Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SUSPENSION - REAR | |||||
| 14993 | 06/01/2001 | 622804 | Some vehicles produced through july 1999 may exhibit rear suspension spring failure with no resulting operational concern. *tt | 10/23/2001 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SUSPENSION | |||
| 03/10/1999 | 10/01/1996 | ||
| Also experience rattling in dashboard and door sides since mileage reached 30k. *ak | |||
| 01/01/1997 | |||
| Not a tire problem, all are up to speck. bad shake in stearing wheel. *ak( dot number: tire size: p185/70/14 ) | |||
| SUSPENSION - FRONT | |||
| 07/01/1997 | |||
| While driving over 45 mph vehicle shakes and has bad vibration. it seems like the front end is about to fall off. dealer cannot determine problem. there is a tsb, and ford states there is going to be a recall, but has no solutions. *ak | |||
| 11/01/1996 | 1 | 01/01/1996 | |
| While driving the vehicle, the vehicle has irregular steering control and rough riding, inappropiate tire wear. *ak consumer states vehicle can not be aligned properly due to the right front wheel assembly design which is causing irregular steering and tire wear. *slc | |||
| 07/12/1996 | 1 | 02/19/1996 | |
| Front end noise. | |||
| When making a left turn there is a noise in the car . please describe. | |||
| 08/08/1995 | 8 | ||
| Noisy vehicle, causing headache/loss of hearing. *ak | |||
| 12/22/1995 | 2 | ||
| Vehicle pulls to the right. *skd | |||
| SUSPENSION - FRONT - CONTROL ARM | |||
| 08/27/1995 | 7 | ||
| Loss of power steering due to ball joint failure. *sd | |||
| SUSPENSION - FRONT - SPRINGS - AIR SUSPENSION SYSTEM | |||
| 1 | |||
| Consumer stated while traveling at a low speed she heard a loud popping noise, and vehicle lost power. the vehicle was towed to dealer. dealer said a spring broke. please provide any further information. *ph | |||
| SUSPENSION - FRONT - SPRINGS - COIL SPRINGS | |||
| 11/13/2007 | 4 | ||
| Upon state inspection we were told the front and rear coil springs were broken and would cost over 650.00 dollars to repair. unbelievable as it seems it was confirmed by another inspection station.... *tr | |||
| 10/29/2004 | 72000 | 1 | |
| The front driver's side coil spring broke . no unusual impact reported. *ak...road construction all summer, many impacts of varied amplitude and duration.*ak | |||
| 12/13/2002 | 51000 | ||
| When i had the car in to repair a leaking radiator i was told that the rear springs of the car were broken - these were replaced along with the two rear tires which had been damaged due to the broken springs. six months later backing out of the driveway the left front spring broke puncturing that tire - per the garage both front springs are broken and must be replaced. since i've had the care in two different garages i've heard that this is a common problem with the ford escorts. | |||
| 04/01/2002 | 1 | 06/10/1996 | |
| While backing out of driveway, left front tire blewout. a piece of coil spring had punctured tire. consumer saw smoke coming from tire.*ak *yd | |||
| 12/07/2000 | 2 | 12/14/2000 | |
| Consumer heard a clunking sound, upon inspection he saw that coil springs had broken. *ak. consumer states the rear coil spring broke on dec-7-2000, and the front coil spring on march 25, 2002 which caused damage to a brand new tire.*jb | |||
| 10/29/2001 | 1 | 12/01/2000 | |
| Coil spring broken at bottom, behind plastic cover. was told this failure is common in escort wagons.*ak | |||
| 09/15/2001 | 1 | 03/01/1995 | |
| Repair shop indicated that they were experiencing a host of coil spring breakage on this and similar ford models. they were recommending that all customers with spring problems write to ford in hopes of forcing a recall - ha!. *ak | |||
| 02/01/1996 | |||
| Had inspection, was told that the springs were broken and that they were going early on all escorts. *ak | |||
| 08/01/2000 | 1 | 08/01/1995 | |
| I just read about the ford winstar front coil springs breaking in the newspaper and now that i browse this site, it appears to be a problem on many other ford cars. my 1995 escort front left spring snapped causing the left front tire to be slashed. i was in a parking lot so speed was not a factor. i managed to change the tire and get the car to a ford dealer that was nearby. upon inspection, i could see that the spring had snapped (clean break) like if a seam in the coil had failed. when i questioned the dealer, they did not know of this being a common occurrence and they would not fix it without charge as there was no recall. now that i see that this appears to happen on many ford cars. ....... i have reason to believe that the coil springs on fords may have hidden defects causing them to snap without warning.. should you need further information, please email me. thanks. *ak | |||
| SUSPENSION - MULTIPLE AXLE | |||
| 05/09/2002 | 2 | 10/01/2095 | |
