Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
VISIBILITY | |||||
0457 | 03/22/2004 | 10008542 | Pop/thump noise at end of window movement and/or driver's window bounce back and reverse to mid-position. *tt | 08/04/2004 | |
VISIBILITY - DEFROSTER/DEFOGGER SYSTEM | |||||
98613 | 03/30/1998 | 601324 | Subject regarding cold air felt on the floor while in heat mode. *yc | 07/22/1998 | |
98417 | 03/02/1998 | 601278 | Cold air may be felt on the floor while in heat mode on some vehicles. *yc | 07/16/1998 | |
VISIBILITY - DEFROSTER/DEFOGGER SYSTEM - WINDSHIELD - HEATER CORE | |||||
01156 | 08/06/2001 | 623944 | Some vehicles may exhibit heater core leaks. *slc | 10/31/2001 | |
BC0854961007 | 10/07/1996 | 50436 | Reattachment of heater hose fittings for concern of no heat, overheat, or coolant loss may occur due to heater hoses not properly connected at their quick-connect fittings. *tt | 04/24/1997 | |
VISIBILITY - POWER WINDOW DEVICES AND CONTROLS | |||||
0324 | 02/04/2003 | 10002474 | Driver's side door glass that binds when operated. *tt | 09/03/2003 | |
996780 | 08/01/1999 | 608469 | This online service bulletin involves vehicles exhibiting windnoise at the top of the door glass seal / weatherstrip molding area. *tt | 12/02/1999 | |
VISIBILITY - REARVIEW MIRRORS/DEVICES | |||||
996042 | 05/01/1999 | 606957 | Information on using 1999 procedures manual for side mirror replacement. *tt | 09/08/1999 | |
VISIBILITY - REARVIEW MIRRORS/DEVICES - EXTERIOR | |||||
BC2391970501 | 05/01/1997 | 52828 | Engineering is addressing the issue of intermittent/unable to adjust mirror concerns. *tw | 09/18/1997 | |
VISIBILITY - WINDSHIELD | |||||
13054 | 08/01/1999 | 6091846 | Experiencing windnoise at the top of the door glass seal / weatherstrip molding area. *tt | 11/15/2000 | |
13838 | 02/01/2000 | 612429 | Concerns with vehicles exhibiting a windshield creak / squeak. *tt | 06/08/2000 | |
BC1012897020 | 01/02/1997 | 51192 | Wind noise at the inner belt, raise door glass to full up position. *jd | 06/27/1997 | |
BC0120970201 | 01/02/1997 | 51031 | Diagnosis windnoise at the inner belt, raise door glass to full up position. *jd | 06/27/1997 | |
96221 | 10/21/1996 | 50940 | Windshield and interior glass - fog/film. *tw | 06/17/1997 | |
VISIBILITY - WINDSHIELD WIPER/WASHER | |||||
962210 | 10/21/1996 | 50949 | Windshield washers - washer hose too short and/or is trapped by the hood - vehicles built through 4/15/96. *tw | 06/17/1997 | |
BC0841961008 | 10/08/1996 | 50426 | Concerns of windshield wiper not cleaning, streaking or smearing. *tt | 04/24/1997 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
VISIBILITY | |||
12/04/1998 | 20 | ||
Both windows stopped working every other day. unable to roll them up or down. *ak consumer also states the windshield wipers stopped working in the rain, (repetitive)-replace relays. the problem is on going, the pcm chip has been updated, fuses checked, the motor for the window has been replaced and now being checked for a wiring short. problem may be in the steering column where they replaced a recall part in the ignition. consumer states, see reference number 8011065. *scc | |||
1 | 02/19/1996 | ||
Dmv placement visor failed due to weak material. | |||
VISIBILITY - DEFROSTER/DEFOGGER SYSTEM | |||
Exhaust manifold is leaking coolant. also, when heater is on temperature rises extremely high. | |||
1 | 04/01/1997 | ||
Ventilation system smells of mildew. | |||
03/17/1996 | 2 | 03/17/1996 | |
Floor heater vents inoperative. | |||
VISIBILITY - DEFROSTER/DEFOGGER SYSTEM - WINDSHIELD - BLOWER | |||
04/01/2002 | 71000 | 4 | 01/20/1999 |
I am sending in a full letter to explain the failures. it centers around tsb 99b29 and lack of owner notification of a bad front cover design that can lead to engine failure, which occurred in this case. additionally, i had a tie rod failure that was not addressed under warranty, but later broke while driving. also, my crank shaft pulley / dampener assembly fell off while highway driving (70 mph). there are other issues including door lock / key sticking.*ak campaign id number : 03v196000 component: steering:gear box:shaft sector. the engine cover gasket failed. *tc the serpentine failed, the transmission had an akward shift, the wipers operated periodically by themselves on high speed, there was little heat coming from the vents through the floor. *jb | |||
09/20/2000 | 07/01/2000 | ||
I had an electrical short under the dash caused by moister in the fuse box , which was caused by water leaking around the windshield. i was not to concerned until i took it to the shop and found out that there is 13 pages of service bulletin about moisture get into the fuse box. it does thing as wiper not working while in drive or reverse but will work any other time. radio not turning off, blower motor not shutting off. trying to engage the starter while the vehicle is running. | |||
12/01/1998 | 2 | 02/02/1996 | |
Heater blower motor failed. yh | |||
VISIBILITY - DEFROSTER/DEFOGGER SYSTEM - WINDSHIELD - HEATER CORE | |||
09/02/2002 | 130955 | 9 | |
