Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
06213 | 06223 | 10019380 | White smoke, lacks power, exhaust odor, surges, runs rough, or no start - 6.0l. *tt | 03/13/2006 | |
19020 | 01/01/2006 | 10019080 | Part changes on vehicles built after january, 2006. casting and machining changes. *tt | 02/10/2006 | |
05B35 | 01/01/2006 | 10019024 | Customer satisfaction program 05b35 - the engine control modules may not be calibrated to the latest software levels, adversely affecting the performance and reliability of the engine. *tt | 02/09/2006 | |
041601 | 11/14/2005 | 05228 | 10018745 | Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt | 01/12/2006 |
051713 | 10/07/2005 | 05249 | 10018062 | Coolant degas bottle overflow. *tt | 12/14/2005 |
18884 | 10/01/2005 | 10017810 | Hard start, no start and/or other symptoms caused by a high pressure oil system leak - service tip. *tt | 12/01/2005 | |
05215 | 10/31/2005 | 10017806 | Buck/jerk or surge - 6.0l vehicles built before 8/22/2005. *tt | 11/30/2005 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
052623 | 01/01/2006 | 0638 | 10019385 | Coolant degas bottle overflow - 6.0l. *tt | 03/13/2006 |
05249 | 01/01/2005 | 052623 | 10018939 | Coolant degas bottle overflow. *tt | 01/25/2006 |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
0714 | 10021236 | Lack of cooling fan operation. *kb | 03/23/2007 | ||
ENGINE AND ENGINE COOLING - ENGINE | |||||
TSB-09-20-12 | 04/01/2010 | 10032613 | Ford: some super duty trucks equipped with a 5.4l 3v or 6.8l 3v engine may experience premature automatic shut off of the fuel fill nozzle. *pe | 04/19/2010 | |
062401 | 10022293 | 6.0l diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct. *kb | 07/25/2007 | ||
19772 | 05/01/2007 | 10021978 | Power steering pump pulley alignment. *kb | 06/27/2007 | |
19614 | 02/01/2007 | 10021619 | Air filter water ingestion / snow packing with codes p0103. *kb | 06/12/2007 | |
07515 | 10021464 | 6.0l oil seep or boost pressure leak at hot side charge air cooler duct. *kb | 04/27/2007 | ||
0754 | 10021462 | Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start. *kb | 04/27/2007 | ||
0727 | 02/01/2007 | 10021278 | 6.0l - reduced engine performance - high altitude. *kb | 03/28/2007 | |
06239 | 10021233 | Hesitation, runs rough, or surge either on acceleration or during idle in gear and occurs right after initial cold engine start up. *kb | 03/23/2007 | ||
19375 | 09/01/2006 | 10021229 | Watch for oil flow from the base engine oil pump. vehicles equipped with a 6.0l diesel engine. *kb | 03/23/2007 | |
06229 | 10021234 | 6.0l - mil on with dtc p2138, p2139, and p2140. *kb | 03/23/2007 | ||
19247 | 06/01/2006 | 10021173 | Oil flow from the base engine oil pump. *kb | 03/19/2007 | |
061811 | 06258 | 10021165 | Service calibration update - loss of rpm on deceleration - 6.8l. *kb updated 07-25-07. *kb | 03/15/2007 | |
061612 | 10021055 | Service calibration update - loss of rpm on deceleration - 6.8l. *kb | 02/27/2007 | ||
061912 | 10020792 | Diagnostic trouble codes (dtc) p0340, p0344, p0345, p0349. are found. *kb | 01/16/2007 | ||
06226 | 10020750 | Buck/jerk steady throttle or slight tip in 6.0l. *kb | 01/05/2007 | ||
052625 | 01/01/2006 | 0697 | 10020069 | Misfire, lack of power, buck/jerk, excessive smoke or crank/no start. *tt | 07/18/2006 |
0646 | 01/01/2006 | 10019915 | High pressure system diagnostics - 6.0l for a hard start/long crank or no start condition due to low injection control pressure (icp). *tt | 05/12/2006 | |
051015 | 01/01/2005 | 05255 | 10018935 | 5.4l 3v with p030x and/or p0316 accompanied by spark knock. *tt | 01/25/2006 |
05132 | 01/01/2005 | 05183 | 10016845 | Diagnostic trouble code (dtc) p0340 and or p0344-5.4 3v engine. *sc | 10/12/2005 |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
TSB-09-20-12 | 04/01/2010 | 10032613 | Ford: some super duty trucks equipped with a 5.4l 3v or 6.8l 3v engine may experience premature automatic shut off of the fuel fill nozzle. *pe | 04/19/2010 | |
TSB-08-18-6 | 09/01/2008 | 10027985 | Ford truck: some trucks equipped with a 6.0l diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp). *pe | 02/25/2009 | |
TSB-08-9-9 | 10/23/2008 | 10026387 | Ford: 6.0l diesel hard start/long crank/no start du to low injector control pressure (icp). ipe | 10/23/2008 | |
19521 | 12/01/2006 | 10022229 | Lack of power or lack of performance condition when operated above 5,000 feet of altitude. *kb | 07/23/2007 | |
