Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| STRUCTURE | |||||
| 01111 | 01/22/2001 | 618084 | Some vehicles may exhibit a water leak around the rear (sliding) window. *tt | 04/03/2001 | |
| 98113 | 01/19/1998 | 605574 | Subject pertaining to red rust stains on the edges of the bumper center vent and fog lamp openings. *tt | 07/12/1999 | |
| 98203 | 01/01/1999 | 604389 | Concerns with the potential effects of adhesives used for body panel repairs. *tt | 04/28/1999 | |
| STRUCTURE - BODY | |||||
| 983573 | 01/08/1998 | 607841 | Some vehicles may exhibit cab vibration. *tt | 10/13/1999 | |
| 12601 | 03/01/1999 | 605323 | Experiencing whistling noise coming from the front of the vehicle at highway speeds. *tt | 06/08/1999 | |
| 982323 | 11/23/1998 | 603930 | Information regarding replacement and / or repairs on any lock component. *yc | 03/11/1999 | |
| 98203 | 10/12/1998 | 603688 | Concerns with adhensives not recommended for body panel repairs. *yc | 03/02/1999 | |
| 9844 | 03/02/1998 | 601263 | Some difficulty in matching the texture of the oem anti-chip stone abrasion material to rpair materials when servicing. *yc | 07/15/1998 | |
| 9831 | 02/16/1998 | 600585 | Repairs to vinyl covered surfaces. *yc | 05/27/1998 | |
| 9833 | 02/16/1998 | 600587 | Service tips for surface defect removal without repainting. *yc | 05/27/1998 | |
| BC0717961021 | 10/21/1996 | 50381 | Information for when replacing an interior trim component under warranty. *tt | 04/24/1997 | |
| STRUCTURE - BODY - BUMPERS | |||||
| 996876 | 08/01/1999 | 608807 | Information pertaining to conditions with red staining (spots) on the front bumper wing ends. *tt | 12/06/1999 | |
| STRUCTURE - BODY - DOOR | |||||
| 01182 | 09/17/2001 | 625674 | Some vehicles may experience a cosmetic crack in the outer door panel at the lower rear corner of window opening.*jb | 11/30/2001 | |
| 99-8-15 | 05/03/1999 | 606419 | Subject regarding door trim panel replacement - service tip. *tt | 01/05/2001 | |
| 98-4717 | 09/01/1998 | 607127 | Vehicles exhibit cracks in door sheet metal at lower rear of the window opening near belt molding. *ak | 11/02/2000 | |
| 985029 | 11/01/1998 | 613071 | Some vehicles may exhibit cracks in the door sheet metal at the lower rear of the window opening near the belt molding. *tt | 08/02/2000 | |
| 12071 | 11/01/1998 | 613046 | Some vehicles may exhibit cracks in the door sheet metal at the lower rear of the window opening near the belt molding. *mjs | 06/16/2000 | |
| 98163 | 08/17/1998 | 6090873 | Locks failed. yd | 03/31/2000 | |
| 99242 | 11/15/1999 | 6090184 | Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt | 03/09/2000 | |
| 996754 | 08/01/1999 | 608461 | This online bulletin addresses concerns with cracks in the door sheet metal at the lower rear of the window opening near the belt molding. *tt | 12/02/1999 | |
| STRUCTURE - BODY - TRUNK LID | |||||
| 7821 | 01/01/2000 | 7821 | 612212 | Cracks in the door sheet metal at the lower rear of the window opening near the belt molding. | 06/07/2000 |
| STRUCTURE - FRAME AND MEMBERS | |||||
| 0014 | 01/10/2000 | 612202 | Vehicles may experience inner fender well- dented or dinged from stones being thrown into wheelwell. *mjs | 06/06/2000 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| STRUCTURE | ||||||
| PE99019 | FORD MOTOR COMPANY | 03/04/1999 | 07/27/1999 | SPARE TIRE WEAR | ||
| Alleged that the spare tire on the vehicle is lifted and secured under the bed of the truck by acable lift. | ||||||
| DP99002 | FORD MOTOR COMPANY | 03/02/1999 | 03/17/1999 | SPARE TIRE MOUNTING | ||
| Alleges that the spare tire mounting places the tire sidewall directly in contact with the metal undercariage causing wear and damage of the sidewall. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| STRUCTURE | |||
| 11/07/2008 | 112000 | 1 | |
| I purchased a 1998 ford f-150 in 2000 from carmax in arlington, tx. i have had no major problems until nov. 7th 2008. i was driving and approached a traffic signal. i attempted to depress my brakes when the vehicle locked up and spun sideways at the intersection. when i exited the vehicle i found that my driverside rear differential had broken lose and the rear differential clamp had broken off allowing the entire driverside differential to fly off of the vehicle. % minutes earlier i was on the freeway. if this would of happened on the freeway, i would not be here today. *tr | |||
| 08/20/2000 | 38000 | 2 | |
