Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||||
032131 | 10/30/2003 | 98205 | 10004842 | Rough idle and engine miss due to injector bore scuffing at green engine break-in. *tt | 01/09/2004 |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
98205 | 10/12/1998 | 603690 | Exhibiting rough idle and engine miss due to injector bore scuffing at green engine break-in. *yc | 03/02/1999 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
982010 | 10/12/1998 | 603695 | Experiencing a buzzing or rattling noise from the exhaust system. *yc | 03/02/1999 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||
DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi | ||||||
ENGINE AND ENGINE COOLING - ENGINE | ||||||
DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi | ||||||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | ||||||
DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
10/25/2010 | 160000 | ||
My 1999 ford f 250hd has blown 3 different spark plugs out of the head.the repair cost is 400.00 each and ford acts like this is normal. this is a mfg. defect that ford will not admit to.our local dealer says they cant count how many plugs they have seen blown out | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
11/20/2009 | 180000 | 1 | |
Twice i have been stranded by the same problem. in july while driving on a major 4 lane highway towing my horse trailer, my 99 ford f250 with the v10 engine blew a spark plug. it sounded like and exhaust leak and i kept driving later to find out that this situation often causes an engine fire. again in november my truck did the same thing, same plug after the manufacturer recommended repair was done. this is not safe at all and a design defect of all triton ford truck engines. *tr | |||
12/21/2004 | 92076 | 1 | 02/12/2003 |
Spark plug blow out. right hand side. *nm | |||
05/27/1999 | 2 | 10/26/1998 | |
Failed oil pan, main bearing and long block caused the engine to knock. nlm | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
01/07/2000 | 1 | 10/26/1998 | |
Engine #3 leaking oil from left side causing smoking as it burns on exhaust manifold causing fumes to enter the vehicle resulting in the consumer feeling dizzy, lightheaded and develop a severe headache. nlm | |||
05/27/1999 | 2 | 10/26/1998 | |
Failed oil pan, main bearing and long block caused the engine to knock. nlm |