I purchased a 1997 ford f-150 june 11, 2001 from two rivers cheverolet on 2/04/02 a hole was patched in the radiator of the vehicle. on 9/02/02 the radiator had another hole in it and this time had to be replaced. on 9/27/02 the heater core began leaking and had to be replaced. at that time i had taken the vehical back to the radiator specialist and he sugguested that the vehical might have electryolisis, said take the vehicale to the ford . i did they replaced the heater core and i had suggested to the service technian that it could have electroylisis. the service tech. said that, that was not very possible. on 12/03/02 i took the vehicle back to the same ford garage for leaking of antifreeze, they said that they could not find any leaks and sent me on my way. on 3/10/03 i was on the other side of the country and the heater core went again i took it to a local ford garage in the area that i was in and they replace the heater core again. on 5/21/03 the heater core went again at this time i was in a different part of the country and at every ford garage i went to i told the story to the service advisor. the heater core was replaced. on 10/29/03 the heater core again failed and i took it back the same ford garage that i last had it at. again they replaced the heater core and this time told me that there was electryolisis in the vehicale. they replace heater core. on7/12/04 the heater core went again i took the vehicle back to the same ford garage and they said that they could replace the heater core and this time the radiator had a hole in it again. they also said that the problem would proably not go away and there was nothing else that they could do for me. i took it to a radiator specialist and they told me if they had had the vehicale when the problem first started that they would have been able to fix it. but now its been going on took long and there was a slim chance that they would be able to fix problem. now with no help from the (ford).*ak | |||
11/29/2003 | 136101 | 2 | 02/11/1999 |
1/28/03 - heater core failed and was replaced. 11/29/03 - heater core failed again and was replaced. ford didn't charge me for another core but i did have to pay agion for the labor, $400.00. this part should not fail after 11 months. *ak | |||
09/08/2003 | 119000 | 4 | |
While driving there was a strong anti freeze odor, and the windshield fogged up. vehicle was taken to the dealer, who informed the consumer that the heater core was no longer working.*ak | |||
03/11/2003 | 96238 | 1 | 10/12/1998 |
Heater core failure. all indications that this is common to ford, but the dealer denies it. this part should not have a high failure rate.*jb | |||
07/30/2002 | 1 | 04/01/2002 | |
Heater core failed. instantly fogged inside of all windows. impossible to see anything outside the vehicle. at 65 mph this could be lethal! why, has this obvious defect never been addressed?*ak | |||
12/28/2000 | 2 | 12/01/2000 | |
Heater core failed and leaked anti-freeze inside heater box mist left oily film on windshield and could not clean . had to drive 2 hours with drivers window open to see. replaced in jan of 2000 and failed 8 months later same result both times i was driving home from work at 3 a. m. see tsb 01-15-6 repeated heater core failure. contacted ford and they will give me another core but i have to install again 12 to 16 hour job. very serious safety issue needs to be addressed. thank you.*ak | |||
01/10/2001 | 1 | 02/01/1999 | |
Heater core leaking. heater core leaked causing antifreeze to leak out and get on the windshield. dealer replaced said had replaced several others in same model of truck. they billed me 568.00 dollars for this. i only agreed to pay them 240 because that is what they quoted over the phone. this is a part that really doesn't ware out. the dealer claimed that they didn't know what was causing this to happen. | |||
04/16/1999 | 2 | 01/01/1997 | |
The vehicle's ventillator assembly lets water into transfer case causing wiper failure. yh | |||
VISIBILITY - GLASS, SIDE/REAR | |||
05/20/2000 | 3 | ||
Loss of anti-freeze or coolant both doors starting to crack rear sliding window leaking. *jb | |||
07/25/2003 | 89000 | 1 | 07/22/2003 |
Rear window leaks water around window seal.*ak | |||
06/22/2004 | 82000 | 0 | 08/08/1997 |
Rear sliding glass window leaking in the inside top left section. taken to ford dealer who in turn subcontracts out to a leak specialist. i was inform by the service desk that he inform them that i would need to replace the whole rear window at a cost estimate of a couple hundred dollars. i in turn contacted ford motor company and of course my vehicle is now out of warranty. i own a 1997 ford f-150 with 82,000 miles. i was informed by ford motor co. that the dealers are franchised and what ever policy they have in place ford co. can't control. *ak | |||
02/17/2004 | 16033 | 2 | 02/17/2004 |
Rear window of 1997 f150 leaks. dealership replaced window, and new unit leaks. problem seems to exist in 1997-2003 f150's.*ak | |||
04/14/2000 | 30000 | 0 | 08/24/1996 |