| Water seeped into the rear window. when the problem first started, the repair shop sealed the glass, but the problem had progressed over time. now the entire rear window has to be replaced to correct the problem. the auto glass shop indicated it was due to a faulty window frame . they also indicated it was a common failure with the rear windows. *jb | |||
| 11/18/1998 | 10/01/1998 | ||
| On-going problem with running board gets slippery when wet / in very cold weather. dealer notified, and nothing could be done. asking nhtsa to look into this matter, could cause bodily harm. *ak *yc | |||
| 1 | 04/01/1998 | ||
| While towing a 19' travel trailer, the trailer fishtailed wildly causing vehicle to lose control and flip trailer. i had towed the trailer a previous 5 years without incident. this wreck occurred only 2 months after purchasing this vehicle. not sure at this time if it indeed was the truck or not. | |||
| 01/09/1998 | 1 | 12/14/1997 | |
| Water leaks into vehicle causing electrical failure and stalling. | |||
| STRUCTURE - BODY | |||
| 10/30/2009 | 105000 | ||
| Spare tire fell off on highway due to rusted hanger cable. the vehicle is a ford f-150 pick-up with 105,000 miles. | |||
| 09/25/2003 | |||
| Paint peeling on roof where roofline joines with windshield, also at top of door around rubber seals | |||
| 1 | 11/01/1997 | ||
| Center console located on the 60/40 split bench seat has a cup holder / storage compartment. however, console will lock in the up position, but will not lock in the down position causing discomfort to driver possible safety hazard. *yc | |||
| 03/01/1998 | |||
| The extended cab where bench seats are located, the rear windshield latch pokes out when going over bumpy road, causing the child's head to hit this part which can cause injuries. please provide further information and vin#. *ak | |||
| STRUCTURE - BODY - DOOR | |||
| 01/10/2005 | 130000 | 1 | 12/16/2004 |
| Crack , drivers door beside lower window opening. *jb | |||
| 06/20/2003 | 1 | ||
| I have a 1998 ford f-150 and on the drivers side door at the window i have a about a 1/2 inch crack.i called ford but i got the run around and was told nothing will be done but they will get with there engineering area.*ak | |||
| 05/01/2000 | 22000 | 2 | 02/25/2000 |
| Cracks have developed in both the driver and passenger doors, approximately half way up and behind the windows. each crack is approximately 1/2 inch long.*ak | |||
| 03/30/2003 | 68000 | 90 | 03/20/2003 |
| 1998 f-150 xlt extra-cab, both passenger and driver doors have a crack in the lower rear corner of the window molding. ford's technical service bulletin states the door assembly should be replaced reference message # 12071. after contacting ford they said they were showing a recall for my vin# even though it is widely known to be a problem. the eventual result will be structural failure of the door which will seriously compromise my safety operating the vehicle.*ak | |||
| 07/17/2002 | 62348 | 1 | 09/24/1998 |
| Sheet metal fatigues and cracks from the inside of the door panel to the outside from stress from the operation of the power windows. *ak | |||
| 06/24/2004 | 93000 | 1 | 06/23/2003 |
| Structural-stress fractures in sheet metal on door.*ak | |||
| 05/04/2004 | 1 | 08/09/1998 | |
| Crack forming on drivers door at bottom of window. also rust developing at bottom of both driver and passenger doors. crack is a known problem for years. when will ford fix this once and for all. nhtsa needs to get involved.*ak | |||
| 10/06/2003 | 100000 | 1 | |
| The driver's side door covering(skin) has developed a crack around the corner of the window. this occurs because the power window covering(skin) flex when the window is closed. this is a common problem and the dealership is replacing the covering that cost $400. this doesn't correct the failure. *mr | |||
| 01/20/2004 | 60680 | 1 | 10/06/1997 |
| I am the original owner of a 1998 f-150 ford 4x4 pick-up truck which is exibiting a cracking condition at the lower welting edge of the window on the drivers side door. understand this is occurring on many other f150's and appears to be an engineering design manufacturing flaw.*ak | |||
| 01/06/2004 | 85000 | 1 | 10/28/1998 |
| Metal on drivers door is cracked at rear of window , about three to four inches up from bottom of window. mine is not the only one. there are many 98 f-150's out there with the same structural flaw. *ak | |||
| 07/10/2003 | 06/09/2003 | ||
| Cracks in driver and passenger doors. they begin on the edge of the window and extend outwards increasing with time. | |||
| 06/10/2003 | 48000 | 1 | |
| A crack in the steel by the window trim on the drivers door. this has been a problem on all ford f-150's from 1997 to 2003. ford is doing nothing to repair the problem that they have known about for seven years. *ak | |||