19529 | 12/01/2006 | 10022233 | Misfire and dtc p0300. *kb | 07/23/2007 | |
19537 | 12/01/2006 | 10022236 | Misfire and dtc p0300. *kb | 07/23/2007 | |
19728 | 04/01/2007 | 10022243 | Lack of power due to low fuel pressure - fuel tank liner seperation. *kb | 07/23/2007 | |
19244 | 06/01/2006 | 10021235 | Runs rough or misfire due to a stuck valve. *kb | 03/23/2007 | |
06176 | 10021231 | High pressure system diagnostics - 6.0l engines. *kb | 03/23/2007 | ||
05135 | 01/01/2005 | 10016846 | Oil leak or boost pressure leak at hot side charge air cooler (cac) duct-6.0l diesel engine. *sc | 10/12/2005 | |
05139 | 01/01/2005 | 10016842 | Diesel exhaust smell in cab-6.0l engine. *sc | 10/12/2005 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
19245 | 06/01/2006 | 10020150 | Repeat turbocharger or vgt replacement. *tt | 07/28/2006 | |
18694 | 06/01/2005 | 10017873 | Lack of power and/or dtc p2263 or p0299 after turbocharger replacement - service tip. *tt | 12/06/2005 | |
ENGINE AND ENGINE COOLING - ENGINE - OTHER FUEL TYPES - TURBO-CHARGER | |||||
20228 | 04/01/2008 | 10024865 | 1999-2008 7.3l/6.0l/6.4l/4.5l diesel f-super duty - clean the charge air cooler (cac) system after certain turbo or engine failures - service tip. *nj | 06/03/2008 | |
08-2-11 | 03/01/2008 | 08-4-7 | 10024325 | 6.0l turbocharger carbon deposit diagnostics and service tips. *nj updated 5/29/08. *nj | 04/04/2008 |
06171 | 06183 | 10021232 | 6.0l turbocharger carbon deposit diagnostics and service tips - lack of power, white or black smoke, surge, p0238, p0299, p0404, p2262, and/or p2263. *kb | 03/23/2007 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
05254 | 01/01/2006 | 0625 | 10018946 | Exhaust smoke and/or smell, harsh transmission shifts -- 6.0l. *tt | 01/25/2006 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
07219 | 10/01/2007 | 10023855 | 6.0l--mil on--p0401, p0402, p0404, p1335--lack of power or surge with some 2003-2007 f-super duty, 2003-2005 excursion and 2004-2008 e-series vehicles. *nj | 02/06/2008 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE | |||
06/01/2010 | 130000 | ||
Tl* the contact owns a 2006 ford f250 super duty. the contact stated that the vehicle stalled numerous without warning and while driving at any speed. the vehicle was taken to a local mechanic where the head gasket, egr valve, and the go plug box were replaced. the failure was not corrected. the vehicle continued to stall without warning and the engine could no longer be started. the vehicle was towed to the contact's residence. the vehicle was not repaired. the manufacturer was made aware of the failure and denied assistance with the repair. the failure mileage was 130,000 and the current mileage was 140,000. | |||
06/01/2010 | 130000 | ||
Tl-the contact owns a 2006 ford f250 super duty. the contact stated that the vehicle stalled numerous without warning and while driving at any speed. the vehicle was taken to a local mechanic where the head gasket, egr valve, and the go plug box were replaced. the failure was not corrected. the vehicle continued to stall without warning and the engine could no longer be started. the vehicle was towed to the contact's residence. the vehicle was not repaired. the manufacturer was made aware of the failure and denied assistance with the repair. the failure mileage was 130,000 and the current mileage was 140,000. kmj | |||
ENGINE AND ENGINE COOLING | |||
09/01/2011 | 89000 | ||
Tl-the contact owns a 2006 ford f-250 sd. the contact stated that while driving 50 mph, he noticed that the vehicle was overheating. after pulling over he noticed that there was smoke coming from the engine and that there was no coolant in the reservoir. the vehicle was not inspected by a dealer nor repaired. the manufacturer was contacted and they advised him that the vehicle would have to be diagnosed at a dealer before going any further. the failure and current mileages were approximately 89,000. kmj | |||
09/01/2011 | 89000 | ||
Tl-the contact owns a 2006 ford f-250 sd. the contact stated that while driving at various speeds he noticed that the vehicle read overheating. after pulling over he noticed that there was smoke coming from the engine and that there was no coolant in the reservoir. the vehicle has not been inspected by a dealer nor was it repaired. the manufacturer was contacted and they advised him that the vehicle would have to be diagnosed at a dealer before goung any further. the failure and current mileages were approximately 89,000. tb | |||