1997 f-150 rear window leaking - took in twice during warranty and told them about hearing water in truck them checked drain in door and said nothing wrong - only have 62000 on truck so i did not drive it much but now i found were water was coming in through gasket and this seems to be a big problem and dealer ship are having outside vendors doing work i think this should be recalled because they knew this problem and changed design | |||
12/31/2002 | 80000 | 1 | 03/29/2002 |
Consumer states the rear window glass is leaking water into cabin of vehicle. dealer diagnosed problem with the assembly of the glass. dealer needs a special ford part due to glass assembly being part of vehicle's frame. ts rear windshield replaced. *tt | |||
03/01/2002 | 07/01/2001 | ||
No summary listed for above vehicle. *ak | |||
04/24/1998 | 4 | 11/01/2097 | |
The rear window frame keeps cracking and causing it to leak water inside the cab. i had it fixed 3 different times under warranty then it happened again and tipton wouldn't help me anymore so i called ford in detroit and they said the dealer said i was abusing my ford and that is a false statement i even offered to send them pictures of my truck and it is in great shape and only 65,000 miles it is unfounded if they just would look at my truck 'not takeing the dealers word because why would it be abuse only after the warranty ran out . the dealer never fixed the problem and if i have to go through legal manners i guess i will have to. *ak | |||
Rear window leaks. right hand side of rear window was leaking. took vehicle to dealer, and dealer indicated to repair vehicle, had to replace the the whole window.*ak | |||
12/02/2001 | 12/01/2001 | ||
No summary listed for abov evehicle. *ak | |||
11/25/2001 | |||
Back sliding glass window is allowiing water to enter vehicle because seal on window is defective, and allows water to enter vehicle. contacted dealer, and dealer is not willing to do anything. *ak | |||
09/07/2001 | |||
Vehicle rear sliding glass would leak wnenever it rains or being washed. dealer notified. feel free to provide any further information.*ak | |||
04/18/2001 | 1 | 05/01/1997 | |
Rear glass is coming out from its seal. dealer notified, and unwilling to assist in this matter. manufacturer notified, and informed consumer that vehicle was out of its warranty. *ak glass had to be replaced *jb | |||
11/01/2000 | |||
Rear window is becoming separated from vehicle. seal is coming off. water is leaking in. consumer was told that vehicle was not a part of any recall. please provide any additional information/attachments.*ak | |||
1 | 06/01/1997 | ||
Purchased an extended cab pickup because i have two children. since purchase, they have grown and when they are in the back seat, they're heads are in line with the rear window. i'm afraid that if i was struck from the rear, my daughters heads would go through the back window and suffer head and neck injuries.. i am currently trying to find an aftermarket solution to the problem. thank you for your time and consideration. *ak | |||
01/31/2001 | 1 | 05/01/1997 | |
Pittman arm referenced eight (8) times in tsb's. rear window also referenced in tsb's. *ak | |||
12/10/2000 | 2 | 01/01/1998 | |
I first discovered the leaking rear window a year ago( the truck was less than 2 yrs old) with 53000 miles and had it repaired at the dealer for 180.00 it is unknown how long it was like that because it was a passenger in the back seat that noticed it was leaking after a heavy rain. this new leak was discovered yesterday by me after a car wash and it was in the same location as the first one. the truck is less than 3 years old and has 84150 miles. i will report this to the dealer tomorrow 12/12/2000. the crack in the driver side door sheet metal was discovered after reading about the problem on a web site 12/11/2000 (www.ford-trucks.com) it was listed as a common problem on 97, 98,99,2000 f150s. when i checked i discovered the crack with a little rust on it a couple inches up from the bottom window molding. | |||
1 | 12/10/1999 | ||
Rear window leaks due to defective seals. *ak | |||
08/30/2000 | 1 | 03/01/1999 | |
The original rear sliding glass window leaked and was replaced under warranty (less than 36000 mi.). the replacement window eventually leaked too, so it was defective also. the front brake pads wore out and scored the rotors. the repair shop indicated that they could not turn/repair the rotors because they were under specification. further investigation indicated that the replacement rotors for this vehicle have a different thickness specification. the original rotors are either not the correct thickness or have an incorrect specification. the brakes have never seemed to perform properly. brakes must be applied very hard and even then the vehicle does not stop very quickly.*ak | |||
09/19/2000 | 1 | 07/01/1999 | |
Rear sliding window leaking and driver's door was chipping paint due to weak metal used. dealer / manufacturer notified, and informed consumer that they were aware of the problem, but nothing could be done. *ak | |||
Rear slidding glass window is leaking water into truck due to faulty craftmanship.*ak | |||
12/02/1998 | 2 | ||
Left front door crack at lower rear of window frame. *ak | |||
12/01/1997 | |||