| 06/23/2003 | 36000 | 1 | 06/05/1998 |
| 1998 ford f-150 xlt super-cab short bed. structural defect on driver's side door. right lower edge of window. defect is approximately 1/2 in length. this defect has been viewed on numerous f-150's that i have seen. the same defect is on all. *nlm | |||
| 11/01/2001 | |||
| Originally noticed that the driver-side power window was slowing down, then noticed cracking on the driver-side door. this is consistent with ford's special service message #12071. date unknown, but window behavior dates to fall 2001. *nlm | |||
| 03/15/2003 | 1 | ||
| I own a 1998 ford f150 pickup and have noticed a crack in the sheet metal of the drivers side door just behind the lower part of the window. an article i was reading suggested calling a ford dealer for repair, the ford dealer stated that ford only repairs the vehicle for the first 36,000 miles. the article i read stated that ford understands the problem to be caused by opening and closing the door and window, which causes the sheet metal, in the location of the crack, to flex, which over time fails and cracks. the problem will only get worse with time and should be repaired regardless of the mileage. my concern is the location of the crack at a corner radius and could propagate toward the rear of the door. the crack that has developed, causes two problems, it creates an opening for water and salt to corrode the unprotected sheet metal on the inside of the door and the crack creates a problem, were the vehicle to be in an accident and hit on the drivers side door. since the crack has already developed, it would take little impact for the crack to propagate allowing the door panel to be severed, removing its structural integrity. the article i read stated that ford has found that welding the door does not correct the problem. the correction can only be made by replacing the door. as these cracks have developed and continue to develop on ford f150 trucks after 36,000 miles, how are they being repaired? my guess would be that if they are being repaired in any manner, they are most likely being welded together and repainted, which ford has found to be a insufficient repair. the only repair is to replace the entire door, which would be costly for the consumer. this problem will most likely only get worse as time goes on. ford is not taking responsibility for their defects, as this clearly is a manufacturers defect. i asked the nhtsa to look at this matter more closely to understand the potential impact of the crack that develops over time on the ford f150 truck doors. *nlm | |||
| 04/09/2003 | 1 | 09/24/1998 | |
| I own 1998 f150 truck that has developed a crack in the door near the window molding. i have been told this is a design problem, but ford will not fix it unless my warranty 3/36 is applicable. i have an extended warranty but it is no good. this crack had likely formed before my warranty expired. i feel it questions the design and strength of the door and how safe it will be with cracks developing weakening it.*jb | |||
| 01/01/2003 | 0 | 2 | |
| Both of the door frames on my 98 f-150 have cracked and continue to get bigger. i believe they will crack completely through the entire door. i was told by my dealer that ford won't pay to fix it until you make them. please help the thousands of owners that ford has fraudulently sold known defective products. *jb | |||
| 09/01/1999 | 12000 | 3 | 08/08/1998 |
| Re 1998 ford f150 super cab driver and passenger side doors are developing cracks ford has repaired this same problem 2 times before now that the crackes are apperaing for the 3rd time they say that my truck is out of warentee but but offered to fix it for 400.00 dollars i think they should have fixed it correctly the first time i also think this should be a recall not just a bulletin first repair was on 9/1/99 second repair was on 2/1/2001 and needs to be repaired again. | |||
| 01/21/2002 | 44000 | 04/08/2000 | |
| Cracks have formed in the both doors of my 1998 f150 xlt at the base of the window. my concern is for the integrity of the door and the resultant rusting that may occur. also, both windows don't operate properly....as they don't move up and down freely. i have seen the same cracks on several other f150s in recent months. | |||
| 10/01/2002 | |||
| Consumer advised that the normal opening and closing of the driver's door is resulting in the metal door frame breaking due to lack of reinforcement between the door and frame. ts | |||
| 10/01/2002 | 2 | 07/01/2098 | |
