Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
SUSPENSION - FRONT | |||||
98158 | 08/03/1998 | 609538 | Front end shimmy may occur at various driving speeds and is usually induced when hitting bumps, such as large potholes or rough railroad crossings. shimmy is not always verified during road test. *ak | 04/03/2000 | |
BC0321961101 | 11/01/1996 | 50729 | Pop/clunk from steering linkage over bumps. *tw | 06/17/1997 | |
9597 | 05/01/1995 | 42080 | Unknown | 11/01/1995 | |
BC4336950705 | 07/01/1995 | 45061 | Front suspension clunk. *tw | 11/01/1995 | |
SUSPENSION - FRONT - HUB | |||||
97628 | 03/17/1997 | 52011 | Noise- ratcheting- front axle- 4x4- self-engagement of automatic hub locks- bronco, f-150 and f-250 under 8500# gvw. *jd | 07/17/1997 | |
97627 | 03/17/1997 | 52010 | Noise- ratcheting- front axle- 4x4- self-engagement of automatic hub locks- f-250 and f-350 over 8500# gvw. *jd | 07/17/1997 | |
SUSPENSION - FRONT - SHOCK ABSORBER | |||||
BC4369950906 | 09/01/1995 | 45762 | 4x4 trucks produced at michigan truck plant between may 15 and june 6, 1995 may exhibit a front suspension clunk or rattle. *tw | 04/25/1996 | |
SUSPENSION - FRONT - SPRINGS - LEAF SPRING ASSEMBLY - HANGER,BRACKET | |||||
97310 | 02/03/1997 | 51669 | Noise- popping/creaking- front frame or suspension brackets- frame- popping/creaking- fastener replacement. *jd | 06/27/1997 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
SUSPENSION | ||||||
PE96052 | FORD MOTOR COMPANY | 08/23/1996 | 01/27/1997 | SEPARATED FRONT SUSPENSION | ||
Allege front suspension members can become separated from the vehicle's frame causing potential loss of control |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SUSPENSION | |||
11/01/2004 | 1 | ||
Axle problems with travel trailer. amount of carrying axles under these vehicles , not sufficient in size or strength to take the load or road punishment without failing. *bf the consumer noticed that the vehicle did not pull properly. there was a side to side pull as it went down a down grade and would wander as it pulled down the road. this problem eventually increased to a violent whip. upon inspection, it was noticed that there was a lot of uneven tire wear due to axle misalignment. the axles were found to support 8285 pounds. (komfort 2000 25 ts travel trailer/vin 1k52ktl22y1022713) *sc | |||
10/20/1998 | 3 | ||
Suspension frame bolts and nuts had to be replaced or tightened. had heard noises & took vehicle to dealer for repairs. *ak | |||
10/12/1999 | |||
Whenever the wheels are turned, the rivets would come loose & make loud noises. took vehicle to dealer & the mechanic. this problem had happened before. was not checked the first time. *ak | |||
1 | |||
Two pivot bolts loosened and fell off, causing suspension sytem not to hold. please provide further details. *ak | |||
04/28/1998 | 07/01/1995 | ||
While driving on uneven pavements the vehicle vibrated violently. the dealer said that a screw on the side of the twin i-beam came loose. the dealer has replaced it. *ak | |||
04/01/1996 | |||
Consumer was pulling a 5th wheel trailer when the bar attaching the frame bolts of right front wheel came loose because all four bolts holding i-beam to frame came off. when pulling into a parking space, the top of the wheel was inward and the bottom was outward, dealer replaced the bolts. *ak | |||
07/11/1996 | 1 | ||
Front suspension failed. *dh | |||
09/01/1995 | 1 | ||
Front axle mounting bolts loosen, causing problems with stability/handling. (sixth vehicle on 501504, 601386, 601387, 601388, 601389) *dsh | |||
SUSPENSION - FRONT | |||
10/26/2005 | 1 | 11/01/2004 | |
Dt: the contact stated the bolts retaining a bracket for the front end failed, and the front axle was allowed to move around. the contact went to the dealership and ordered the parts to fix the vehicle by himself. he had not spoken to anyone a t ford about the defect. he still has the defective parts. the bolt held on the driver's side differential frame. *ak | |||
01/02/1995 | |||
Front end has rivots that will wear out in time. consumer can never get vehicle aligned correctly. vehicle will shake when making turns, contacted dealer. *ak | |||
04/20/1997 | 11/01/1994 | ||
Vehicle's front suspension frame bracket that attaches to the axle broke off on right wheel bracket. *ak | |||
10/15/1996 | 2 | ||
While driving across railroad tracks, front end of vehicle vibrated as if hit ad tire a blowout, according to dealer, three bolts were missing, remaining bolt loose, dealer replaced all bolts. *ak | |||
01/01/1995 | |||
When making a turn at low speeds, the steering wheel shakes and the vehicle makes a clunking noise. *ak | |||
Consumer has had a continuous alignment problem which caused the vehicle pull to the right. *ak | |||
Vehicle pulls to the right while driving due to alighment problem that cannot be fixed, causes loss of vehicle control. please add further details. *ak | |||
The front end shimmies and when turning the vehicle to the right it pops really loud. *ak | |||
02/16/1995 | 3 | 02/16/1995 | |
Front end end misaligned, causing excessive wear to tires. | |||
Consumer was driving and the front end fell off . please describe . *ak | |||
12/01/1994 | 1 | ||
Suspensions i-arms loose. *dsh | |||
05/01/1995 | 1 | ||
Vehicle out of alignment, causing front tires to cup. | |||
05/02/1995 | 2 | ||
Vehicle pulls to the left. | |||
SUSPENSION - FRONT - SHOCK ABSORBER | |||
02/18/1995 | 8 | ||
Front shock absorber failed. *ak | |||
SUSPENSION - FRONT - SPRINGS - AIR SUSPENSION - SPRINGS/BAGS | |||
10/05/1999 | |||
Front left spring is rattling, and there is some type of knocking noise. dealer can't determine the cause of the problem. *ak | |||
SUSPENSION - FRONT - SPRINGS - LEAF SPRING ASSEMBLY - U-BOLT, LEAF SPRING TO AXLE | |||
08/01/1995 | |||
I bean on suspension bolts came unbolted while driving from the frame, vehicle is a four wheel drive. tt |