Rear window has a leak on the passenger side of the sliding window that has been sent back to the shop several time for repairs. its on oing ! the window has been replaced w/ frame three times , but the truck has been in shop several times prior to and after the windows have been replaced. it would last a short time and would then start leaking all over again. ** presently still leaking **. # 2 . engine has a knock during start up. sounds more like a diesel ! both issues have been present since 14,000 miles or so. this truck has had several problems. to mention a few ; rear bumper rusting out, door & shift nobs breaking , body paint peeling, rattle in floor gear shift ( still present ), ** now the air conditioning is not working **. i like the truck, but would rather have one with out all the problems ! | |||
01/10/2000 | 10 | 01/01/1999 | |
Every time it rains,water pours in the top of the rear window and soaks the rear seat.when i contacted the dealer ,they said this happens frequently with these trucks,but that ford was not responsible. *ak | |||
03/11/2000 | 1 | 04/01/1997 | |
No summary listed for abov evehicle. *ak | |||
03/11/2000 | 1 | 04/01/1997 | |
No summary listed for above vehicle. *ak | |||
03/11/2000 | 1 | 04/01/1997 | |
No summary listed for abov evehicle. *ak | |||
03/11/2000 | 1 | 04/01/1997 | |
No summary listed for above vehicle. *ak | |||
12/01/1999 | 0 | ||
Six months after purchasing vehicle back window started to leak, took to dealer , and they said that it was not under warranty. top of the window is still leaking. *ak | |||
12/03/1999 | 4 | 07/01/1997 | |
No summary listed for above vehicle. *ak | |||
07/07/1999 | 07/14/1999 | ||
Water pours in through the back window everytime it rains. dealer put some kind of sealant around the window, which did not correct the problem. *ak | |||
06/01/1998 | 2 | 10/01/1996 | |
Water pours in through rear window when it rains; dealer resealed window but it still leaks; dealer replaced window with a new design to fix problem; dealer charged me $350.00; should i have to pay for a design flaw? | |||
08/24/1999 | 9000 | 08/01/1999 | |
I was told that i would have to pay a deductable to have this fixed. it is a hazard because my windshield wipers do not work half the time,and when they do not work, the windows will not roll down so therefore i can not see when it rains. there was something wrong with it when i bought it and i feel i should not have to pay the deductable. | |||
07/31/1996 | 3 | 05/01/1996 | |
Back rear window leaks and they have failed to fix three times at two different dealers. the first dealer failed to tell me there was a recall on the window. the second dealer fixed it under some kind of recall and now refuses to fix it again. the window is still leaking. | |||
05/01/1997 | 3 | 11/01/1996 | |
I have had the back light resealed twice already, still leaks...have heard it is a cracked window frame, a design flaw and some have had the dealer replace with a new window. mine because out of warranty is my problem. i had it fixed once under warranty, but the problem still exists and sidney ford doesn't want to do anything about it....poor customer service and warranty service!!! | |||
12/21/1998 | 5 | ||
When the rear sliding window is closed, water/rain would leak through the opening area. this is a design flaw. *ak | |||
1 | 11/01/1997 | ||
Rear sliding glass window leaks. | |||
1 | |||
Sliding rear window leaks. | |||
60 | 06/10/1996 | ||
While driving at approximately 60 mph an object fell of a truck in front of consumer. consumer moved from left to right to avoid hitting the object. 8-year old daughter that was strapped in hit the window latch which caused a small cut to open up. | |||
07/18/1997 | |||
The conversion ford f150 has a defect in rear window by the bench seat which was not reinforced properly, it's structural unsafe; it does not have the roll bar which does not comply with our fmvss. the conversion is transapple custom, 2645 route25 centre reach ny 11720 at 516-981-vans,kenny coder thru babylon ford 495 montaqa hwy west isley ny at 516-669-3232, hank heckels. *ak | |||
VISIBILITY - POWER WINDOW DEVICES AND CONTROLS | |||
05/19/2004 | 105000 | 4 | 11/01/1997 |
Consumer claimed that electrical light,windows, and locks were inoperable. also, windshield wipers failed. consumer will take the vehicle to dealer for inspection this week. *ak the a/c unit, dome light, and no check engine light. *sc | |||
05/19/2004 | 4 | ||
Electrical lights/windows, and locks were inoperable. also, windshield wipers failed to come on. consumer will take the vehicle to dealer for inspection this week. *ak | |||
08/19/2003 | 70000 | 6 | |
The top of the back window leaks, causing water to drip into the cab of vehicle. dealer informed consumer that the window and the track need to be replaced to remedy the problem.*ak | |||
12/04/1998 | 20 | ||
Both windows stopped working every other day. unable to roll them up or down. *ak consumer also states the windshield wipers stopped working in the rain, (repetitive)-replace relays. the problem is on going, the pcm chip has been updated, fuses checked, the motor for the window has been replaced and now being checked for a wiring short. problem may be in the steering column where they replaced a recall part in the ignition. consumer states, see reference number 8011065. *scc | |||
