Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN | |||||
16915 | 05/01/2004 | 17813 | 10002626 | Excessive drive-away shudder or vibration under moderate to heavy acceleration from a stop. *tt | 09/08/2003 |
15292 | 10/01/2001 | 630192 | Some super duty f series equipped with pto capable transmissions may exhibit a failure to go t high idle upon pto engagement. *tt | 04/15/2002 | |
00142 | 07/10/2000 | 618529 | Inoperative or inaccurate speedometer, 4x4 lamp illuminated and / or diagnostic trouble codes (dtcs) p1635 or p1639 present after a powertrain control module (pcm) or instrument cluster replacement. *jb | 04/16/2001 | |
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
18376 | 01/01/2005 | 10013316 | A cold weather reverse engagement stall. *tt | 04/14/2005 | |
992111 | 10/18/1999 | 6089677 | Service procedure for orange service tagged 4t100 transmissions. *tt | 02/11/2000 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
042107 | 12/13/2004 | 042414 | 10014086 | General (pcm) power train control module programming procedures. *tt | 04/28/2005 |
04217 | 11/01/2004 | 10013369 | General power train control module (pcm) programming procedures. *tt | 04/15/2005 | |
00611 | 03/20/2000 | 612924 | Some bi-fuel vehicles may require powertrain control module (pcm) replacement during service and may not run on cng or lpg., recalibration of the pcm/replacement. *mjs | 06/13/2000 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||||
0038 | 02/07/2000 | 612343 | Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs | 06/07/2000 | |
POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT | |||||
8207 | 02/01/2000 | 612415 | Some vehicles equipped with 10.50-inch ring gear, full-floating rear axles may exhibit a leak at the outboard end of the axle shaft(s). *tt | 06/08/2000 | |
POWER TRAIN - DRIVELINE - DRIVESHAFT | |||||
00B53 | 10/01/2000 | 618563 | Vehicles may experience severe vehicle vibration, due to front driveshaft maybe one inch too long. *jb | 04/16/2001 | |
POWER TRAIN - MANUAL TRANSMISSION | |||||
15711 | 03/01/2002 | 636350 | Some vehicles equipped with a 5-speed mazda r2 manual transmission may exhibit a high effort condition when shifting any gear. *tt | 11/07/2002 | |
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
14043 | 04/01/2000 | 613694 | Information regarding transfer case hall effect encoder tips. **mr | 07/27/2000 | |
8487 | 04/01/2000 | 613651 | Information regarding transfer case hall effect encoder tips. **mr | 07/26/2000 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||
06/15/2005 | 110000 | 1 | 09/26/2002 |
Dt: live on lake, driveway has a slope and put the vehicle in park and the cut switch off get out of the truck and the vehicle started rolling. had to jump back in and mess with the gears in order to get the vehicle to stop.*ak | |||
06/02/2002 | 1 | 01/01/2000 | |
No summary listed for above vehicle. *ak | |||
04/16/2002 | 06/01/2000 | ||
I was driving home on the interstate when traffic stopped ahead of me. it was raining pretty hard and i was not able to stop and i hit a minivan that was in front of me. (there were 40 - 50 other vehicles involved in this incident, but my piece of the greater wreck only involved myself and the minivan.) i do not know how fast i was going when i made contact, but it was fast enough to cause $16,000 of damage to the front end of my truck. the impact mostly went above the bumper, pushing the grill into the front of the engine causing everyhing in front of the engine to be replaced along with replacement of the motor and transmission mounts. neither the driver or passanger airbag deployed. i was wearing my seatbelt, so i was not at all injured, but i was very surprised that a significant inpact like i experienced did not set off the airbag. are there any general guidelines for when the airbags should deploy?*ak | |||
01/30/2001 | |||
When turning left or right vehicle will shake. when pulling from a drop off or parking lot there was a loud humming noise. then, it faded away. driver also, when putting in gear, there was a clunck noise then a jerk.*ak | |||
