Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||||
99122 | 06/14/1999 | 606436 | Some vehicles may exhibit a hard / no start condition occurring when the engine block heater is plugged in with temperatures below -18 degrees c (0 degrees f). *tt | 08/20/1999 | |
9874 | 04/13/1998 | 601343 | A new silicone gasket and sealant. *yc | 07/24/1998 | |
97610 | 03/17/1997 | 51990 | Blower motor- chirping or squeaking from blower motor at low speeds. *jd | 07/17/1997 | |
BC9666961001 | 10/01/1996 | 50527 | 2.5l duratec engine exchanges no longer include front end accessory drive component, oil level indicator, water pump belt/tensioner, egr tube, linkshaft bracket or exhaust manifolds. *tt | 05/27/1997 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
01246 | 12/10/2001 | 630515 | Engine oil system priming procedures, service tips for reports of premature engine failure. *tt | 04/18/2002 | |
0214 | 01/21/2002 | 630001 | Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt | 04/11/2002 | |
00188 | 09/04/2000 | 618599 | Concerns with premature failure occuring on the 1.9l motorcraft remanufactured longblock assembly and shortblock assembly due to ingestion of foreign objects remaining in the transferred intake system from the original failed engine. | 04/17/2001 | |
11769 | 08/01/1998 | 615270 | Some vehicles may exhibit brief spark knock on acceleration during hot weather once the engine has thoroughly warmed up. *tt | 01/10/2001 | |
12174 | 11/01/1998 | 613224 | Some vehicles may exhibit a hard start/long crank, cold start stall, cold rough idle concern. *mjs | 06/19/2000 | |
99816 | 05/03/1999 | 606420 | Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt | 08/19/1999 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
982010 | 10/12/1998 | 603695 | Experiencing a buzzing or rattling noise from the exhaust system. *yc | 03/02/1999 | |
9864 | 03/30/1998 | 601312 | Information on a buzzing or rattle noise from the exhaust system. *tt | 07/21/1998 | |
BC0300970201 | 01/02/1997 | 51103 | Mil light on with dtc's p0443 and p1443. *jd | 06/27/1997 | |
BC0490961112 | 11/12/1996 | 50763 | Instructions for replacing diagnosed failed component. *tw | 06/17/1997 | |
BC0407961115 | 11/15/1996 | 50753 | Instructions for replacing diagnosed failed parts. *tw | 06/17/1997 | |
BC9714961101 | 11/01/1996 | 50860 | Diagnostic instructions for servicing evaporative emission purge flow system. *tw | 06/17/1997 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
12295 | 12/01/1998 | 615541 | Some vehicles may exhibit malfunction indicator light on, stall at tip-in from idle, engine hesitation, and / or surge caused by the mass air flow (maf) sensor. *tt | 01/18/2001 | |
982310 | 11/23/1998 | 603724 | Mass air flow (maf)- sensor contamination- service tip. *ak | 03/03/1999 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
01/01/1901 | 4 | ||
1996 ford escort has had cylinder head and gasket replaced four times. the vehicle has low mileage and now it's just sitting. **cc *nm | |||
12/11/1996 | 1 | 12/27/1995 | |
Temperature gauge defective. | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
03/12/2001 | 0 | ||
While driving engine will overheat. also, radiator and fan had to be replaced.dealer did not state what was cause of replacement.*ak | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||
03/12/2001 | 0 | ||
While driving engine will overheat. also, radiator and fan had to be replaced.dealer did not state what was cause of replacement.*ak | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
03/12/2001 | 0 | ||
While driving engine will overheat. also, radiator and fan had to be replaced.dealer did not state what was cause of replacement.*ak | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
05/15/2000 | 1 | 12/01/2099 | |
Valve guide separated from head. got into the cylinder and scored the cylinder walls and the valve droppped. ruined the engine. *ak | |||
06/14/2002 | 1 | 10/01/2000 | |
When talking to a machine shop there is a tech bulletin stating that ford on 94-97 when they baked the powder metal for their intake seats something went wrong and that all seats in head should be replaced. the people at the machine shop said they had to even replace all the pistons in the motors due to the damage caused by the defective seats. and it is all a ford error and they know it | |||
03/12/2001 | 0 | ||
While driving engine lost power. had taken vehicle to dealer where they said that problem was head gasket that blewout. *ak | |||
02/22/2001 | 1 | 08/30/1996 | |