09/01/2001 | |||
Bottom of each window in right corner, if inside vehicle, there's a quarter inch crack on outside of the windows. driver states crack is getting longer. dealer has been contacted. please provide any further information.*ak | |||
09/06/2001 | 0 | ||
Rear window is leaking water on passenger's side. glass has separated from frame of the truck. please provide any further information.*ak | |||
06/05/2001 | 1 | 07/01/1997 | |
Technician found power windows were not working due to cracks on both doors, all three doors are rusting at bottoms, consumer states if there would be an accident, most likely the doors would break in half. *slc | |||
Fues to power windows continues to blowout. this has happened on several occasions. also, dome light is affected. dealer has been contacted.*ak | |||
03/01/1999 | |||
Door at lower window has developed crack on both doors.electrical system that reads door ajar or shut in door has failed /also controls wipers & int.& ext. lighting/ they share the same fuse.*ak | |||
11/12/1998 | 1 | 08/22/1997 | |
The right power window is inoperable, the dealer lubricated window. *slc | |||
09/28/2000 | 0 | ||
Lower right corner of window, there is a small crack on door about 25 inches long. *ak | |||
01/01/1999 | |||
Rear back glass leaks. dealership is aware of problem. everytime she washes vehicle water comes in though the window.*ak | |||
05/29/1998 | 2 | 05/01/1998 | |
Doors have fractures in door frames above&behind door handles , under the thicker weather stripping of the side windows. they are stress fractures that mat have come from the operating of the glass going up & down. anyway this is a problem for safety & metal stress failure the metal will come apart in a crash in the door area. design flaw at best is what i see here, which be looked into by someone. thank you terry e. thompson | |||
01/14/1998 | 1 | 02/26/1997 | |
Power rear view mirror failed. mjs | |||
06/18/1998 | 1 | 02/26/1997 | |
Keyless entry remote system failed. mjs | |||
VISIBILITY - REARVIEW MIRRORS/DEVICES | |||
11/26/1999 | 1 | 12/01/1997 | |
No summary listed for above vehicle. *ak | |||
12/15/1999 | 2 | 01/01/1997 | |
Driver side elec. remote cntrl. mirror glass has cracked 2 times almost same place each time, top to bottom | |||
VISIBILITY - REARVIEW MIRRORS/DEVICES - EXTERIOR | |||
05/10/2002 | 6 | 02/01/2000 | |
Headlights worked poorly confuse the oncoming drivers, and scares the hell out of the driver of the mentioned vehicle. outside mirrors------outside mirrors ( right and left side) fail to operate with the adjusting switch located in the interior driver side arm rest. mirrors fail to adjust. this is a problem when different drivers use this vehicle. *ak | |||
11/15/1999 | 08/01/1999 | ||
Exterior mirrors design are poor in visibility when used with a trailer hitched to vehicle. unable to see properly and causes blind spot from both sides. dealer / manufacturer notified, and informed consumer that nothing can be done since mirrors meet specification. mirrors do not support extension mirrors. *ak *ml | |||
VISIBILITY - REAR WINDOW WIPER/WASHER | |||
05/19/2004 | 105000 | 4 | 11/01/1997 |
Consumer claimed that electrical light,windows, and locks were inoperable. also, windshield wipers failed. consumer will take the vehicle to dealer for inspection this week. *ak the a/c unit, dome light, and no check engine light. *sc | |||
05/19/2004 | 4 | ||
Electrical lights/windows, and locks were inoperable. also, windshield wipers failed to come on. consumer will take the vehicle to dealer for inspection this week. *ak | |||
VISIBILITY - REAR WINDOW WIPER/WASHER - MOTOR | |||
Their was a recall for rear windshield wipers. after consumer had recall work performed, rear window leaked when it rained. the dealer has been contacted.*ak | |||
VISIBILITY - WINDSHIELD | |||
Rear windshield leaks. vehicle was taken to the dealer for repairs, but the problem still exists.*ak | |||
2 | 01/01/2002 | ||
I have noticed that i have devolped cracks on my drivers side door and passenger door. im curious to know why some sort of action has not been taken by ford motor company. i have read on certain ford websites that as much as 65% of f150 pickup trucks have this problem. im would like to know what would have to be done in order to solve this problem.*ak | |||
10/01/2001 | |||
The back window leaks and both doors have a crack right on the doors on the corner of the windows. i talked to someone else and they have the same problem with the leak and the cracked paint. can you please look into this for me. thank you! | |||
06/01/2001 | |||
Crack in each door near window. *ak | |||
06/01/2001 | 0 | ||
Rear sliding window will leak water everytime it rains and could not fix the situation. *ak | |||
05/27/2001 | 2 | 05/01/1997 | |
There is a crack in the sheetmetal approximately 3 inches up from the bottom corner of the window. this crack is on both doors. it appears to result from the bending of the door when the window is raised and lowered. the crack is getting bigger with time, and will cause the door to break.*ak | |||