| A lot of f 150 owners have reported stress cracks in the sheet metal of the doors. can i get this fixed. i have contacted ford and thay tell me no. dt | |||
| 08/01/2002 | |||
| Crack appearing at right-hand bottom side of window causing it to rust. mr | |||
| 08/30/2002 | 1 | 07/01/2098 | |
| Driver door cracked lower left rear at belt molding. *ak | |||
| 05/03/2002 | 1 | ||
| Hair line cracks are developing outside the driver's door. dealer and manufacturer have been notified. *ak consumer states that the door on the vehicle is cracked by the window and that this is happening on all the 97, 98, and 99 ford half tons. *scc | |||
| 05/01/2098 | |||
| 1/2 crack in driver side door where window molding makes 90 degree bend, been through ford customer service and local dealer with no satisfaction, tsb on problem exists along with letter between ford and dealers describing problem in 1997-2000 f 150s. *ak | |||
| 09/01/2097 | |||
| There are cracks forming on both drivers and passengers door frames. about 3 inches above the bottom of the window and running to the back of the truck. the cracks are through the outside metal of the door.*ak | |||
| 06/21/2002 | 0 | ||
| Metal stress tear in both doors. consumer was told that doors would have to be repaired through welding and reinforcement.*ak | |||
| 2 | 04/01/2001 | ||
| There is a stress fracture in the exterior of both doors next to the glass on the latching side (not hinge side). this defect is covered under the 3 year, 36,000 mile warrenty although it's the use of the door not how far you drive that will allow the defect to occur. if left unrepaired, it could cause cuts on the hand, and i question the integrity of the door around the glass. | |||
| 06/15/2002 | 2 | 07/01/2098 | |
| I have door cracks on my f150 truck. ford has known about this problem since 1997. my truck is out of warranty now. ford needs to recall the trucks and fix this problem at no charge. i have searched the internet and found this is not an isolated problem. can you help me with this problem. thank you. *ak | |||
| Metal on driver's side is cracking on rear side of door. dealer indicated door needed to be reenforced on inside.*ak | |||
| 08/15/2001 | 05/01/1998 | ||
| No summary listed for above vehicle. *ak | |||
| 12/23/2001 | 1 | 12/01/2001 | |
| Crack in door metal next to driver's window. *ak | |||
| 09/29/2001 | 1 | 07/01/1998 | |
| There is a crack in the driver side door frame metal above the door handle near the bottom of the window. the crack is about 3/4 long now. my local news ran a story about this problem, that is how i became aware because it is happening to several trucks. i contacted ford and they sent me to you, please help. *ak | |||
| 07/01/2001 | 1 | ||
| Driver's door frame is cracked, and has been that way since consumer took possession of vehicle. dealership examined vehicle, and stated this problem was currently under investigation by ford. only option for a corrective action given to the consumer was replacement of door. please provide any additional information / attachments. *ak | |||
| 11/10/2001 | 1 | 08/17/1998 | |
| Doors are cracking at rear seam of window. vehicle is not covered under extended warranty which consumer purchased. dealer is not willing to fix it because it's out of the original warranty. *ak *jb | |||
| 10/31/2001 | 1 | ||
| There is a crack on the side of the door that goes from back of door, and it's about four inches long. contacted dealer, and dealer is not willing to do anything. *ak *jb | |||
| 1 | 12/01/1998 | ||
| I went to the dealer and he was very aware of the problem and that he is also an f150 owner and that he cannot get ford to fix his problems either. whe i call ford at 1800 392 3673 the lady that assisted me told me that she never heard of such problems. which goes to show that ford is just trying to hide the problem. i have bought and extended warranty which the dealer says it wont cover this failures, and that ford is only replacing doors on vehicles that their warranty hasnot expired. from what i have gather, i am one in thousands of f150 owners with this type of structural damage and all we want is to have our problem fix.*ak | |||
| 10/05/2001 | |||
| Passenger's and driver's side doors were cracking. crack started from bottom of window and it ended on door of both sides. contacted dealer, and dealer was not willing to do anything. *ak | |||
| 2 | |||
