Ford F Series (medium) 1995
Model F Series (medium) made in 1995 by Ford got 29 service bulletins. Technical service bulletines regarding electrical system, engine and engine cooling and equipment.
Model 1995
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||||
951713 | 08/01/1995 | 45970 | Generator-motorcraft 95amp-front bearing concern-fd1060/1460 engines- vehicles built before 7/3/95. *sd | 04/25/1996 | |
ELECTRICAL SYSTEM - BATTERY | |||||
95620 | 03/01/1995 | 39914 | Battery covers for outboard frame-mounted batteries rattle or crack. *tw | 11/01/1995 | |
95620 | 03/01/1995 | 3055700 | Unknown | 11/01/1995 | |
ELECTRICAL SYSTEM - STARTER ASSEMBLY | |||||
BC3236970211 | 02/11/1997 | 51861 | Fd 1060 engines - new design starter motor to alleviate hard start/no start concerns in cold ambients. *tw | 07/17/1997 | |
942613 | 12/01/1994 | 38066 | Starter stays engaged after key is released. *tw | 02/07/1995 | |
ELECTRICAL SYSTEM - WIRING | |||||
951115 | 06/01/1995 | 45087 | Stall or no start - fuel shutdown solenoid - wiring chafing on fuel injector lines-vehicles built before 10/19/94 with fd1060 engine and bosch p7100 fuel injection pump. *tw | 11/01/1995 | |
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||||
951115 | 06/01/1995 | 45087 | Stall or no start - fuel shutdown solenoid - wiring chafing on fuel injector lines-vehicles built before 10/19/94 with fd1060 engine and bosch p7100 fuel injection pump. *tw | 11/01/1995 | |
95723 | 04/01/1995 | 41023 | The engine wiring harness may become pinched between the cab and left hand frame rail. *tw | 11/01/1995 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||||
952012 | 10/01/1995 | 46477 | The engine coolant temp gauge may read on the cold side of the normal range, or may stay below normal even though the engine is at its proper operating temp on some vehicles. this is caused by the coolant temp sending unit not being positi | 04/25/1996 | |
BC0187960102 | 12/01/1995 | 46446 | On f/b series w/ fd 1060 engine there may be a concern regarding insuffi- cient in-cab heat. to resolve this, the current thermostat can be replaced with a new low leak thermostat. the needed parts are available from cummis engine. refer t | 04/25/1996 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
951517 | 07/01/1995 | 45945 | Leaks - oil - front cover or gear housing vehicles with fd1460 engine. *sd | 04/25/1996 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
951714 | 08/01/1995 | 45971 | Engine- 'knocking' noise - when operating engine at 200-2300 rpm - fd1460 engine | 04/25/1996 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
942320 | 11/01/1994 | 37743 | Main front end accessory drive belt rolls off. *tw | 01/06/1995 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||||
BC0883961004 | 10/04/1996 | 50440 | Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds. *tt | 04/24/1997 | |
EQUIPMENT - ELECTRICAL - AIR CONDITIONER | |||||
BC1853950705 | 07/01/1995 | 44093 | A/c compressor may be damaged due to the overall length of the hose between the accumulator and the compressor. the hose may not be adequate to to allow for engine movement. *tw | 11/01/1995 | |
FUEL SYSTEM, GASOLINE - DELIVERY | |||||
952010 | 10/01/1995 | 46476 | Hard starting or a no start concern may occur on some vehicles. this may be due to diesel fuel draining out of the fuel injection system back into the fuel tank. this condition causes the injection system to lose its prime which leads to l | 04/25/1996 | |
POWER TRAIN - DRIVELINE - DRIVESHAFT | |||||
942321 | 11/01/1994 | 37744 | Multi-piece driveshaft misalignment with center bearing. *tw | 01/06/1995 | |
POWER TRAIN - MANUAL TRANSMISSION | |||||
BC0678961025 | 10/25/1996 | 50356 | Information on aode/4r7w transmission main control & case replacement. *tt | 04/24/1997 | |
BC0844961008 | 10/08/1996 | 50429 | E4od trans may emit a tick/rattle noise when driving at light loads in 1st gear at 1100 to 1800 rpm rpm. *tt | 04/24/1997 | |
POWER TRAIN - MANUAL TRANSMISSION - FLOOR SHIFT ASSEMBLY | |||||
13736 | 01/01/2000 | 612728 | Some vehicles may experience oil leaking from the shift lever. *mjs | 06/12/2000 | |
SERVICE BRAKES, AIR - SUPPLY - COMPRESSOR | |||||
BC1300950906 | 09/01/1995 | 45754 | Improved air compressor support bracket. *tw | 04/25/1996 | |
SERVICE BRAKES, AIR - SUPPLY - GOVERNOR | |||||
942213 | 10/01/1994 | 37754 | Mounting location of the air compressor governor interfering with power steering hose. *tw | 01/06/1995 | |
SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||||
95212 | 10/01/1995 | 46478 | The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par | 04/25/1996 | |
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||||
BC3461950201 | 02/01/1995 | 39132 | The hydromax brake reservoir mounting bracket may seperate or fluid may slosh from the reservoir. *tw | 03/17/1995 | |
SERVICE BRAKES, HYDRAULIC - POWER ASSIST | |||||
BC0203960102 | 12/01/1995 | 9-10-13 | 46415 | W/ hydraulic brakes & tilt hood, hydraulic fluid may leak from the brake pump reservoir. tsb 95-10-13 provided a reservoir support bracket to minimize leakage. it was determined that this repair was not entirely effective. engineering is w | 04/25/1996 |
STEERING - GEAR BOX (OTHER THAN RACK AND PINION) | |||||
95327 | 02/01/1995 | 39234 | Steering - revised camber specification. *tw | 03/31/1995 | |
STRUCTURE - BODY | |||||
95325 | 02/01/1995 | 39233 | Stationary engine cover cracks. *tw | 03/31/1995 | |
SUSPENSION - FRONT - SPRINGS - COIL SPRINGS | |||||
97218 | 01/20/1997 | 51417 | Suspension - noise from front spring rear hanger - revised rear spring hanger insulator pad - vehicles equipped with 6000, 7000 or 9000 lb axles built through 10/1/97. *tw | 06/27/1997 | |
VEHICLE SPEED CONTROL | |||||
942025 | 10/01/1994 | 39718 | Throttle - hand throttle difficult to operate. *tw | 11/01/1995 |