02/13/1997 | 0 | ||
Window located behind driver and passenger, makes a squeaking, rattling noise.*ak | |||
01/07/2001 | 1 | 11/01/1998 | |
The door post at lower right of window is cracking at both doors through research i have found this to be a common problem with ford f150 & f250 trucks and i feel this could be a safety concern and fmco does not want to address this matter. thank you michael. *ak | |||
09/01/2000 | 1 | 05/01/1997 | |
Detected a defect on the driver's door, located at the lower right corner of window pillar. defect description is a small crack which is approx. 3/8 long and is rusting.*ak | |||
01/01/1997 | 1 | 01/01/1997 | |
The failure occurs at the seam next to the window on the drivers and passengers door at the rear of the window{just above the door handle} right where the rubber molding ends. i have seen this crack on almost every f-150 i have inspected made in 1997. i have shown 5 other people the cracks on their vehicles and have also shown the local ford dealerships in town. but despite the fact that they have received a bulletin from ford authorizing them to replace the door some of them refuse to do so. *ak | |||
07/01/2000 | 0 | ||
Consumer was washing vehicle and noticed that water come through the rear window, and got inside of vehicle. possibly, there was damage with seatbelt. consumer took vehicle to the dealership, and they told him that vehicle wasn't on recall. *ak | |||
04/13/2000 | |||
Consumer noticed cracks in lower rear corner of window frame. dealer/manufacturer notified, and refused to repair unless cost goes to consumer. *ak | |||
2 | 04/01/1999 | ||
Cracks developing near bottom of windows just under the edge of the moulding and on the drivers side has now grown to a little over .25inch. *ak | |||
02/19/2000 | |||
Cracks had developed in the window on the driver's & passenger's side doors. the cracks are slowly getting worse. took vehicle to dealership & was informed by mechanic nothing could be done. *ak | |||
10/01/1999 | 1 | 05/01/1997 | |
The skin on the outside of the driver side door has developed a crack that is 1.5 inches long. this crack was caused by the window going up and down. ford wants the owners of out of warranty vehicles to pay $250 toward repairs. obvious engineering flaw. *ak | |||
1 | |||
The sliding window has leaked many times and seems it is a manufacturing defect. yh | |||
07/15/1999 | 09/05/1997 | ||
Driver's and passenger's windows cracked along the edges, causing injuries. common problem. please provide further information. *ak | |||
06/15/1999 | |||
Water leaking inside the vehicle. glass shop informed consumer that a window separated from frame. consumer believed that this condition was caused by a manufacturer's defect. *ak *ml | |||
1 | |||
Windshield leaking. | |||
11/13/1997 | 1 | 09/01/1997 | |
Window weather-stripping loose. | |||
09/17/1997 | |||
The windshield makes a noise like it's going to explode and then it cracks, also the windshield wipers lift off of the vehicle at a speed of 55mph or greater. *ak | |||
03/27/1997 | 1 | 03/20/1997 | |
Windshield glass has spots etched into glass , causing poor visibility | |||
08/12/1997 | 2 | 04/01/1997 | |
Driving at turn pike speed the rear window exploded with a pop sound, three weeks later the driver's side window exploded outward. *ak after sitting for two days infront of our home. *yh | |||
04/01/1996 | 1 | 02/01/1996 | |
Window handle failed. | |||
VISIBILITY - WINDSHIELD WIPER/WASHER | |||
04/01/2002 | 71000 | 4 | 01/20/1999 |
I am sending in a full letter to explain the failures. it centers around tsb 99b29 and lack of owner notification of a bad front cover design that can lead to engine failure, which occurred in this case. additionally, i had a tie rod failure that was not addressed under warranty, but later broke while driving. also, my crank shaft pulley / dampener assembly fell off while highway driving (70 mph). there are other issues including door lock / key sticking.*ak campaign id number : 03v196000 component: steering:gear box:shaft sector. the engine cover gasket failed. *tc the serpentine failed, the transmission had an akward shift, the wipers operated periodically by themselves on high speed, there was little heat coming from the vents through the floor. *jb | |||
06/26/1997 | 60 | 05/01/2096 | |
Winshield wipers rarely work on intermittent setting and if they do they are not consistant in timing. about 30% of the time the wippers will not come on at all. washers work only 20-25% of the time.*ak | |||
06/07/2001 | 1 | 10/01/1996 | |
Fuel line leak caused gasoline to spill onto the pavement; a definite safety hazard. defect was covered by a safety recall, but i had previously taken vehicle in for inspection and given a clean bill of health. how can a part covered under a recall fail after i took it in? ford is unwilling to cover any expenses except the repair costs, while i incurred addtional costs. the windshield washer quit working. ford is unwilling to cover the cost of repairs.*ak | |||
09/20/2000 | 07/01/2000 | ||