| Both rear coil springs on this vehicle are broken. the car does not carry heavy loads, and the roads traveled upon are not rough. the car has relatively low milage, 88,000. when inspected, the mechanic involved indicated that this was a known problem with the ford escort. this comment was further substantiated by another mechanic and the auto parts dealer where the replacement parts were purchased. when contacting a ford dealership, the service manager i spoke with seemed familiar with the problem, stating that if the car had less than 100,000 miles, i would be covered. however, she later came back and said there was no recall in effect. if this is a known problem, i would expect there would be some sort of recall notice. furthermore, i was told, that if the spring shifted while driving, it could come into contact with the tire, causing a severe blowout and accident.*ak | |||
| SUSPENSION - REAR | |||
| 10/09/2002 | 1 | 12/01/2001 | |
| Upon annual state inspection, it was discovered that both rear coil springs had broken, fortunately both in a way that had not caused tire damage. speedometer fluctuates greatly and creates buzzing-like noise at speeds greater than 55 mph. mr | |||
| 04/19/2002 | 1 | 02/01/2095 | |
| No summary listed for above vehicle. *ak | |||
| 09/01/1998 | 1 | 09/01/1994 | |
| No summary listed for this vehicle. *ak | |||
| SUSPENSION - REAR - SPRINGS | |||
| 10/05/2004 | 1 | ||
| Rear coil springs broken, told by mechanic that its a common problem. *jb | |||
| 04/01/2002 | 34527 | 2 | |
| The rear coil springs were found broken (both), the front passenger's side coil spring broke when turning in the driveway and as a result, the front tire was punctured. there was a sag in the front end. the date of the first incident was 04/01/2002. *ak *sc *jb | |||
| 10/13/2003 | 1 | 05/01/1995 | |
| 1995 ford escort station wagon - rear springs cracked and rusted through cracked areas. replaced and no compensation by ford for defects. ford motor refused to offer any compensation for the defective rear springs. *la | |||
| 07/01/2002 | |||
| Consumer states that while driving the rear coil springs failed resulting in vehicle stalling. mr | |||
| 12/07/2000 | 2 | 12/14/2000 | |
| Consumer heard a clunking sound, upon inspection he saw that coil springs had broken. *ak. consumer states the rear coil spring broke on dec-7-2000, and the front coil spring on march 25, 2002 which caused damage to a brand new tire.*jb | |||
| 10/01/2000 | 1 | ||
| Right rear coil spring broke. *ak the rear spring breaking is common on these make of vehicle. *yh | |||
| SUSPENSION - REAR - SPRINGS - COIL SPRINGS | |||
| 11/13/2007 | 4 | ||
| Upon state inspection we were told the front and rear coil springs were broken and would cost over 650.00 dollars to repair. unbelievable as it seems it was confirmed by another inspection station.... *tr | |||
| 10/28/2003 | 2 | 11/28/2001 | |
| Twice in the road life of this vehicle, the rear springs have had to be replaced. this vehicle is not used for offroad driving nor is it used to haul heavy loads.*ak | |||
| 10/29/2003 | 1 | ||
| Upon receiving safety inspection, was informed that rear coil springs had broken. *la | |||
| 08/30/2003 | 123752 | 1 | 04/04/1998 |
| Rear coil springs broken. *jb | |||
| 07/25/2003 | 50000 | 2 | 05/01/1995 |
| 1995 ford escort wagon,rear coil spring failure(broken) even the replacement springs are prone to premature failure. under normal driving, why don't these last the life of the car? what renumeration can i expect from ford?*ak | |||
| 12/13/2002 | 51000 | ||
| When i had the car in to repair a leaking radiator i was told that the rear springs of the car were broken - these were replaced along with the two rear tires which had been damaged due to the broken springs. six months later backing out of the driveway the left front spring broke puncturing that tire - per the garage both front springs are broken and must be replaced. since i've had the care in two different garages i've heard that this is a common problem with the ford escorts. | |||
| SUSPENSION - REAR - SPRINGS - LEAF SPRING ASSEMBLY | |||
| 10/30/2001 | 06/01/1995 | ||
| I could not put an accurate date or mileage because i took my car in for the 100,000 mile check up. at that time the dealer (varsity ford) told me the springs were broken. however, i had no indication they were broken (the car stops bouncing at less than 2.5 bounces). i have now taken it to a local shop, illi's auto in ann arbor, mi, and he confirmed that they are fractured. since i have never had an accident, it makes no sense. the repair bill is $963.00. i have spoken with several friends who had to have the rear springs (mounts and struts) replaced for the same reason. furthermore, the repair place my friend took his escort to said that replacing the rear springs has become a standard repair. this should not be. my office-mates 1995 ford contour had front springs that broke. they did a recall on those. your help is appreciated.*ak | |||
| 06/01/2001 | 2 | 01/01/1995 | |
| Both rear springs have broken, causing undo wear of rear tires. *ak | |||
| 04/01/2001 | 1 | 11/01/1995 | |
| Common failure problem of 1995 to 2000 ford exscorts -- rear spring breakage resulting in possible puncture of rear tire by spring. replacement springs do not break -- only the original equipment is a problem accourding to two different repair shops. *ak | |||
| 12/15/2000 | 0 | ||
| While vehicle was being repaired for brakes and technician found a broken rear spring leaf which had to be replaced. *ak | |||
| 10/02/2000 | 2 | 11/01/1994 | |
| Rear springs cracked and are shifting, mechanic said, most wagons crack around 30000 miles.*ak | |||