Ford F Series 1971-2008

Car model


Ford F Series model

Ford F Series bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
AIR BAGS
BC522796100110/01/199650502Information for air bag dtc b1813 observe the air bag lamp flash out code & perform the appropriate pinpoint test for the flash out code. *tt1997-04-24
ELECTRICAL SYSTEM
TB-08-25812/29/200810029029Jerr-dan: anti stall feature for ford f series light duty chassis with v10 gas engine and an engine drive clutch pump. model years unknown. *pe2009-06-12
BC520796100110/01/199650483Information for servicing the electronic/hydraulic control unit (ehcu) on 4wabs. *tt1997-04-24
ELECTRICAL SYSTEM - IGNITION
BC520496100110/01/199650480Concerns of check engine light (mil) w/codes p0300 thru p0308 & engine runs rough/misses may be due to a spark plug wire boot that is not fully seated on the spark plug. *tt1997-04-24
ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH
BC519096100110/01/199650468Vehicles experiencing chafing on the 14401 wire harness causing the accessory fuses to become open (primarily the cigar fuse). *tt1997-04-24
ENGINE AND ENGINE COOLING - ENGINE
TB-08-25812/29/200810029029Jerr-dan: anti stall feature for ford f series light duty chassis with v10 gas engine and an engine drive clutch pump. model years unknown. *pe2009-06-12
BC517396100110/01/199650452On various 4.0l applications the oil indicator tube (dip stick) is coming into contact w/ the crankshaft. *tt1997-04-24
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE
BC518196100110/01/199650459Engine oil leak at the oil pan, front cover &/or the front & rear crankshaft oil seal. *tt1997-04-24
BC518396100110/01/199650461An oil leak in the area of the engine oil filter may be caused by a damaged or mis-installed (i.e. rolled over, pinched, sheared, nicked, etc.) oil pump body seal. *tt1997-04-24
BC517296100110/01/199650451Information for concerns of check engine light 'on' on 4.2l/4.6l/5.4l/6.8l vehicles. *tt1997-04-24
BC518296100110/01/199650460Information on correcting an oil pan gasket leak. *tt1997-04-24
EQUIPMENT - ELECTRICAL - AIR CONDITIONER
BC517596100110/01/199650454Concerns of a/c going to defrost mode when climbing grades or accelerating are likely caused by vacuum leaks. *tt1997-04-24
FUEL SYSTEM, GASOLINE
830804/01/2000613636Instructions for diagnostics tests on bi-fuel vehicles. *tt2000-07-28
830803/01/2000612726Information containing instructions for diagnostics tests on bi-fuel vehicle. *tt2000-06-12
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP
BC517696100110/01/199650455Connection between the sender (9a299) & the fuel pump (9350) changed from the existing spade terminal to an eyelet terminal which is secured under the top sender mount screw. *tt1997-04-24
BC465196100110/01/199650443Vehicle may not start after being parked in below freezing temps. may be due to moisture freezing in the fuel pump relay contained within the ccrm (constant control relay module). *tt1997-04-24
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS
1396503/01/2000612888Xc3z-9229-aa fuel injector o-ring kit for 1994.5 and newer vehicles. *tt2000-06-13
831403/01/2000612737Subject regarding 1994.5 and newer vehicles serviced with fuel injector o-ring kit xc3z-9229-aa. *tt2000-06-12
FUEL SYSTEM, GASOLINE - STORAGE
1395903/01/2000612875Informational instructions for diagnostics tests on bi-fuel vehicles. *tt2000-06-13
POWER TRAIN - AUTOMATIC TRANSMISSION
BC518596100110/01/199650463Vehicles may exhibit a grinding noise while shifting into 4l. *tt1997-04-24
POWER TRAIN - MANUAL TRANSMISSION
BC485496100110/01/199650444Revised eec calibration has been incorporated in pcm calibration for vehicles which display lack of power due to torque converter engagement scheduling, catalytic converter failures, rough idle or hard start on hot restart. *tt1997-04-24
BC964296100110/01/199650506Procedure for vehicles equipped with an aode or 4r70w transmission has a concern of shudder from the transmission torque converter clutch in 3rd or 4th gear or during 3-4 shift. *tt1997-04-24
BC521796100110/01/199650492Information on replaced/repaired manual transmission under warranty and returned w/ signs of improper/lack of maintenance or misdiagnosis. *tt1997-04-24
SERVICE BRAKES, HYDRAULIC - ANTILOCK - CONTROL UNIT/MODULE
BC522496100110/01/199650499Information on abs sensors returned for analysis are identified as 'no problem found'. *tt1997-04-24
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM - SHOES/LININGS
BC520996100110/01/199650484Revised rear brake lining for both 9 inch & 10 inch applications for concerns w/ rear brake grab during the first few brake applications when the brakes are cold or in the morning after an overnight rain. *tt1997-04-24
STRUCTURE - BODY - DOOR
BC520595100110/01/199650481For windnoise concerns in the right door a-pillar area of super cab trucks, ck the secondary weatherstrip (w/s) on the door opening panel (dop) flange for positive contact to the door. *tt1997-04-24
BC507596100110/01/199650445Information on erratic or self locking door locks. *tt1997-04-24
BC517496100110/01/199650453Information to diagnose wind noise & water leaks at the lower passenger door area & 3rd door. *tt1997-04-24
STRUCTURE - BODY - HOOD
BC521496100110/01/199650489Revised hood seal for concerns of a wind whistle at speeds over 35 mph. *tt1997-04-24
SUSPENSION - FRONT - SPRINGS - AIR SUSPENSION SYSTEM
BC519396100110/01/199650470Procedure for air suspension light on. *tt1997-04-24
SUSPENSION - REAR - SHOCK ABSORBER
BC519896100110/01/199650475Improved rear shock absorbers for customers who may experience a low tone rattling noise or whoosh sound from the rear of the vehicle while traveling less than 25 mph & going over small to moderate bumps. *tt1997-04-24
TIRES - TEMPORARY/EMERGENCY SPARE TIRE
BC521896100110/01/199650493Information on stowing the spare tire stowage. *tt1997-04-24
VEHICLE SPEED CONTROL - CRUISE CONTROL
BC518696100110/01/199650464Vehicles may experience an intermittent high idle after decel to a stop, when clutch pedal is depressed w/ no throttle movement. *tt1997-04-24