I had an electrical short under the dash caused by moister in the fuse box , which was caused by water leaking around the windshield. i was not to concerned until i took it to the shop and found out that there is 13 pages of service bulletin about moisture get into the fuse box. it does thing as wiper not working while in drive or reverse but will work any other time. radio not turning off, blower motor not shutting off. trying to engage the starter while the vehicle is running. | |||
1 | 08/09/1999 | ||
Windshield wipers would activate by themselves, and then squirt water on windshield. this would cause a visibility problem for driver. its unexpected and very distracting.*ak | |||
Windshield wipers will come on by themselves without touching controls, causing poor visibility. defect occurs intermittenly. dealer cannot determine cause.*ak | |||
1 | 03/01/1996 | ||
When driving under normal conditions windshield wipers will activate on their own. also, they will shut off when it is raining . dealer has been contacted.*ak | |||
11/21/1999 | 1 | 09/01/1997 | |
Windshield wiper motor replacement ($260.07 to dealer)did not solve problem; returned to dealer 12/9/99-response; unable to duplicate problem- | |||
03/01/1997 | 6 | 03/01/1996 | |
Windshield wiper comes on by itself while driving.*ak | |||
05/05/2000 | 06/01/1996 | ||
Windshield wipers come on randomly and has become more frequent. also, the wiper fluid is projected onto windshield by itself. latest incident of this severely affected by vision of the roadway and traffic during heavy rush hour interstate traffic. from what i have been able to see on some of the internet new groups this is a not uncommon problem with ford trucks. *ak | |||
08/30/1999 | 10 | 08/01/1999 | |
Anti-lock brakes don't work,they lockup and skid.wiper arms and wipers lift off windshield at 55 mph. or faster. *ak | |||
12/24/1999 | 0 | ||
Going down the road while it was raining windshield wipers would not work. then, all at once windshield wipers came on by themselves. also, while standing outside of the truck horn started to blow on its on. then, while on the road, horn once again started to blow on its own. *ak | |||
01/02/2000 | 0 | ||
While making a turn windshield wipers will come on and washer fluid sprays all over the windshield when it is not raining. this is unsafe on a curvy road. on a raining day and making a turn, windshield wipers will stop. *ak | |||
01/01/1998 | 10 | 04/01/1997 | |
Windshield wipers come on unexpectedly while switch is in off position. this is a safety problem because in the case of my father's ranger, the washer fluid would spray unexpectedly as well, thereby smearing the windshield and causing loss of visibility. both our trucks were diagnosed with faulty multifunction switches. a recall for this part should be issued as there is a high number of the same complaints listed on this site for various ford vehicles containing the same part. *ak | |||
08/24/1999 | 9000 | 08/01/1999 | |
I was told that i would have to pay a deductable to have this fixed. it is a hazard because my windshield wipers do not work half the time,and when they do not work, the windows will not roll down so therefore i can not see when it rains. there was something wrong with it when i bought it and i feel i should not have to pay the deductable. | |||
10/01/1999 | 5 | 12/01/1998 | |
I have experienced the 3 defects listed.....first, the powertrain, when four-wheel drive is engaged at a stop and an engagement time of at least 30sec. to 1min. is given, when i release my brake to proceed the powertrain makes a loud thump, this happens about 75% of the time....second the washer sprayers on the hood do not spray the windsheild. one sprays way off and the other sprays nothing. and third the high beam low beam switch is defected. when engaged in high beam and driving a short accures and the lights will flicker from high to low and completely off with no head lights at all......if you have any questions about any of these defects please contact shane e. mass at my home number ((712)-322-5233) .... thank you. | |||
10/02/1999 | 09/01/1996 | ||
My instrumental panel just stop working. no gas guage, speedometer, odometer, oil pressure, temp gauge, charge gauge, etc. checked fuse but ok. but like no power dealer knows of no such defect. also wipers come on at all different times without activation by driver . beat several times at very high speed then stop. this has happened over 20 times over the last several months | |||
4 | 02/05/1997 | ||
Windshield wipers turns on and off on its own. yh | |||
08/01/1999 | 10 | ||
Windshield wiper/washer would operate intermittently while in off mode, causing poor visibility which could lead to a vehicle collision . nhtsa needs to look into this matter. *ak | |||
08/21/1999 | 1 | ||
On several occasions windshield wipers will commence operating without any action by the driver. *yc | |||
06/01/1999 | 12 | 02/01/1999 | |
I recently saw were the nhtsa was looking at ford's windsheild wiper control as a possible problem for the explorer & another vehicle. i can vouch that the f150 also needs to be looked at. my 1997 f150's turn signal/windsheild wiper control will come on at any time & after using it will stay on. | |||
1 | 11/15/1996 | ||
