicle would not start. the fuse to the guage blew out, causing the fuel pump to go bad. dealer has been contacted. *ak | |||
01/01/1992 | |||
Owner was never notified of recalls concerning the offset toe adjusting pin or the fuel pump sending assembly. | |||
12/01/1997 | 2 | 04/01/1993 | |
Fuel tank and fuel pump failed causing fumes. | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
04/15/1992 | 1 | ||
Fuel pump failure. 8ak | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
08/08/2005 | 1 | ||
Dt: the contact states there is a nhtsa recall campaign 92v117000 concerning the fuel system. this vehicle has the same problems as indicated in the recall, but it is not included in the recall due to vin. the contact repaired the vehicle at his own expense. *ak | |||
12/20/2002 | 39000 | 4 | 04/12/1992 |
The consumer noticed fuel leakage from the tank. the dealer diagnosed a hole in the tank. the tank had leaked again. the consumer contacted the manufacturer who advised her that the v.i.n. was not included in the related recall 92v117000. ts after the purchase of the vehicle, a suspension bar was needed, and within the first year, the ignition switch was replaced. the consumer was advised to keep the fuel at half full. scc | |||
03/01/1993 | |||
Cracks in joint between the fuel return and fuel pump sending unit. leaks gas. possible fire hazard.*ak | |||
Fuel tank and fuel pump are leaking fuel due to cracks. please give any further details.*ak | |||
06/03/2000 | |||
Defective fuel tank cracked and developed a hole above the heat shield which was located over the muffler. this may have caused a fire. very common problem. plelase provide further information. *ak | |||
08/31/1999 | 1 | 05/01/1996 | |
Unibody has rubbed a hole in the fuel tank, car has never been in an accident, i feel like this is due to a flaw in the design, gas has been leaking on the exhaust pipe. i was told by a mechanic that this should be reported. i will also contact the ford motor co. and the consumer protection agency. i feel there was a great potential for injury or death | |||
08/27/1999 | 12/01/1992 | ||
Vehicle was parked in the driveway, noticed fluid underneath and realized it was gasoline. fuel tank was leaking. drove vehicle to the mechanic, and they replaced the fuel tank. *ak *ml | |||
11/14/1999 | 1 | 05/01/1998 | |
Car was emitting a slight gas odor. mechanics at grease monkey noted a leak on the top of the fuel tank. i took the car to an auto repair mechanic--the diagnosis was a crack in the fuel tank assembly. replaced fuel tank at a cost of 580.04. the repairs took over a week because the part was on back-order from the factory. | |||
08/18/1999 | |||
+a part of the gas tank where the brakes screw in there is a piece missing, causing the gas to leak .dealer was contacted ,and vehicle is being repaired at the owner's cost. *ak | |||
01/15/1999 | 1 | 11/01/1991 | |
I am reporting on a prior recall that supposedly did not affect my car. nhtsa campaign id # 92v117000. i had been having a fuel leak around the tank area for awhile and could not figure out where it was coming from. it would only do it when the tank was full or 3/4 full. i then came across recall # 92s54 which described my problem. i took my car into a ford garage and they told me that my vin # was not included in the recall. i then called the ford home office and was told that since my car wasn't included, that there was nothing wrong with my car. i examined the codes on the fuel pump and verified that it was indeed the defective one. i then replaced the assy (which cured the problem). i viewed the old one (which i still have) confirmed that there was a crack in the solder joint between the fuel pump mounting plate and the fuel return tube. i then registered a complain by phone to your office and was told that i would receive a copy of my complaint by mail in approx. two weeks. it's been about two months and i haven't received anything. i would appriciate a response. thank you. *ak | |||
05/13/1999 | 1 | ||
Ford customer said that my vin series was not covered under a previous recall for same problem with other 1992 escort gas tanks. *ak | |||
1 | |||
Leaky gas tank valve cover caused odor of gasoline. | |||
12/01/1997 | 2 | 04/01/1993 | |
Fuel tank and fuel pump failed causing fumes. | |||
Odor of gasoline coming from car when gas tank full, goes away when gas is used, gas tank valve on top of tank, leaks and evidence of long term leakage, replace gas tank. | |||
03/13/1997 | |||
When filling up fuel tank completely about 3 gallons of the fuel will leak back out, not sure where fuel in leaking from. vehicle has not been repaired. *ak | |||
Fuel tank leaks. please describe. *ak | |||
12/01/1996 | 1 | 02/20/1992 | |
Fuel tank leak. *ak | |||
05/25/1996 | |||
Heat gauge over gasket deteriorated on fuel pump. causing leakage under back seat, eating coating off wiring and shorted out. *ak | |||
09/30/1995 | |||
Purchase car had to replace the gas tank it was leaking . tt | |||
07/19/1995 | 1 | ||
Gas tank leaks when filled above 3/4 full. *ak | |||
Vehicle leaking gas from the gas tank, fixed gas tank. tt | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
06/01/2000 | 1 | ||
Fuel leaks from the neck of tank while vehicle is being driven or when is parked. technician said that had happened to another escort.*ak | |||
05/01/1996 | |||
Fuel leaks from tank area. | |||
FUEL SYSTEM, OTHER | |||
Gas guage on the dash console did not work, and vehicle would not start. the fuse to the guage blew out, causing the fuel pump to go bad. dealer has been contacted. *ak | |||
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||
09/01/1996 | 7 | 03/05/1992 | |
Electrical failure; driver's side lap belt; dash lights(speedometer fuel gauge, engine heat temp & revolotion guage), radio lights, driver's door buzzer/ overhead light; a/c,/ heater fan intermittent. ignition switch failure, x2, both brake light bulbs replaced: courtesy light in trunk needs replaced. has never been to garage, to be repaired, for any above electrical.exception, ignition replaced by garage x1.*ak | |||
03/25/2002 | 1 | 09/01/1992 | |
Fuel is leaking from the top of the tank, the consumer can smell fuel inside the vehicle and the consumer noticed a puddle of fuel on the ground when exiting the vehicle, this problem only occurs when the rear tank is full, the manufacturer has been contacted. nlm there is a recall 92v117000 to replace fuel pump sending unit. consumer replaced 4/7/1994. *tt |