Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
98167 | 04/07/2000 | 609736 | Transmission-e40d-no 2-3 upshift. some vehicles may exhibit a no 2-3 upshift condition. *ak | 04/07/2000 | |
98168 | 04/07/2000 | 609737 | Transmission- e40d/4r100-1989-99-main controls, separator plates and separator plate gaskets usage chart. yd | 04/07/2000 | |
97511 | 03/03/1997 | 51945 | Fluid- transmission fluid usage charts. *jd | 07/17/1997 | |
95619 | 03/01/1995 | 39913 | New design transmission range sensor. *tw | 11/01/1995 | |
BC4321950705 | 07/01/1995 | 45059 | Vehicles experiencing occasional harsh reverse engagement concerns. *tw | 11/01/1995 | |
951112 | 06/01/1995 | 45085 | Revised design transmission rear case bushing. *tw | 11/01/1995 | |
BC4225 | 04/01/1995 | 3055147 | Unknown | 11/01/1995 | |
951113 | 06/01/1995 | 45086 | Delayed forward engagement and/or heat stained forward clutch plates after installing center support service. *tw | 11/01/1995 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER | |||||
96249 | 11/18/1996 | 50908 | Torque converter - leak test procedure - service tip. *tw | 06/17/1997 | |
962612 | 12/16/1996 | 50997 | Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw | 06/17/1997 | |
POWER TRAIN - AXLE ASSEMBLY | |||||
983074 | 02/27/1998 | 607369 | Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers. *tt | 09/21/1999 | |
12905 | 06/01/1999 | 606937 | Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt | 09/08/1999 | |
BC0131960102 | 12/01/1995 | 46438 | 4x4 front axles must use hypoid 4x4 gear oil p/n f1tz-19580-a & high temp 4x4 front axle & wheel bearing grease when servicing. it is not recommended to use heavier weight lubes in these front axles. | 04/25/1996 | |
POWER TRAIN - CLUTCH ASSEMBLY | |||||
96728 | 03/25/1996 | 613350 | Service tip information regarding the reverse clutch piston and piston seal usage. *tt | 06/22/2000 | |
POWER TRAIN - CLUTCH ASSEMBLY - PEDAL/LINKAGE | |||||
BC3287970206 | 02/06/1997 | 51883 | The clutch may be hard to depress due to dust/contamination entering the slave cylinder. *tw | 07/17/1997 | |
POWER TRAIN - DRIVELINE - DRIVESHAFT | |||||
962415 | 11/18/1996 | 50913 | Vibration - driveline vibration and/or driveline noise - regular cab 4x4 vehicles equipped with 7.5l engine and manual transmission. *tw | 06/17/1997 | |
BC0682961024 | 10/24/1996 | 50358 | Vehicles may exhibit a driveline vibration or noise while driving at highway speeds on steady cruise or decel. *tt | 04/24/1997 | |
POWER TRAIN - MANUAL TRANSMISSION | |||||
BC2301970501 | 05/01/1997 | 52797 | New clutch slave cylinder with a redesigned lip seal. *tw | 09/12/1997 | |
BC0678961025 | 10/25/1996 | 50356 | Information on aode/4r7w transmission main control & case replacement. *tt | 04/24/1997 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
POWER TRAIN | ||||||
EA95012 | FORD MOTOR COMPANY | 03/31/1995 | 05/28/1996 | FAILURE OF SERPENTINE BELT | 96I003000 | |
There is no summary currently available | ||||||
EA95012 | FORD MOTOR COMPANY | 03/31/1995 | 05/28/1996 | FAILURE OF SERPENTINE BELT | 96I003001 | |
There is no summary currently available | ||||||
EA95012 | FORD MOTOR COMPANY | 03/31/1995 | 05/28/1996 | FAILURE OF SERPENTINE BELT | 96I003002 | |
There is no summary currently available |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||
07/15/1998 | |||
Consumer had 2 rebuild transmissions put in a year. once vehicle went into overdrive and if the light came on, consumer had to get to a delaer immediately or transmission would be ruined. when vehicle was put on the diagnostic machine, they couldn't find anything. but, when test driven they knew that there was a problem. *ak | |||
07/19/1997 | 1 | 04/01/1993 | |
Transmission park engagement failed, causing accident. | |||
04/06/1995 | 6 | ||
Vehicle bumps/jerks, especially in second gear. *aw | |||
04/12/1995 | 2 | ||
Transmission problems. *skd | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||
08/03/1994 | 3 | ||
Transmission lines broke, causing fluid leak. | |||
08/24/1995 | |||
Engine compartment fire, automatic transmission cooler line leaked and caught fire. tt | |||
06/11/1993 | 1 | ||
Transmission cooler line leak. *ak | |||
POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT - SEAL | |||
02/01/1994 | 2 | 01/21/1993 | |
Wheel axle seal leaks oil onto brake shoes, causing brake failure. | |||
05/24/1996 | 4 | ||
Rear axle seal leak onto left rear brake shoes, causing brake failure/accident. *sd | |||
POWER TRAIN - AXLE HUBS | |||
01/27/1999 | |||
4- wheel drive locking hubs failed, causing power train axle assembly to lock up. vehicle in dealer shop. *ak | |||
POWER TRAIN - CLUTCH ASSEMBLY | |||
09/01/1992 | |||
Whiletraveling the clutch went completley out, causing the vehicle to continue to accelerate, key was removed from the ignition in order to stop vehicle. consumer has contacted the dealer, dealer has replaced the clutch four times. problem still occurs. please provide any further details. *ak | |||
02/27/1995 | |||
Upon shifting to another gear the clutch assembly breaks. resulting in a loss of fluid. this is the fourth occurrence. *ak | |||
POWER TRAIN - CLUTCH ASSEMBLY - PEDAL/LINKAGE | |||
08/13/1998 | |||
The clutch master cylinder assembly bushing that holds the clutch arm that goes through the fire arm plastic piece, breaks/snaps and clutch goes to the floor. dealer has replaced four times, and cannot duplicate the problem. *ak | |||
04/01/1998 | |||
The clutch linkage comes off the clutch arm , causing the vehicle not be able to shift gears or brake, which may cause an accident. *ak | |||
04/17/1998 | 1 | 11/05/1992 | |
Going 15mph, pressed the clutch pedal. went to floor. stopped vehicle. checked problem. noticed piece on ground had broken. towed vehicle to dealership. mechanic said master cylinder needed replacing. could not order small plastic piece for clutch. *ak | |||
POWER TRAIN - DRIVELINE - DRIVESHAFT | |||
03/29/1996 | 9 | ||
Drive shaft fell off. *sd | |||
POWER TRAIN - DRIVELINE - UNIVERSAL JOINT | |||
05/16/1996 | 1 | 09/01/1995 | |
Universal joint failed. | |||
05/01/1994 | 1 | ||
Universal joints repaired due to front end shaking. *sd |