| The truck is a 3 door ext. cab. the driver & passenger doors both cracked near the bottom of the windows towards the back of the door. i believe this is a safety hazard as the stress fracture would probably give on impact & cause the door to crush in on this area and the window to break, both on the occupant. ford did replace both doors under warranty approximantely 20 months ago-the replacement doors also cracked in the same area. ford must be aware of this problem - 1999 models have different doors. this is a rampant problem on 1997 & 1998 ford trucks. this would be safety concern upon an impact. | |||
| 09/03/2001 | |||
| Driver's door is developing cracks in corner area. dealer has inspected vehicle and was willing to share the cost of repairs. feel free to provide any further information on this matter.*ak | |||
| 07/04/2001 | 1 | 04/01/1999 | |
| The drivers side door has developed a crack in it. the metal itsself is actually cracking. the crack is located near the window and extends appox 1/2 from thw window out. i contacted ford and they informed me that it was not their problem as the vehicle is over the mileage. ford did tell me that they know of this problem and that the doors are not capable of being open and shut numerous times. it is a design problem according to them.*ak | |||
| 08/15/2001 | 09/01/1998 | ||
| Door is cracking apart at a welded seam aft of the window3 inches up from window base this so much of a common problem with this truck that every one i know who ownes one has the problem. *ak | |||
| 01/01/2001 | |||
| Both doors have cracks in the metal below the window about 3-4 inches from side of door. cracks are about 1 inch long. *ak | |||
| 08/21/2001 | 1 | ||
| Door has crack by lowerrear of the belt molding.*ak | |||
| 08/01/2001 | 1 | 01/01/2001 | |
| Around 1 august 2001 i was talking with some friends at work, during the conversation defects in the door design of the new ford f-150 pickup truck came up. i had purchased an f-150 super cab in april 2001 and hadnt heard anything about this defect. my friends stated that the door on the new f-150s werent designed properly for the weight of the door and would start to develop cracks. they said that if i took it to the dealer ford would pay to repair the cracks. i checked my truck and i noticed a crack at the lower right corner of my drivers door near the bottom of the window. i went to crowne ford in warrensburg, mo 660-747-7111, on 6 aug 01 and spoke with mr. chris marten he informed that i needed to contact ford directly because even though i purchased the vehicle in april 2001 the warranty on my truck expired in february 2001. after arriving at home i called ford on 6 aug 01 at 11:45am at 800-392-3673 and spoke with mark, employee # 2547. mark informed me that ford would not repair the defect since the 3/36-warranty period had expired. (note) what i have since discovered is that ford has known about this defect since 1997. the defect was corrected in the 2000-year models but many customers who discovered cracks and brought their trucks in for repair prior to 2000 had new doors installed with the same defect in them. ford has even sent out a technical bulletin to their dealers, article # 01-2-6 but failed to inform the public about the defect. ford would pay for the repairs only if the customer brought it to the dealers attention within the warranty period. there seems to be a continuing problem with ford not informing the public about known defects with their vehicles until after someone gets killed or seriously injured. i hope that the nhtsb can help resolve this defect for all ford f-150 owners and myself. *ak | |||
| 08/04/2001 | 2 | ||
| There's a crack on driver's side door frame just above handle near window frame area. crack is just starting. have taken to dealer , and mechanic indicated problem was stress. there is a technical service bulletin in place on this procedure. manufacturer knows of problem , and had changed door design in newer vehicles. *ak *slc | |||
| 07/01/2001 | 1 | 03/01/2001 | |
| Drivers side door crack bottom right, next to window. *ak | |||
| 05/01/2001 | 1 | 03/01/1998 | |
| I noticed the paint cracking and went to the local dealership. they sent me to the warrenty paint shop, which detedted the thickness of paint. the truck has never been painted by me, the original owner. the paint shop also told me, and showed me the crack in the door. the local dealership said they could do nothing for me, but cintact the regional ford rep. she said ford will only pay % 20 of the $4450 cost for the paint and door. i feel this is outrageous, since i had nothing to do with the damage and poor quality. the ford national customer relationship center has been notified and kept abreast of the situation. they say today that the regional rep has the final say. if this is a defect from the factory, and because i took good care of the truck so the defects didn't show up until 61,000. why should i pay? i'd like to know what %80 i caused?*ak | |||