01/21/2011 | 60000 | ||
Tl- the contact owns a 2006 ford f250 sd. the contact stated while driving approximately 25 mph the engine light illuminated. the vehicle was taken to the dealer whom performed a diagnosed that located the failure at the engine erg valve. the vehicle has not been repaired. the manufacturer will not assist with the repair, because the vehicle was out of warranty. the failure and the current mileage were 60,000. li | |||
05/26/2010 | 200000 | ||
Tl-the contact owns a 2006 ford f-250 super duty. the contact stated that she has been experiencing recurring engine failures in which the vehicle will sputter and the exhaust fumes would be white. the contact also stated that the vehicle currently would not start and she has had to repeatedly clean the egr valves. the vehicle was taken to an authorized dealer where the contact was informed the engine needed to be replaced. the vehicle was not serviced. the failure mileage was 200,000 and the current mileage was 215,000. sm. | |||
05/12/2009 | 43000 | ||
Complete engine failure in one day on ford f250 5.4 gas engine with 43,000 miles. *tr | |||
10/28/2006 | 47000 | 1 | |
Vehicle looses power,stalls sparkplug failure/breakage sparkplugs replaced at customer expence. have old parts. *tr | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
05/08/2010 | 41000 | ||
The egr valve is a defective part on my 06 super-duty it has over heated on me the last two times i took my rv out ,after checking out after market parts stores i see they have one availble that keeps it running cool.after doing more research its a well known fact that its a defective part along with the weak head bolts.i also heard that last year in 2009 that ford started repairing the egr on vehicals that were brought in that have factory warrenty on them. my question is why no recalls have been isued ! ! ! ! | |||
03/31/2010 | 69806 | ||
2006 ford f250 super duty, diesel, 6.0 l, 4x4, crew cab, short bed: total loss of throttle response while driving. the engine runs, but the truck completely stops and will not move when the accelerator is pressed. there is no advance warning. it just stops moving right where it is. this has happened on several occassions over the last few months. the egr valve has been replaced several times or cleaned the other times, but the vehicle is unsafe on the road because it stops suddenly right in the middle of the traffic lane. why hasn't a recall been made on the egr and related parts....everytime we take it to the shop that's all that's in there for the same reasons!! | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
05/01/2011 | 125000 | ||
Tl- the contact owns a 2006 ford f-250 sd. the contact stated that the vehicle would over heat and smoke would come from the hood of the vehicle. the dealer diagnosed that the contact would need to replace the head gasket. the manufacturer was also notified of the failure. the failure was not repaired. the failure mileage was 125,000 and the current mileage was 130,000. nw | |||
12/15/2010 | 162355 | ||
2006 f250 superduty 6.0: this vehical stalls while driving down the road just about every day. i noticed that there was a recall for the same engine on the 2004 f250 for the same thing. it stalled last week going into a hard turn and i ran off the road because i was unble to controll the vehical after it stalled. it could have been leathal if there were more traffic....i had it towed ($250) it has been in the shop for a week....looking for answeres.. this vehical is a death trap........ | |||
07/24/2010 | 125000 | ||
Filed complaint previously. egr and oil cooler failure...caused engine failure and hydrolock situation. total cost of repairs to my vehicle $8650. sure would be nice for ford to have a hand in the repairs due to their faulty engine design. ford refused to help with repair cost. 120k miles. please launch an investigation into these complaints. i believe you will find enough evidence to warrant an investigation. i am sure that the lobbiest at ford are doing thier job to keep this from becoming a recall situation. it is hurting no one but the owners of this 6.0l diesel engine!!! we need your help! | |||
07/25/2010 | 128000 | ||
