Recalls


CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE
92V112000FORD MOTOR COMPANYfrom 08/01/1991 to 05/01/1992V (Vehicle)4800011/06/1992ODIFORD MOTOR COMPANY08/04/199208/17/1992
Defect SummaryThe sound insulation on the engine side of the dash panel can contact the exhaust manifold.
Consequence SummaryContact between the insulation and the hot exhaustmanifold may result in a engine compartment fire.
Corrective SummaryDealers will modify the sound insulator at no cost to owners.
NotesSystem: engine compartment; sound insulation.vehicle description: trucks and chassis cabs equipped with 7.3 liter dieselengines.

Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
ENGINE AND ENGINE COOLING - ENGINE
01019801/01/1998605721Some vehicles may develop cavitation erosion in the cylinder wall of the engine. *tt07/22/1999
9552205/01/199545074Accessory drive belts - all 7.3 idi diesels come off accessory drive pulleys - vehicles built after 2/15/92. *tw11/01/1995
BC422504/01/19953055147Unknown11/01/1995
956803/01/199539904Revised oil pan gasket. *tw11/01/1995
9552203/01/199539891Some diesel powered vehicles are experiencing drive belt tracking concerns due to front end accessory drive pulleys (fead) misalignment. *tw11/01/1995
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE
958804/01/199541029Knocking noise on initial start-up. *tw11/01/1995
BC422504/01/19953055147Unknown11/01/1995
9552403/01/199539892There may be a concern of poor performance, coolant in the oil and engine knocking and/or hydraulic lock on some vehicles. *tw11/01/1995
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS
974802/17/199751691Accessory drive belts- fead belt comes off- vehicles with 4.9l engine. *jd06/27/1997
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM
986403/30/1998601312Information on a buzzing or rattle noise from the exhaust system. *tt07/21/1998
BC422504/01/199539831Vehicles with manual transmission may have a lack of power or no start condition caused by a plugged catalytic converter or muffler. *tw11/01/1995
95101505/01/199542099Hydromounted cab - evaporative emission lines rubbing on the fender. *tw11/01/1995
BC422504/01/19953055147Unknown11/01/1995
BC268195050305/01/199540086Lack of power or no start condition may be due to exhaust restriction caused by a plugged catalytic converter and/or muffler. *tw11/01/1995
9571104/01/199541012Some vehicles may exhibit a lack of power or a no start condition due to an exhaust restriction. *tw11/01/1995

Investigations


NHTSA IDManufacturerDate openDate closeSubjectRecall campaign
ENGINE AND ENGINE COOLING
PE92055FORD MOTOR COMPANY06/24/199208/20/1992ENGINE COMPARTMENT FIRES92V112000
 There is no summary currently available
PE93010FORD MOTOR COMPANY03/02/199307/30/1993IDLE AIR SPD CTRL VLV MALF
 There is no summary currently available
EA93022FORD MOTOR COMPANY07/30/199308/31/1994IDLE AIR SPD CTRL VLV MALF
 There is no summary currently available

Consumer Complaints


Fail datemilesoccurencesPurchase date
ENGINE AND ENGINE COOLING - COOLING SYSTEM - HOSE
11/30/19991
 All cooling system hoses were getting very soft. nlm
ENGINE AND ENGINE COOLING - ENGINE
11/30/19991
 The right side manifold was warped resulting in an exhaust leak, 2 bolts were also broken in the cylinder head. nlm
06/01/19951
 Engine pulley crankshaft failed.. *sd
07/26/19956
 Cylinder wall developed pinhole due to corrosion. *tt
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE
04/01/1999101/01/1994
 Engine cylinder had a small hole in the cylinder side wall due to latent casting defect in the engine compartment. mjs
03/20/1999108/01/1992
 Holes in cylinder wall caused engine to fail. nlm
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS
03/01/2000206/01/1992
 Serpentine belt tensioner failed twice on vehicle while consumer was driving, consumer lost steering and brakes. contaced dealer ,and the dealer was not willing to do anything.*ak *slc
01/02/2000407/01/1992
 This is the second time that this unit has failed on this truck. it was replaced by ford under a recall the first time. now it has failed again with the same results. both times it was caused by the belt tensioner wearing prematurely, causing the belt to ride forward off the pulleys and shredding itself. this is a safety issue because when this happens, power steering and power brakes become inoperable. *ak
10/03/1992809/01/1992
 I have had continual serpentine drive belt failures since purchasing it new. ford has made several attemps to correct but has been unsuccessful. in 92,000 miles i have had eight belt failures. each time all power assist on breaks and steering is lost and becomes nearly impossible to steer or stop. on my last visit to the dealer they estimated $800.00 to correct the problem but would not guarantee it would be a permanent fix. in 1995 or 96 i received a letter from ford motor company advising me to bring it in for a service bulletin related to the serpentine drive belt problem. at the time my company had me working on the east coast, by the time i returned home it was about ten days past the experiation date for the service bulletin. the local dealer refused to honor the service bulletin as did ford motor company. ford has acknowledged that there is a problem but refuses to fix it. my family has been very lucky in avoiding an accident to date because of loss of steering and brake control each time the drive belt breaks. any assistance you can provide will be greatly appreciated as ford appears to be uninterested in correcting this known safety contition. *ak
04/18/19961
 Serpentine belt misaligned due to some engineering error that has caused premature wear.
06/01/19951
 Engine belts loose/fall off, causing failure. *sd
06/20/19951
 The belts break in the pully, causing loss of power steering/brakes. *ak
04/01/19943
 Vehicle has had 3 failures of the belt breaking, causing loss of power assist and other functions.(ea95-012). tt`
 Engine belt that operates steering and braking function broke 15 times, replace. tt
04/01/19953
 Serpentine belt continuously fails, interrupting other engine functions. tt
12/31/1994
 The fan belt fell off about ten to twelve times keep taking it back to be fix. tt
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL
11/30/19991
 The right side manifold was warped resulting in an exhaust leak, 2 bolts were also broken in the cylinder head. nlm