| 05/15/2001 | 1 | 06/01/1998 | |
| Ford knows their is a problem with f150 doors cracking and has even sent out a bulletin to their dealers , because my truck was out of the warranty by 2000 miles they would not fix the problem i beleive if involved in a crash this defect will result in a failure of the door ,i think ford should replace the doors because of an safety issue. *ak | |||
| 06/01/2001 | 2 | 12/01/1998 | |
| Both front doors are cracking also every 1997 ,1998 ,1999, ford f-150 extended cab truck i looked at had also cracked this is going cause injury's in an accident because i know the door is designed to help cushion impact on certian types of collissions the crackes have know compromised the integrity of the doors . i am apolled at the arregance of big bussiness not standing behind thier $30000 product also at how weak your safety agency is you should protect the public 100% and make all the auto manufactures produce quality vehicles and stand behind them ,thanks chuck matthews | |||
| 06/05/2001 | 1 | 12/01/1997 | |
| Door skin has a crack coming out from under door window seal lower right hand corner approximatley 4 inches up from the bottom. same area that is referenced in ford tsb number 996754 sequence number 845, dated 9908. nhtsa item number sb608461. ford dealer says they are unaware of any problems in this area, yet in looking at their used trucks, 1997 thru 2001 all trucks have cracks in drivers door and most in passenger doors. *ak | |||
| 1 | 05/01/1998 | ||
| Crack in the door sheet metal at the lower rear of the window opening near the belt molding.*ak | |||
| 05/19/2001 | 1 | 10/01/1998 | |
| Drivers side door crack starting at lower right hand side of side window running horizontal about 1 long. *ak | |||
| 05/01/2001 | 02/01/1998 | ||
| No summary listed for above vehicle. *ak | |||
| 03/01/2001 | 0 | ||
| When consumer closes driver's side and passenger's side doors there are stress cracks on molding. there has been more than one incident.*ak | |||
| 04/24/2001 | 1 | 08/22/2000 | |
| A crack has developed in structure of driver's side door. weld holding door together at base of window was cracking.*ak *jb | |||
| Doors are starting to break on outside where curve begins, cause is unknown. please provide further information.*ak | |||
| 04/06/2001 | 1 | 11/01/2000 | |
| Driver's side door sheet metal exhibits a crack at the lower rear of the window opening near the belt molding.*ak | |||
| 03/10/2001 | 2 | 03/01/2001 | |
| Outside sheet metal fatigue at lower rear corner of both door windows adout 1/4 ford won't repair.*ak | |||
| 01/29/2000 | 1 | 10/25/1997 | |
| The drivers side door cylinder is hard to open. nlm | |||
| 03/27/2001 | |||
| The drivers door is splitting looking at the door, bottom right hand side of the window. its starting to crack the door. *ak | |||
| Door light on dash panel stays on even though all doors are closed properly. cause is unknown.*ak | |||
| 03/21/2001 | |||
| A crack in metal outside driver's door where seal meets window. dealer / manufacturer notified, and informed consumer that vehicle was out of its warranty, and there were no recalls on that problem. please provide any further details on this matter. *ak | |||
| 03/05/2001 | |||
| Driver's side door is cracking right above door handle near window. has not contacted dealer yet. *ak | |||
| 03/16/2001 | 0 | ||
| There is a hairline crack right below the window frame forming on door.*ak | |||
| Driver's side door has a crack down middle, on outside. crack is very visible from a distance and to the naked eye. took vehicle to dealership, and was informed by mechanic that crack on door would not be repaired due to mileage on vehicle. owner had reported problem when vehicle had 41,000 miles, but nothing done at that time.*ak | |||
| Structure of driver's side door is breaking up around window. ford has not been contacted. *ak | |||
| 03/01/2000 | 1 | 10/01/1998 | |
| Door skin is cracked at beltline on passenger door. dealer response: we'll look into it this seems to be a fairly common problem wirh the 97 and up f150s.*ak | |||
| 1 | 06/01/2000 | ||
| Ford wants $150 to make the repair since the warranty has expired / i am not at fault for the manufactured defect. no safety defect listed. *ak | |||
| 01/01/1999 | 02/01/1998 | ||
| Drivers door sheet metal has 3/4 horizontal crack even with window sill, looks like top of door could break off in a crash. *ak | |||
