Ford F Series (medium) 1993

Model F Series (medium) made in 1993 by Ford got 3 consumer complains as well as 32 service bulletins. Consumer complaints with reference, among others things, to fuel system, gasoline and vehicle speed control. Technical service bulletines regarding electrical system and engine and engine cooling.

Model 1993

Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR
95171308/01/199545970Generator-motorcraft 95amp-front bearing concern-fd1060/1460 engines- vehicles built before 7/3/95. *sd04/25/1996
ELECTRICAL SYSTEM - BATTERY
9562003/01/199539914Battery covers for outboard frame-mounted batteries rattle or crack. *tw11/01/1995
9562003/01/19953055700Unknown11/01/1995
ELECTRICAL SYSTEM - STARTER ASSEMBLY
BC323697021102/11/199751861Fd 1060 engines - new design starter motor to alleviate hard start/no start concerns in cold ambients. *tw07/17/1997
94261312/01/199438066Starter stays engaged after key is released. *tw02/07/1995
ELECTRICAL SYSTEM - WIRING
95111506/01/199545087Stall or no start - fuel shutdown solenoid - wiring chafing on fuel injector lines-vehicles built before 10/19/94 with fd1060 engine and bosch p7100 fuel injection pump. *tw11/01/1995
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD
95111506/01/199545087Stall or no start - fuel shutdown solenoid - wiring chafing on fuel injector lines-vehicles built before 10/19/94 with fd1060 engine and bosch p7100 fuel injection pump. *tw11/01/1995
ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY
BC018796010212/01/199546446On f/b series w/ fd 1060 engine there may be a concern regarding insuffi- cient in-cab heat. to resolve this, the current thermostat can be replaced with a new low leak thermostat. the needed parts are available from cummis engine. refer t04/25/1996
95201210/01/199546477The engine coolant temp gauge may read on the cold side of the normal range, or may stay below normal even though the engine is at its proper operating temp on some vehicles. this is caused by the coolant temp sending unit not being positi04/25/1996
ENGINE AND ENGINE COOLING - ENGINE
95151707/01/199545945Leaks - oil - front cover or gear housing vehicles with fd1460 engine. *sd04/25/1996
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE
95171408/01/199545971Engine- 'knocking' noise - when operating engine at 200-2300 rpm - fd1460 engine04/25/1996
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS
94232011/01/199437743Main front end accessory drive belt rolls off. *tw01/06/1995
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE
BC088396100410/04/199650440Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds. *tt04/24/1997
FUEL SYSTEM, GASOLINE - DELIVERY
95201010/01/199546476Hard starting or a no start concern may occur on some vehicles. this may be due to diesel fuel draining out of the fuel injection system back into the fuel tank. this condition causes the injection system to lose its prime which leads to l04/25/1996
POWER TRAIN - AUTOMATIC TRANSMISSION
94242011/01/199437768A driveline vibration/moan may occur when the automatic transmission shifts into converter lockup mode while accelerating or climbing a grade. *tw01/06/1995
POWER TRAIN - DRIVELINE - DRIVESHAFT
94232111/01/199437744Multi-piece driveshaft misalignment with center bearing. *tw01/06/1995
POWER TRAIN - MANUAL TRANSMISSION
BC067896102510/25/199650356Information on aode/4r7w transmission main control & case replacement. *tt04/24/1997
9562003/01/19953055700Unknown11/01/1995
9562103/01/199539915The transmission countershaft bearing end clearance may not be within specification on some vehicles. *tw11/01/1995
SERVICE BRAKES, HYDRAULIC - ANTILOCK
9521210/01/199546478The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par04/25/1996
STEERING - GEAR BOX (OTHER THAN RACK AND PINION)
9552705/01/199545075Steering-power-high efforts in left turns- vehicles with bendix c300n or c500n steering gear and zf power steering pump. *tw11/01/1995
9532702/01/199539234Steering - revised camber specification. *tw03/31/1995
STEERING - HYDRAULIC POWER ASSIST SYSTEM
9562003/01/19953055700Unknown11/01/1995
9552703/01/199539895Steering - power - loss of assist/momentary and random stick/bind at low speeds. *tw11/01/1995
STEERING - RACK AND PINION
9425812/01/199438058Replacement of bendix steering gear with new ross steering gear. *tw02/07/1995
STRUCTURE - BODY
9532502/01/199539233Stationary engine cover cracks. *tw03/31/1995
9532402/01/199539232Front engine cover cracks. *tw03/31/1995
9532302/01/199539231Trucks may crack on the cab floor near the transmission shifter cover area. *tw03/31/1995
SUSPENSION - FRONT - SPRINGS - COIL SPRINGS
9721801/20/199751417Suspension - noise from front spring rear hanger - revised rear spring hanger insulator pad - vehicles equipped with 6000, 7000 or 9000 lb axles built through 10/1/97. *tw06/27/1997
VEHICLE SPEED CONTROL
94202510/01/199439718Throttle - hand throttle difficult to operate. *tw11/01/1995
9541002/01/199539241Lack of power - excessive play at throttle linkage. *tw03/31/1995
9521301/01/199539126New ford holland engine may exhibit the need for frequent throttle linkage adjustments. *tw03/17/1995

Consumer Complaints


Fail datemilesoccurencesPurchase date
FUEL SYSTEM, GASOLINE - DELIVERY
01/01/2001101/29/1993
 Some time ago, my ford f150 was sent a recall notice; the problem was that one fuel tank was sending fuel to the other. i was told it was ok. the event is still occuring with fuel spilling from the fill port. i would like to have the matter reevaluated. the dealer to whichi took the truck is bell ford.*ak
VEHICLE SPEED CONTROL
12/21/20071
 I received a recall notice for cruise control on my 1993 f150 in september and followed instructions for correction to take to a local dealer. at the dealer the cruise control was disconnect to remove fords liability for possible fire and i was told that the fused harness would be available and installed in december. i called my local dealer today and was told it will be around march before the harness is available. what are a consumer's rights to obtain a remedy in a reasonable amount of time? i don't consider over 6 months acceptable and not that ford has essentially removed their liability by disabling the item, they have no impetus to resolve the problem quickly. thanks for your assistance. *tr
VEHICLE SPEED CONTROL - CABLES
12/21/20071
 I received a recall notice for cruise control on my 1993 f150 in september and followed instructions for correction to take to a local dealer. at the dealer the cruise control was disconnect to remove fords liability for possible fire and i was told that the fused harness would be available and installed in december. i called my local dealer today and was told it will be around march before the harness is available. what are a consumer's rights to obtain a remedy in a reasonable amount of time? i don't consider over 6 months acceptable and not that ford has essentially removed their liability by disabling the item, they have no impetus to resolve the problem quickly. thanks for your assistance. *tr

Car dealers selling


StateCityZipNamePhone
AZPHOENIXFORD
VALYNCHBURGAPPLE FORD