Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| FUEL SYSTEM, DIESEL | |||||
| SB-21410 | 07/01/2010 | 10034628 | Ford: some trucks with 6.4l engine will run rough, smokes, or no start due to gasoline or alcohol in the fuel. gasoline/alcohol lack the lubricity of diesel fuel and will cause fuel system failure. *pe | 12/13/2010 | |
| 20020 | 10/01/2007 | 10023437 | Some 2008 f-super duty - 6.4l diesel egr valve and dpf failures due to high sulfur diesel fuel. *nj | 12/11/2007 | |
| 0707 | 06/08/2007 | 10022715 | In some of the affected vehicles, three fuel injectors were subjected to a reverse polarity voltage during engine testing that may have damaged the injector resulting in reduced fuel flow. this may potentially cause the vehicle to run roug | 09/24/2007 | |
| FUEL SYSTEM, GASOLINE | |||||
| 19621 | 02/01/2007 | 10021621 | Lack of power due to low fuel pressure, fuel tank liner seperation. *kb | 06/12/2007 | |
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
| 19813 | 06/01/2007 | 10022657 | Injector circuit open- dtc(s) p0201-p0208 with a misfire/rough running/lack of power condition. *nj | 09/18/2007 | |
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||||
| 19849 | 06/01/2007 | 10022765 | Uvc 15-way connections that are secured by an o-ring. *nj | 09/26/2007 | |
| FUEL SYSTEM, OTHER - DELIVERY - FUEL PUMP | |||||
| 19815 | 06/01/2007 | 10022718 | 2008 f-super duty - 6.4l diesel engine - the fuel cooling pump noise. *nj | 09/25/2007 | |
| FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||||
| 19786 | 06/01/2007 | 10022911 | Distance to empty (dte) and fuel gauge service tip. *nj | 10/04/2007 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, DIESEL | |||
| 03/07/2011 | 171000 | ||
| Tl-the contact owns a 2008 ford f-250 sd. while driving approximately 60 mph the check engine light illuminated on the dashboard. the vehicle was taken to an independent mechanic where the contact was told the failure involved the fuel pressure sensor. the vehicle was not repaired. the failure mileage was 171,000 and the current mileage was 173,000. sm. | |||
| 04/27/2010 | 30130 | 1 | |
| Tank full of diesel fuel contaminated with water and some debris. ford will not warranty but several parts of the fuel system developing rust. this vehicle is equipped with a fuel water separator as standard equipment. so ford has equipped the truck with a fuel water separator but several of the parts in the fuel system are very subject to rust if there is any exposure to water. so as soon as the vehicle is exposed to water in the fuel there are parts that will fail and are not covered by warranty. *tr | |||
| FUEL SYSTEM, GASOLINE | |||
| 10/31/2011 | 114000 | ||
| We where hauling cattle down the highway and lost power at 2500 rpms this was extremely dangerous to be on a highway going 55 mph with a load of cattle and with no warning the truck lost power. we took the truck into the ford dealership and are now having the high pressure fuel injector pump replaced. the cab of the truck has to be taken off to work on this pump it will be at least 18 hours of labor. ford has redesigned the newer motors so that the high pressure fuel injector pump is now in the front of the motor. i really think this should be a recall before more people have this happen to them please look into this... | |||
| FUEL SYSTEM, OTHER | |||
| 07/10/2010 | 30000 | ||
| 2008 ford f 250 super duty diesel 6.4 engine - engine quit running with no warning, would not restart. coasted to the side of the road and had to be towed to dealer. tsb 07-26-2 was performed to fix the known problem of an unprotected wire in the high pressure fuel pump gasket chaffing through. a new and improved gasket with protected wire was installed. luckily i was not towing my boat or travel trailer at the time. this is a serious safety risk and ford should recall all effected vehicles asap! | |||