| 12/01/2000 | 0 | ||
| Driver's side door panel is splitting when consumer closes door. there are cracks inside and outside, exterior is showing big cracks. ford was notified. *ak | |||
| 05/08/2000 | 1 | 02/01/1998 | |
| Driver's side window, as consumer is facing door, there is a crack in door. took vehicle to dealer, and they said it was a cracked weld. *ak there was cracking on door and roof seams but necessay repair was done on warranty. *yh | |||
| 10/16/2000 | 2 | 10/01/2000 | |
| From 1997's to 2000's f-150 1 or 2 of their doors are cracking just above the door handles at bottom of glass on the exterior ford motor co. has service bulletins dated in 1998 on my truck telling of these cracks . 2 people in my family has this problem also with their 2000's, and just about everyone i tell has the same problem , a lot of them aren't aware of it, ford wants to pay 80%, they should pay it all. *ak | |||
| 10/16/2000 | 2 | 10/01/2000 | |
| On 97's and up the doors are cracking just above the door handles on the outside there is service bulletins on my 98 telling of these cracks just about everyone i talk to has this problem and didn't know anything about it. ford wants to pay 80% ,i feel they should have a recall on all of them and pay it all. *ak | |||
| 10/01/2000 | 2 | 10/01/1997 | |
| Both the driver's and passanger's doors have sheet metal failure next to the lower rear corner of the window. crack is approximately 1/2 inch long and appears to be growing. dealer says ford knows of this issue but is not covering it. | |||
| 09/01/2000 | |||
| Crack in drivers side door .seems to be a very common problem. | |||
| 1 | 12/01/1999 | ||
| Driverside door has a 1/2 crack in sheet metal around window. took truck to nearest dealership and they blew me off. called ford motor company, they also blew me off. ford has numerious trucks in the 1997-98 year having same problem. they won't do any nessicary repairs. they should have a recall, due to the fact that this is a manufacturing defect. *ak | |||
| 08/12/2000 | 1 | 08/01/1998 | |
| There are so many complaiets on the cracked door why is there not a recall? | |||
| 08/20/2000 | 1 | ||
| My truck has a crack in the outside body sheet metal near the corner of the drivers window on the door. dealership where i bought it says nothing they can do because it is out of warranty. this crack is due to maufactures defect. i need help in bearing the cost of repair. nhtsa item # sb608461 / service bulletin # 99-6754 | |||
| 08/04/2000 | 1 | 03/01/2000 | |
| The door crack is at the base of the lower window structure. the crack will continue to increase in size further weakening the door strength. it is unknow if the door will remain intact during collision. personal survey results : 62 vehicles examined, 52 had cracks, 2 were repaired under warranty by manufacturer. | |||
| 07/12/2000 | |||
| Driver's and passenger's side doors are cracking vertically, and the upper and lower doors are detaching from panel. *ak | |||
| 12/20/1998 | 2 | 05/01/1998 | |
| Cracks in the door sheet metal at the lower rear of the belt molding. *ak | |||
| 06/06/2000 | 1 | 07/01/1998 | |
| I have noticed a small crack forming in the metal on the driver side door. if your facing the door form the outside, the crack is located by the lower right hand corner of the window. after doing some research i have found that this is a problem in many newer model ford trucks. *ak | |||
| 1 | 09/01/1998 | ||
| Crack developing in driver's side door sheet metal on aft post. approximately 1/4 long. have not contacted dealer. personally inspected 5 other like trucks and found all to have similar cracks. *ak | |||
| Both driver's side and passenger's side doors have cracked. both doors were replaced. however, problem has reoccurred on the driver side. consumer has contacted dealer. please provide any further details. *ak | |||
| 10/01/1999 | 1 | 10/01/1999 | |
| Crack in driver's side door beyond window molding. *ak | |||
| 1 | 01/01/2000 | ||
| Driver side door has a 3/4 inch crack developing from about 1 from the rounding from the bottom rear corner of the outside window molding (metal part of the door) and have notice avery ford 150 i've look at has this door crack. and over hafe of have them have them on both driver & passenger doors. there seem to be a disign flaw that ford motor company doesn't want to say yes to. and fix the flaw and not just put a band-aid fix on it. you spend any where's from 22,000 to 29,000 not including tax and all they are going to do is drill weld and bondo. that's a poor engneering design. i could under stand if the truck only costed $1000 not only is there a safety concern for starters. lets get to the bottom of this once and for all?*ak | |||
