Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 19020 | 01/01/2006 | 10019080 | Part changes on vehicles built after january, 2006. casting and machining changes. *tt | 02/10/2006 | |
| 04233 | 01/01/2005 | 052625 | 10013408 | Misfire lack of power buck jerk excessive smoke crank no start 6.0l engine diagnostics for fuel system . *eh service tips. *tt | 04/18/2005 |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
| 0714 | 10021236 | Lack of cooling fan operation. *kb | 03/23/2007 | ||
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 062401 | 10022293 | 6.0l diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct. *kb | 07/25/2007 | ||
| 06257 | 10022297 | White smoke, lacks power, exhaust odor, surges, runs rough, or no start. *kb | 07/25/2007 | ||
| 19772 | 05/01/2007 | 10021978 | Power steering pump pulley alignment. *kb | 06/27/2007 | |
| 19614 | 02/01/2007 | 10021619 | Air filter water ingestion / snow packing with codes p0103. *kb | 06/12/2007 | |
| 06237 | 10021485 | White smoke, lacks power, exhaust odor, surges, runs rough, or no start. *kb | 05/08/2007 | ||
| 06163 | 10021482 | No start, no ecm/tcm communications and/or flashing automatic transmission indicator. *kb | 05/08/2007 | ||
| 0754 | 10021462 | Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start. *kb | 04/27/2007 | ||
| 07515 | 10021464 | 6.0l oil seep or boost pressure leak at hot side charge air cooler duct. *kb | 04/27/2007 | ||
| 0727 | 02/01/2007 | 10021278 | 6.0l - reduced engine performance - high altitude. *kb | 03/28/2007 | |
| 0719 | 10021221 | Check engine and/or stop engine light on - cummins engine only. *kb | 03/23/2007 | ||
| 19375 | 09/01/2006 | 10021229 | Watch for oil flow from the base engine oil pump. vehicles equipped with a 6.0l diesel engine. *kb | 03/23/2007 | |
| 06229 | 10021234 | 6.0l - mil on with dtc p2138, p2139, and p2140. *kb | 03/23/2007 | ||
| 0715 | 10021219 | Vehicle diagnostics and programming using ids-6.0l engine and low cab forward with 4.5l engine. *kb | 03/23/2007 | ||
| 06239 | 10021233 | Hesitation, runs rough, or surge either on acceleration or during idle in gear and occurs right after initial cold engine start up. *kb | 03/23/2007 | ||
| 061910 | 10021175 | Check engine light on, and/or stop engine light on. cummins engines only. *kb | 03/19/2007 | ||
| 19247 | 06/01/2006 | 10021173 | Oil flow from the base engine oil pump. *kb | 03/19/2007 | |
| 061811 | 06258 | 10021165 | Service calibration update - loss of rpm on deceleration - 6.8l. *kb updated 07-25-07. *kb | 03/15/2007 | |
| 061912 | 10020792 | Diagnostic trouble codes (dtc) p0340, p0344, p0345, p0349. are found. *kb | 01/16/2007 | ||
| 06226 | 10020750 | Buck/jerk steady throttle or slight tip in 6.0l. *kb | 01/05/2007 | ||
| 05204 | 01/01/2006 | 0657 | 10019924 | Vehicle diagnostics and programming using wds - f-650/750 with 6.0l engine and low cab forward with 4.5l engine. *tt | 05/16/2006 |
| ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
| TSB-08-9-9 | 10/23/2008 | 10026387 | Ford: 6.0l diesel hard start/long crank/no start du to low injector control pressure (icp). ipe | 10/23/2008 | |
| 07153 | 10023233 | Some 2005-2007 f-650 and f-750 vehicles equipped w/ a 6.0l diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp). *nj | 11/05/2007 | ||
| 19521 | 12/01/2006 | 10022229 | Lack of power or lack of performance condition when operated above 5,000 feet of altitude. *kb | 07/23/2007 | |
| 19537 | 12/01/2006 | 10022236 | Misfire and dtc p0300. *kb | 07/23/2007 | |
| 19728 | 04/01/2007 | 10022243 | Lack of power due to low fuel pressure - fuel tank liner seperation. *kb | 07/23/2007 | |
| 19529 | 12/01/2006 | 10022233 | Misfire and dtc p0300. *kb | 07/23/2007 | |
| 06176 | 10021231 | High pressure system diagnostics - 6.0l engines. *kb | 03/23/2007 | ||
| 19244 | 06/01/2006 | 10021235 | Runs rough or misfire due to a stuck valve. *kb | 03/23/2007 | |
| ENGINE AND ENGINE COOLING - ENGINE - OTHER FUEL TYPES - TURBO-CHARGER | |||||
| 08-2-11 | 03/01/2008 | 08-4-7 | 10024325 | 6.0l turbocharger carbon deposit diagnostics and service tips. *nj updated 5/29/08. *nj | 04/04/2008 |
| 06171 | 06183 | 10021232 | 6.0l turbocharger carbon deposit diagnostics and service tips - lack of power, white or black smoke, surge, p0238, p0299, p0404, p2262, and/or p2263. *kb | 03/23/2007 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
| 07219 | 10/01/2007 | 10023855 | 6.0l--mil on--p0401, p0402, p0404, p1335--lack of power or surge with some 2003-2007 f-super duty, 2003-2005 excursion and 2004-2008 e-series vehicles. *nj | 02/06/2008 | |