Ford 6.0l diesel egr and oil cooler issues. how many millions of dollars are the owners of these engines going to have to shell out before ford recalls this motor. when these components go out, there is a total loss of throttle response, and large clouds of white smoke that pour out of the exhaust which poses a huge safety concern. when mine failed, i was able to limp through an intersection just before an 18 wheeler broadsided me. i had my wife and kids in the vehicle with me and we almost lost an entire family. get it fixed ford!!! nhtsa has to pressure ford into getting this recall started. this is an ongoing issue with these motors, and it needs to be corrected on ford's account. | |||
07/24/2010 | 125000 | ||
Ford f-250 with 6.0l diesel engine. continuous issuse regarding enging performance and reliablity. egr cooler failure, oil cooler failure and burning coolant thru exhaust. poses a huge safety issue for cars trailing a failing engine due to thick white clouds of smoke. ford is aware of the issue but refuses to aknowlege the problem with the engine and issue a recall. | |||
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||
08/06/2007 | 21000 | 2 | 09/01/2006 |
I have a new 2006 ford f-250 sd diesel 6.0l. the first year i owned it 7,000 miles i blew a head gasket. it took ford more than 5 weeks to fix it and 2 different dealerships of hassle. 6 months later the problem has happened again. i spoke with ford they gave me an appointment 1 month after i called to set the appointment. after that month dealership took 4 weeks of my time with my truck and didn't fix a thing. told me they were to busy to deal with me and i should take it to another dealership to get fixed. got ford customer relations involved and they have done nothing. i now have my unfixed truck in my driveway with another appointment 2 weeks away and that dealership says it will be some time before they can get to it. no customer service plus they haven't offered me any money for car rental fees nothing. please advise. updated 01/11/08. *lj a complaint was filed with the police. updated 12/12/07. *jb | |||
06/29/2006 | 6600 | 1 | 02/16/2006 |
Dt*: the contact stated the vehicle pumped out a lot of blue and white smoke from the exhaust. the fumes entered the vehicle, and the smell was worse when driven 45 mph. also, there was a problem with the egr belt and egr cooler. the vehicle was taken to the dealership three times, but could not be fixed. | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
03/31/2010 | 69806 | ||
2006 ford f250 super duty, diesel, 6.0 l, 4x4, crew cab, short bed: total loss of throttle response while driving. the engine runs, but the truck completely stops and will not move when the accelerator is pressed. there is no advance warning. it just stops moving right where it is. this has happened on several occassions over the last few months. the egr valve has been replaced several times or cleaned the other times, but the vehicle is unsafe on the road because it stops suddenly right in the middle of the traffic lane. why hasn't a recall been made on the egr and related parts....everytime we take it to the shop that's all that's in there for the same reasons!! | |||
05/02/2009 | 57779 | 1 | |
2006 ford f250 super duty, diesel, 6.0 l, 4x4, crew cab, short bed: total loss of throttle response while driving. the engine runs, but the truck completely stops and will not move when the accelerator is pressed. there is no advance warning. it just stops moving right where it is. this has happened five times now within two months and 2500 miles driving. the egr valve has been replaced several times or cleaned the other times, but the vehicle is unsafe on the road because it stops suddenly right in the middle of the traffic lane. *tr | |||
05/02/2008 | 57850 | 1 | |
After letting 2006 f250 diesel warm up for approximately 5mins, proceed to get onto i-35, about 5 miles from the house when i set the cruise control for 70mph everything was fine. within a mile of getting on the highway, truck hesitated and completely stalled. i move the vehicle onto the shoulder of the highway to await a tow. i took it to a ford dealership where they found that the ficm was bad. a day after i picked up the truck, again, the vehicle hesitated for a second before stalling in city traffic. i lost power brakes and power steering and was very difficult to get off of the city streets. currently towed to the dealership again, where the issue is under investigation. concern that if someone other than a 6'4 person was driving this 7500lb vehicle, they may not have been able to steer this vehicle out of the traffic. i've heard of common complaints with the ficm/hpop/egr issues with these trucks and am surprised that no recall has been created by ford. *tr |