| 11/01/1998 | 2 | 03/01/1998 | |
| Deal has attempted to fix both brakes and the door cracks: brakes still do not work and door cracked again. dealer now will not fix them again. *ak | |||
| 12/09/1999 | |||
| Both doors are experiencing cracks in the metal. dealer/manufacturer were not contacted at this time. *ak | |||
| 11/26/1999 | 1 | 10/01/1998 | |
| Crack found on door, i have heard of many others exeriencing this problem | |||
| 10/15/1999 | 1 | 10/01/1997 | |
| There is a crack developing in the door sheet metal at the lower rear of the belt molding. could lead to disassembly or failure of door | |||
| 11/05/1999 | 1 | 06/01/1998 | |
| Crack developing on door, at rear side of window, 2 above bottom of window. almost every f-150 owner who's heard of this problem has taken a look at his/her truck and found same problem. ford not making any effort to remedy. | |||
| 09/01/1999 | 1 | 11/01/1998 | |
| There is a crack (1/2 in length) that has developed on the outer sheetmetal of the drivers door on the lower left hand corner near the l shaped weatherstripping. this crack is growing weekly and structural integrity in an accident is my major concern as the crack can act as a crumple joint. cosmetically it is also likely to begin to rust if not corrected as the paint is beginning to peel around the crack. | |||
| 09/15/1999 | 1 | 11/01/1997 | |
| Cracks appearing in door | |||
| 09/12/1999 | 06/01/1998 | ||
| As stated, the door is cracking at the rear of the driver's side window approximately 1/4 of the way up from the bottom of the window. i have personally seen numerous f150 vehicles with the same type of crack. i believe this to be a safety issue because of the compromise of the structural integrity of the vehicle at normal speed as well as during a crash. | |||
| 09/01/1999 | 2 | 12/01/1997 | |
| Door sheet metal cracking around window. unknown affect to integrity of door. | |||
| 03/01/1999 | 1 | 08/01/1998 | |
| This is my second truck (frist one was 1997 w/two cracked doors which dealer bought back) with this problem. the sheet metal on doors crack at the at the window trim do to stress created when raising and lowering window. ford won't admit problem | |||
| 05/14/1999 | |||
| Driver's side door and passager's side doors have cracks within the frame and panel. both door's are rusting at the bottom when driving at 25 mph on wet pavement. also, when applying brakes rear brake's will lock up. *ak | |||
| When driving 50 to 60mph the vehicle makes excessive wind noise around the door and cab area. dealer says it's normal. *ak | |||
| 06/10/1998 | 1 | 06/10/1998 | |
| Doors do not shut properly consumer must slam doors. | |||
| 05/19/1998 | 1 | 03/01/1998 | |
| Steering shaft failure. also, power door locks failed/abs brakes malfunctioned, causing brakes to vibrate upon braking. | |||
| 05/19/1998 | 1 | 03/01/1998 | |
| Car would shake at 45 mph, causing tires to go out of round. | |||
| 05/19/1998 | 1 | 03/01/1998 | |
| Steering pulls. | |||
| STRUCTURE - BODY - DOOR - HINGE AND ATTACHMENTS | |||
| 08/10/2005 | 80000 | 1 | 04/07/2000 |
| I have a 1998 f-150 at the bottom of the window my doors are splitting and starting to rust i know its happening quite a bit i work in the industry and see this on a regular basis also the ford dealers do have a fix for this problem but the consumer pays it is not covered why?*jb | |||
| Driver's side door has started to separate from welds. manufacturer has been notified. please provide additional information.*ak | |||
| STRUCTURE - BODY - ROOF AND PILLARS | |||
| 01/10/2004 | 1 | 02/27/2001 | |
| Rear window started leaking from the top - it now pours in when raining, damaging the back seat in the extended cab pickup. there is no crack and the leaking is not from the sliding glass, instead from the top on both sides of the sliding glass. *la | |||
| STRUCTURE - FRAME AND MEMBERS | |||
| 09/12/2010 | |||
| The strap on my gas tank on my 1998 ford f-150 xl has rusted apart from the weld and is hanging off. | |||
| 03/01/2000 | |||
| Have contacted ford serveral times and they say there is nothing wrong with the trucks. no safety defect listed. *ak | |||
| 11/01/1999 | 1 | 07/01/1998 | |
| Rear of left side frame cracked piece fell off @ t/hitch mount | |||
| STRUCTURE - FRAME AND MEMBERS - UNDERBODY SHIELDS | |||
| 12/01/2004 | 161000 | 1 | |
| While changing the shocks on the vehicle consumer noticed the rear frame broke. no explanation as to how or why.*ak | |||