While traveling at 10 mph and going through traffic light car died. took to dealer, and they said valve seals let loose. seal runs everything to the point that it's not repairable.*ak | |||
01/19/2001 | 1 | 05/01/1997 | |
I was driving up a hill on my way to work. i heard a bang and then a clattering sound. i was able to get the car to work and then to mclean ford a total of about 35 miles. they looked at the car that friday and said they'd have to look futher on monday. they also told me it didn't look good. they said something about a piston. on monday afternoon they called me and said that the engine needed to be replaced. however, they said they had good news - ford would pay for $2,000 of the repair. my question is why would ford pay $2,000. was it because of a hidden warrenty. if so then why should i have to pay the remainder $698.39. s there such a thing a hidden warrenties. if it was a defect in the engine why should the consumer have to pay?*ak | |||
05/11/2000 | 1 | ||
The engine was replaced due to broken valve seats inside the cylinder which damaged the pistons, the consumer feels that ford should pay for this expense due to the low mileage of the vehicle and because the vehicle is very well maintenanced. *slc | |||
07/14/2000 | 05/01/1996 | ||
# 4 piston disentigrated ruining engine block. stoped for red light and car acted as if it was going to stall. drove to bank parking lot 1 block away and turned car of. tried to restart car and made engine noise. turned car off called western slope ford to speak with service department to see if i could get it towed into garage. no return call from them. had another shop tow and inspect. *ak | |||
08/01/2000 | 1 | 11/01/1998 | |
At stop light #4 cylinder dropped valve seat destroying head and all 4 pistons. also engine check light comes on intermittently giving code 1433. replaced solenoid as recommended by tsb and it still fails at random intervals. *ak | |||
02/01/2000 | 1 | 05/01/1999 | |
Consumer has multiple problems with vehicle. engine light stays on & the vehicle won't pass inspection if the dealer can't find out what was wrong with it. there were gas smells coming from hatchback. however, dealer couldn't determine were it was coming from. *ak as of this date 9-13-00 engine light still on, consumer replaced oxygen sensor, timing belt and water pump. kink was found in gas line caused smell coming from front of the car. bracket off of motor mount. *yh | |||
11/15/1998 | |||
Would have no compression in ford engine cylinders. this causes engine to sputter & finally stall out. couldn't restart vehicle & took to dealership. mechanic indicated a problem with the compression to engine. check engine light also came on before vehicle stalled out. *ak | |||
06/06/1999 | 1 | 05/01/1997 | |
The vehicle had the top of the piston brake off on the no# 4 cyclinder, causing a hole to go through the engine while in the start up mode. the ford servise manager said it was a manufacter's defect in the engine and that he said he never saw anything like it. i called ford to see assisstance in paying for this and they said no since there has not been a recall. *ak | |||
06/06/1999 | 1 | 05/01/1997 | |
The vehicle had the top of the piston brake off on the no# 4 cyclinder causeing a hole to go through the engine while in the start up mode. the ford servise manager said it was a manufacter defect in the engine and that he said he never saw anything like it. i called ford to see assisstance in paying for this and they said no since there has not been a recall. | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
12/14/2001 | 1 | 04/01/2001 | |
Check engine light came on, mechanic diagnosed it as a misfire on one of the cylinders. replaced plugs and wires, and two days later the engine dropped a valve destroying engine. this has happened a number of time on this engine according to the nhtsa website. went to ford and stated it was a defect in the engine, they refused all help or compensation. cost was over $4,000. to repair. this definitely a factory defect, and should be picked up by ford. no line of engines should be failing at 60-70,000 miles, like these are. $4,000. to repair. *ak | |||
05/01/2001 | |||
Vehicle will stall in hot weather and at any speed, this happens on a daily basis.*ak | |||
03/12/2001 | 0 | ||
While driving on the high way engine blewout without a prior warning, leaving vehicle without power on road.*ak | |||
7 | 04/04/1997 | ||