Windshield wiper arm would not retain blade. yh | |||
08/13/1999 | 6 | 12/01/1996 | |
The winshield wipers will come on intermittently even when off. also, the last time it happened (i have a witness), the washer was also continously spraying fluid even though everything was off. | |||
08/05/1997 | 2 | 03/01/1996 | |
Windshield wipers - intermittent wipers erratic or not active. unable to use washer fluid. replacement part has same problem as orginal equipment. | |||
Windshield wiper fluid switch does not work. dealer tried to fix it, and no there was no solution. *ak | |||
09/09/1998 | 12 | ||
Windshield wipers and washers comes on by themselves. manufacturer/ dealer stated not common to have a short in system. problem has not been corrected. *ak | |||
09/01/1998 | |||
While driving windshield wipers malfunctioned, causing the wipers to operate unexpectedly which may cause an accident. also, problem with the oil stick. it seems to be cracking or falling apart, which may cause by some type of metal rubbing against the oil stick. causes unknown. *ak | |||
4 | 07/01/1996 | ||
The windshield washer fluid pump will engage without notice,blocking drivers view.dealer was notified,turn signal and wiper assembly replaced at cost to original owner. | |||
While driving over 50 mph the windshield wipers lose contact with windshield, causing reduced driver visibility. *ak | |||
09/17/1997 | |||
The windshield makes a noise like it's going to explode and then it cracks, also the windshield wipers lift off of the vehicle at a speed of 55mph or greater. *ak | |||
In weather temperatures below 20 degrees the windshield wipers' rubber blades do not touch windsheild, causing visibility problems. *ak | |||
01/20/1997 | 1 | ||
The windshield washer jet does not reach the windshield above 40mph. had jet replaced and the same thing happened again. *ak *jb | |||
01/29/1997 | 12 | 11/25/1996 | |
Vehicle rolled away while in park on slight incline; also vehicle veers to the left and windshield wipers skip cycles while on delay. *ak | |||
VISIBILITY - WINDSHIELD WIPER/WASHER - MOTOR | |||
08/04/2003 | 1 | ||
While driving and with no warning windshield wipers would come on intermittently. vehicle has been to the dealership. *ak | |||
12/04/1998 | |||
While driving in rain windshield wipers stopped working every other day. driver was unable to see.*ak | |||
01/01/2001 | 1 | 03/01/1997 | |
Passenger's area dome light will come on intermittently, causing a distraction while driving at night. dealership has not examined or repaired vehicle. *ak consumer states he has replaced the part that holds the plugs twice and it costs 450 dollars each time, consumer states he thinks he may have to replace them again, the interior light also comes on at times. windshield wipers come on by themselves. *slc | |||
08/15/2000 | 100 | 06/01/1997 | |
While driving windshield wipers will come on unexpectedly like twice a month without warning. also, a short inside of steering column. *ak washer lever also on steering column, to get washer to operate must push handle in at angle. the dome lamp is defective and stays on when the engine is started. *yh | |||
01/05/1999 | |||
Windshield wipers intermittently stop working during operation or sometimes donot work at all. dealer notified, and and informed consumer this vehicle was not included in recall due to vin. *ak | |||
Windshield wipers come on by themselves, causing a distraction to driver. dealer claims switch and module need to be replaced. 2. tailpipe located to in front of passenger's rear wheel causing exhaust to corrode wheel and lugs: nuts. dealer will not change location of exhaust. *ak | |||
08/06/1999 | |||
Whenever windshield wipers are in use they would go on & off on their own. sometimes have to hit wipers to get them going again. sometimes not raining when this happens. causes havoc with driving. *ak | |||
03/22/1999 | 10/06/1996 | ||
Windshield wipers will operate intermittently on their own. also, starter will make noise as if starting car when already running. dealer contacted ,and cannot remedy the problems. problems still exist. *ak | |||
11/10/1997 | 10 | 06/26/1996 | |
Consumer had taken the vehicle to dealer for repairs of the lugs: nuts:bolts, but dealer did not had the parts to repair vehicle for the first time, and now the vehicle has the same problem. dealer has been contacted. *ak consumer has became aware of recall 98s14, regarding the lugs/nuts/bolts. steering not operating properly, it locks up when it rains. transmission does not operate properly, consumer was informed of recall 97s86, however dealer stated that consumer would have to work with their schedule for repairs. windshield wipers start by themselves. turn signals worked too fast, dealer found a loose wire. brakes did not work efficiently, takes a longer distance to stop. a/c was not cold enough. serpentine belt was replaced. door was out of adjustment, making it hard to open from the inside. *slc | |||
VISIBILITY - WINDSHIELD WIPER/WASHER - SWITCH/WIRING | |||
01/01/1999 | |||
With the switch on/off windshield wiper/washer would intermittently operate. also, door ajar light would come on. *ak |