There is a clucking noise when accelerating and deceleration. ford claims it is normal noise, but are working on resolution. | |||
3 | 06/01/2000 | ||
While driving vehicle gears shifts in and out of nuetral unexpectedly. recently engine shut off while being driven at 40mph which caused a loss of power steering. driver had to put gear into neutral, and start vehicle back up. an hour later , vehicle stalled again and would not start back up. dealer has vehicle currently. *ak | |||
While traveling 60 mph engine stalled without indication. dealer stated that transmission was blown. please provide further information. *ak | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||
10/13/2000 | 1 | ||
A company vehicle caught fire when using, vehicle had been examined, and fire was the result of transmission lines being positioned too close to exhaust system, a heat producing source. temperature that day was approximately 75-80 degrees. *ak manufacturer not willing to take any responsibility, they are stating there was no manufacturing defects that caused fire.*jb | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||
11/15/2000 | 1 | 01/01/2000 | |
Rear differential was leaking and transfer case was noisy. *yh | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - PARK/NEUTRAL START SWITCH | |||
01/23/2000 | 3 | 10/01/1999 | |
When ignition key is halfway between off position and on position, the gear shift lever can be moved into any gear/ without having to push on the brake pedal. this is a serious defect. *ak | |||
POWER TRAIN - AXLE ASSEMBLY | |||
50900 | 1 | ||
The truck is not steering properly, driver has to constantly fight to keep truck from wondering over the road. dealer says there is a crack on the handle that connects the stabilizer arm to the axle. *ak | |||
POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT - SEAL | |||
3 | |||
Vehicle fails to stop properly when brakes are applied. would shake and vibrate badly. took vehicle to dealership, mechanic noticed rotors were warped, which caused the braking problem. had them replaced after 10,000 miles.*ak engine stalls and oil leaks from the turbo into the inter cooler. transmission does not shift. tires began to bulge out, consumer did not specify kind of tires. electric window motor failed. seals are out on the front axles and they were just replaced two months ago. air filter system is inadaquet for this size of engine and has to be replaced every 2 to 3 thousand miles. *slc | |||
POWER TRAIN - CLUTCH ASSEMBLY | |||
10/01/2002 | 56000 | 1 | |
The clutch disengaged with the transmission while driving. ts consumer stated the clutch had cracked.*jb | |||
01/04/2000 | |||
Consumer has taken the vehicle in a few times for the clutch. the dealer can't seem to remedy the problem. the consumer will be contacting the manufacture to return the truck.*ak | |||
POWER TRAIN - CLUTCH ASSEMBLY - PEDAL/LINKAGE | |||
07/01/2001 | 2 | ||
Hydraulic clutch has failed two times while traveling less than 5 mph. dealership has replaced clutch disc assembly in an attempt to remedy problem. please provide any additional information / documentation.*ak | |||
POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||
11/15/2000 | 1 | 01/01/2000 | |
Rear differential was leaking and transfer case was noisy. *yh | |||
POWER TRAIN - DRIVELINE - DRIVESHAFT | |||
09/05/2000 | 62 | 08/01/2000 | |
Extreme vibration in rear driveshaft when towing in low gear. vibration is daily. *ak | |||
10/09/2000 | |||
Vehicle vibrated uncontrollably at various speeds. dealer has replaced driveshaft and tires, but vehicle continued to vibrate. manufacturer has been notified. *ak | |||
POWER TRAIN - MANUAL TRANSMISSION | |||
09/19/2002 | |||
Consumer states while shifting down from 2nd to 1st the gear goes into reverse. please provide any additional information. ts | |||
1 | 05/12/2000 | ||
Transmission experiences a clunk when shifting gears, at lower speeds the transmission will jerk. *slc | |||
1 | 04/26/2000 | ||
Faulty 5 speed transmission keeps popping out of 4th gear. dealer installed a new transmission. *ak *ml |