Engine light has came on repeatedly, dealer never found major problem, the light started coming on again and vehicle would cut off when put in to gear, at 73000 miles engine failed. *slc | |||
02/01/2000 | 1 | 05/01/1999 | |
Consumer has multiple problems with vehicle. engine light stays on & the vehicle won't pass inspection if the dealer can't find out what was wrong with it. there were gas smells coming from hatchback. however, dealer couldn't determine were it was coming from. *ak as of this date 9-13-00 engine light still on, consumer replaced oxygen sensor, timing belt and water pump. kink was found in gas line caused smell coming from front of the car. bracket off of motor mount. *yh | |||
12/10/1999 | 3 | 02/01/1996 | |
There was an explosion in the engine, roughly work of the engine 5 to 10 seconds with metal sounds in the engine, then the engine completely shut down. found the 3rd code, 2nd code (a/c hi-pressure switch intermitent-dirty connector). *ak | |||
12/10/1999 | 1 | 02/01/1996 | |
First heard a explosion in the engine, after thet the engine ran rough 5-10 sec and shutdown. performed the compression test and found cylender 4 compression at 0(zero) and 30% leaked. replaced the engine with a new one. problems repeted with the new engine two times( one time in the town road and anather time on the highway). both times the engine was shutdown. *ak | |||
06/23/1999 | 1 | 05/01/1996 | |
No summary. | |||
01/01/1997 | 3 | ||
Speedometer malfunctioned, causing an incorrect reading which is higher than it should be. dealer replace speedometer 3 times. also engine problems. please provide further information. *ak | |||
07/01/1999 | 1 | 07/01/1996 | |
Engine blew out resulting in vehicle smoking. nlm | |||
09/27/1998 | |||
Engine failed. | |||
01/11/1997 | |||
Check engine light: check engine light came on while driving and vehicle cut off. had vehicle towed. last week check engine light came on again, drove vehicle about five miles and it cut off again. had the vehicle towed to the house, called zone office next morning and was told to see what color light was, and light was yellow. vehicle started the next morning. third failure has occurred and dealer has called and said come pickup the car because ford cannot fix this problem at this time. *ak | |||
02/23/1997 | 3 | 08/01/1996 | |
`vehicle stalls while driving. ownerand has vehicle at dealer. owner is concerned for her safety because vehicle can stall frequently and at anytime. *ak | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||
05/04/2004 | 1 | ||
Timing belt broke while driving the vehicle on highway. although luckily there was no injury, i was surprised to find similar report from the internet whose vehicle was manufactured during the same period. i think someone has to informed the owner to check the timing belt or reccomend a replacement before anyone get hurt. the vehicle is ford escort lx 96, manufacture on 12/95.*ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
11/15/1999 | 15 | 08/01/1996 | |
Seat belt became stuck midway on numerous occasions, finally it came off the track. i do not have a seat belt to wear now. engine check light problem began at under 10,ooo mi vehicle was brought into dealer was repaired (maybe? or was it only reset?) oxygen sensor' s (2 )had to be replaced to pass emission test. not covered under warranty. passenger door had problem took to dealer who sort of fixed it. at least one could open it from the inside. but it was difficult. eventually problem resurfaced. i have noticed that many of the problems i have had with the seat belts and with the check engine light are not an uncommon occurence. i am a chicago police officer and i notice that the check engine light is always on in the ford squad cars. there are problems which needs to be addressed. the seat belt issue needs to be addressed immediately. until i saw your web info in a magazine, i was not aware there was any recourse other than to complain to the manufacturer which is fruitless. perhaps your number and information need to be listed on the vehicle information books that are supplied to new car buyers. i only wonder how many other consumers have had similar problems that have not been reported other than to ford's customer service. *ak . | |||
11/26/1996 | 2 | 05/30/1996 | |
Oxygen sensor failed; also automatic seat belts locked during deployment, injuring driver and wife and gas gauge malfunctioned, is off by at least 3 gallons. *ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||
06/20/1996 | 1 | 02/20/1996 | |
Egr sensor assembly failed. |