Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||||
| BC2297970501 | 05/01/1997 | 52793 | When the air cleaner is being replaced, the drain mechanism on the bottom of the air cleaner case is to be cleaned of obstructions. *tw | 09/12/1997 | |
| 962211 | 10/21/1996 | 50950 | Air cleaner - damaged air filter in severe dusty conditions - vehicles with 7.3l dit diesel engine built through 5/8/96 - service tip. *tw | 06/17/1997 | |
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
| 980323 | 01/01/1998 | 607727 | Dtc's p1211/1212 icp pressure higher/lower than expected. | 02/15/2001 | |
| BC4225 | 04/01/1995 | 3055147 | Unknown | 11/01/1995 | |
| 95613 | 03/01/1995 | 39908 | A no start or reduced power condition may occur intermittently on some vehicles. *tw | 11/01/1995 | |
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||||
| BC1351950906 | 09/01/1995 | 45752 | Rough idle or miss may be due to loose injector hold down bolt. *tw | 04/25/1996 | |
| 95108 | 05/01/1995 | 42093 | Vehicles may be hard to start after the fuel injectors have been replaced. *tw | 11/01/1995 | |
| FUEL SYSTEM, OTHER | |||||
| 032127 | 10/30/2003 | 971118 | 10004838 | Lack of power and/or low performance condition caused by no return fuel flow to the fuel tank. *tt | 01/09/2004 |
| 03218 | 10/30/2003 | 952512 | 10004819 | The water-in-fuel lamp may stay on and the fuel may be slow to drain or not drain at all when the fuel drain valve is opened. *tt | 01/08/2004 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, GASOLINE - DELIVERY | |||
| 05/25/2001 | 02/01/2001 | ||
| Exhibiting same symptoms ad nhtsa campaign 00v231000. *ak | |||
| 10/25/1999 | 1 | 07/01/1996 | |
| While towing our 5th. wheel trailer in the curb lane on an interstate highway, we experienced a blow out which actuated the emergency fuel shut off valve. the right, front truck tire blew out and the associated bumpy/shuddering apparently caused the fuel shut off valve to close. we were able to pull off the highway, but with considerable difficulty. when the fuel starved motor shut down we lost power steering and power brakes which added to the difficulty controling the rig. nobody was injured and we were able to install the spare tire and re-set the fuel valve. our concern is that the fuel shut off valve may have actuated too easily. if we had been traveling in the center lane there is a good chance we would have been unable to reach the safety of the median or shoulder of the highway.( dot number: tire size: lt23585r16 ) | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
| 1 | 06/26/1997 | ||
| The fuel pump in the front tank pumps fuel from the rear tank to the front tank causing the front tank to overflow while driving, ford refuses to do anything about the problem. nlm | |||
| 07/29/1996 | 1 | 11/01/1994 | |
| Fuel pump failure, causing vehicle to stall. *sd | |||
| FUEL SYSTEM, GASOLINE - STORAGE - AUXILLARY TANK - SELECTOR DEVICES | |||
| 09/10/2001 | 1 | 08/08/1994 | |
| When filling up one tank it caused other tank to overflow. *ak consumer states that 1993 models have been recalled. *yh | |||
| 1 | |||
| Vehicle not included in recall 00v424000. a malfunctioning check valve allows fuel to transfer from one tank to another, resulting in fuel leakage. *ak | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
| 10/01/1999 | 1 | 04/01/1994 | |
| Rear dual gas tank malfunctions and fuel odor comes out of it. yh | |||
| 10/01/1999 | 1 | 08/01/1995 | |
| The dual fuel tanks malfunctioned causing gas leakage. yh | |||
| The seam on the front fuel tank has a leak in it at 25,800 miles. the dealer has been contacted. *ak | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
| 03/01/2005 | 85000 | 1 | |
| Fuel flowing from fuel tank filler cap. 1994 ford f-250 with dual fuel tanks has condition which overfills tank and causes steady fuel flow from filler cap. corrective action required replacing both fuel pump assemblies. there are multiple complaints of this condition in this database, unfortunately they are spread through varying categories. manufacturer warranted same condition for previous model year (1993) but was unresponsive to inquiries regarding 1994 model year.*ak | |||
| 10/01/1999 | 08/01/1995 | ||
| Fuel overflows out of filler cap fire hazard. *ak | |||