Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| 06510 | 01/01/2006 | 06112 | 10020135 | 6.0l - mil on with dtc p0460. *tt | 07/26/2006 |
| 06111 | 01/01/2006 | 10020136 | 6.0l - mil on with dtc p2138, p2139, p2140. *tt | 07/26/2006 | |
| 19082 | 10019810 | Lack of power or mil on - turbocharger sticking - revised diagnostics. *tt | 04/28/2006 | ||
| 19071 | 10019817 | Dtc b2900 or b2477 - service tip. *tt | 04/28/2006 | ||
| 052317 | 01/01/2006 | 0629 | 10019378 | Diagnostic trouble codes p0340/p0344/p0345/p0349 - 4.6l 3v and 5.4l 3v. *tt | 03/13/2006 |
| 052615 | 01/01/2006 | 06510 | 10018957 | Mil on with dtc p0460 -- 6.0l. *tt | 01/25/2006 |
| 051511 | 01/01/2006 | 0661 | 10017928 | Diagnostic procedure for trailer tow lights or no power due to open fuse. *tt | 12/07/2005 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 09/05/2011 | 90000 | ||
| Tl* the contact owns a 2006 ford f-350 sd. the contact was driving 25 mph when the engine stalled. the vehicle was taken to a private mechanic where the mechanic advised that the wiring harness needed to be replaced. the manufacturer was contacted, but the vehicle was not repaired. the failure mileage was 90,000 and the current mileage was 114,000. | |||
| 09/05/2011 | 90000 | ||
| Tl- the contact owns a 2006 ford f-350 sd. the contact was driving 25 mph when the engine stalled. the vehicle was taken to a private mechanic where the mechanic advised that the wiring harness needed to be replaced. the manufacturer was contacted, but the vehicle was not repaired. the failure mileage was 90,000 and the current mileage was 114,000. kmj | |||
| 09/05/2011 | 90000 | ||
| Tl- the contact owns 2006 ford f-350 sd. the contact was driving 25mph when the engine stalled. the vehicle was taken to a private mechanic. the mechanic stated the wiring harness needed to be replaced. the manufacturer was contacted, but the vehicle was not repaired. the failure mileage was 90,000 and the current mileage was 114,000 . rds | |||
| 01/10/2010 | 160000 | 1 | |
| On 2006 ford f350 vehicle with 6.0 diesel , the egr coolers have defect that cause them to leak. after reading into this it is a common issue. i took the truck to ford and they stated it is a very common problem and that i should look into an aftermarket cooler since the oem unit fails quite often to the frequency of 2 to 3 within 100,000 miles. this repair is approx. 1000 to 2000 depending on if the head gaskets have been subsequently damaged as well. in my case i had to replace the oil cooler along with egr cooler an egr valve and head gasket. my total bill was $2095.63 ford stated it is a very common problem and has tsb,s on this but has no plans for a voluntary recall. they did state that they will only compensate if instructed to due to a recall. these issues if researched online are more common then people needing any other parts on this vehicle. when these coolers fail the egr get wet and does not function. this can happen at highway speeds with can make you loose power thus loosing hydroboost for braking and steering. *tr | |||
| 08/18/2008 | 50000 | 1 | |
| I have a ford f-350 that has had a violent front end shake at freeway speeds. the shake has been so violent i thought i was going to crash. i have taken it to ford and they change out a couple parts and then it happens again within 20,000 miles. this has happened 4 times since owning the truck (purchased new in nov. 2006). i have also had problems repeatedly with the high pressure oil pump and or electrical that ford cant resolve. the truck is now in the shop again. it cranks but will not start the truck was going down the freeway at 70mph and it just dies and wont restart. they say it is high pressure oil pump and have replaced it 3 times within 50,000 miles. *tr | |||