Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| TIRES | |||||
| 0637 | 01/01/2006 | 10019384 | Low tire indicator on - tpms system sensor wake up. *tt | 03/13/2006 | |
| 052624 | 01/01/2005 | 10018938 | Vibration diagnosis - tire/wheel runout. *tt | 01/25/2006 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| TIRES | |||
| 08/01/2011 | 68874 | ||
| Tl-the contact owns a 2005 ford explorer, equipped with goodrich touring t/a tires. the tire size was p235/75/r16 and the dot number was ap70l2113710. the contact stated that there was extreme and inconsistent tread wear on the tires. during inclement weather, the vehicle would hydroplane on the highway. the dealer and manufacturer were notified, but stated that there was nothing that they were able to do to assist. the vehicle was not repaired. the failure mileage was 58,575 and the current mileage was 68,874. the vin was unavailable. sm. | |||
| 08/01/2011 | 68874 | ||
| Tl- the contact owns a 2005 ford explorer, equipped with goodrich, touring t/a tires. the tire size p235/75/r16, dot number ap70l2113710. the contact stated that there was extreme and inconsistent tread ware to the tires. during increment weather the vehicle would hydroplane on the highway. the dealer and manufacturer were notified, but stated that there was nothing that they were able to do to assist the contact. the vehicle was not repaired. the failure mileage was 58,575 and the current mileage was 68,874. the vin was unavailable. nw | |||
| 03/15/2009 | 1 | ||
| Bulge in sidewall of tire. *tr | |||
| 08/20/2007 | 14000 | 1 | |
| Tires have small cracks along tread lugs and sidewall tread lugs. i am afraid they will blow out at anytime. *tr | |||
| TIRES - PRESSURE MONITORING AND REGULATING SYSTEMS | |||
| 09/03/2012 | 72000 | ||
| Tl- the contact owns a 2005 ford explorer. the contact stated that the panel under the rear window split around the outside of the window, which extended to the ford emblem. the damage became progressively worse over time and the contact was concerned that the window could explode when she drove through a car wash. the contact also stated that heat could be a factor in the failure. in addition, the rear latch failed to engage when she attempted to close the rear window. the dealer was contacted and advised that she would be responsible for the repair costs since there were no recalls for the failure. also, the tire sensor gauge remained illuminated at all times. the tire mechanic stated that the failure was a common problem that could have been caused by the spare tire. the contact stated that she had to check the air pressure of the tires on a continual basis. the vin was not available. the failure mileage was 72,000. kmj | |||
| 09/03/2012 | 72000 | ||
| Tl- the contact owns a 2005 ford explorer. the contact stated the panel under the rear window split around the outside of the window which extended to the ford emblem. the damage became progressively worse over time. a collision mechanic stated they were familiar with the failure. she is concerned that the window could explode when she drives through the car wash. the failure began approximately one month ago. the heat could be a factor. the rear latch also failed to engage when she attempted to close the rear window. the ford dealer advised her that she would be responsible for the repair cost since there were no programs to assist with the repairs. the tire sensor gauge also remains illuminated at all times. the tire mechanic stated it was a common problem that could be caused by a spare tire; however, she needs to check the air in the tires on a continuous basis. the vin was not available. the failure mileage was 72,000. rk | |||
| 03/15/2010 | |||
| My 2005 ford explorer came with metal valve caps on the tires, when i brought it in for service with a low pressure signal on, the dealer told me that the valve caps were frozen onto the stems, and if he tried to take off the caps, they would snap the sensors in the tires, and it would cost approximately $600. to replace all four sensors. i responded that it would cost $600. to put air in the tires because of a design defect? the response was yes. my point, if you did not have the money to correct a mfr's design error, you are riding on under-inflated tires, creating a potentially hazardous situation | |||
| 07/20/2010 | 35000 | ||
| Have owned 2005 ford explorer since new. after 35,000 miles the gas gauge started to bottom out on empty followed by a service engine soon light staying on. the gauge will start working again off and on but it's not reliable. tried running a fuel cleaner through it a couple of times and did nothing for it. also the tire pressure monitor says it's reading a bad sensor in one of the wheels. this vehicle is well taken care of and babied by my wife. there seems to be alot of consumers having the exact same troubles with the same vehicles. why is ford not held liable for these defects? this was not a budget low cost car. we paid over $36000.00 for this suv. please help us in any way you can. | |||
| 09/18/2008 | 100000 | 1 | |
| I was removing caps on valve stems to check tire pressure when the valve stem broke off in the cap. it immediately deflated the tire completely! i was lucky that i was not driving. the tire was completely flat and coming off the rim. i had the spare tire put on. when i went to the ford dealer said that they had alot of vehicles in that the valve stems had broken off. very dangerous. i am now afraid that the valve stems on the other tires could do the same thing. because they also have tire sensors in valve stems it is very costly to replace and only a ford dealer can get the part and recalibrate the computer for the sensors. *tr | |||
| TIRES - TREAD/BELT | |||
| 12/17/2007 | 29100 | 1 | 06/28/2005 |
| Tl*the contact owns a 2005 ford explorer. the vehicle has michelin cross touring (na), size lt235/70/r16 tires. while driving approximately 70 mph, the passenger side front tire blew out without warning. the contact pulled off the road and noticed that the only thing holding the tire to the vehicle was the tire mount. prior to operating the vehicle, the tire pressure was normal. the dealer stated that the tire tread began to separate and the tread was 4 and 5/30 seconds. the contact has pictures. the current and failure mileages were 29,100. updated 02/12/08. *lj the tire blow caused damaged to the vehicle. | |||