Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 12720 | 05/01/1999 | 6091697 | Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal intake coolant tube and the flexible rubber coolant hose. *tt | 11/09/2000 | |
| 6232 | 05/01/1999 | 607031 | Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal intake coolant tube and the coil resulting in engine misfire with diagnostic trouble code p0304 and / or rough idle. *tt | 11/03/2000 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| 15570 | 01/01/2002 | 630111 | Some vehicles may exhibit various driveability conditions including lacks power, hesitates, hard to start, and/or malfunction indicator lamp (mil) illuminated and produce possible diagnostic trouble codes p0103, p0172 and p0175. *tt | 04/12/2002 | |
| 01205 | 10/15/2001 | 627927 | Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt | 02/26/2002 | |
| 012110 | 10/29/2001 | 627768 | Some vehicles equipped with the romeo built 4.6l 2v engine may exhibit an engine oil leak or oil weepage from the cylinder head gasket at the right hand rear or the left hand front of the engine. *tt | 02/22/2002 | |
| 0147 | 03/05/2001 | 619424 | Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt | 05/30/2001 | |
| 0142 | 03/05/2001 | 619419 | Some vehicles may exhibit the engine oil sending unit contacting the oil drip shield attached to the front axle. *tt | 05/30/2001 | |
| 0182 | 04/30/2001 | 619273 | Some bi-fuel vehicles may exhibit a no start condition. *tt | 05/22/2001 | |
| 00238 | 11/13/2000 | 616519 | Some vehicles may exhibit a no crank / no start condition in temperatures below 12 degrees c (10 degrees f). *tt | 03/01/2001 | |
| 4635 | 08/01/1998 | 615173 | Cold engine knock. *tt | 02/08/2001 | |
| 985185 | 11/01/1998 | 613316 | Cold start engine noise | 01/29/2001 | |
| 5267 | 12/01/1998 | 615388 | Subject regarding misfire codes on all engines. *tt | 01/16/2001 | |
| 4981 | 12/01/1998 | 615321 | Some vehicles equipped with 5.4l engines may exhibit a cold start engine knock concern until warmed up. *tt | 01/13/2001 | |
| 5257 | 12/01/1998 | 615374 | Information on vehicles exhibiting cold engine knock. *tt | 01/13/2001 | |
| 00123 | 06/12/2000 | 613859 | Some vehicles may experience spark knock during light-to-moderate accelerations. *tt | 09/20/2000 | |
| 14039 | 04/01/2000 | 613723 | Information regarding malfunction indicator lamp on -p030x dtc's contact request / detroit area. **mr | 07/27/2000 | |
| 8482 | 04/01/2000 | 613646 | Some vehicles may exhibit diagnostic trouble code(s) p030x (cylinder #1 through #8 misfire detected) that cannot be resolved using proper diagnostics. **mr | 07/26/2000 | |
| 985062 | 11/01/1998 | 613198 | Subject regarding idle vibration (repeat message). *tt | 06/19/2000 | |
| 985059 | 11/01/1998 | 613196 | Experiencing cold engine knock (repeat / revised message). *tt | 06/19/2000 | |
| 12139 | 11/01/1998 | 613160 | Some vehicles equipped with 4.6l or 6.8l engines may exhibit a cold start engine noise until warmed up. *mjs | 06/19/2000 | |
| 996034 | 05/01/1999 | 606947 | Experiencing a engine knock at cold start-up. *tt | 09/08/1999 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
| 14365 | 09/01/2000 | 618636 | This bulletin addresses concerns a noise at intial engine startup when cold from the accessory drive belt. *jb | 04/18/2001 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
| 982010 | 10/12/1998 | 603695 | Experiencing a buzzing or rattling noise from the exhaust system. *yc | 03/02/1999 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
| 981512 | 08/03/1998 | 609551 | A direct replacement part for the evaporative emission canister and bracket assembly. ak | 04/03/2000 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
| 05417 | 03/07/2005 | 10014666 | Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. *tt | 05/05/2005 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | ||||||
| DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
| On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi | ||||||
| ENGINE AND ENGINE COOLING - ENGINE | ||||||
| DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
| On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi | ||||||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | ||||||
| DP05005 | FORD MOTOR COMPANY | 09/22/2005 | 01/04/2006 | SPARK PLUG EJECTION FROM CYLINDER HEAD | ||
| On september 6, 2005, odi received a petition requesting that the agency investigate allegations of engine spark plug ejection in certain model year 1997 through 2004 ford vehicles with triton v-8 and v-10 engines.odi received a total of 474 non-duplicative complaints on the subject vehicles where the complainant, or the dealer repairing the vehicle, reported that a spark plug detached from the cylinder and/or ejected from the engine.as of december 8, 2005, odi is not aware of any allegations where the alleged defect resulted in a loss of vehicle control, a crash, an injury, or a fatality in any of the 10,319,810 subject vehicles.in addition, odi is aware of only two incidents where the vehicle stalled without restart.information contained in the odi consumer complaints and obtained from 72 telephone interviews with complainants showed the following:(1) 99% of the complaints were on my 1997 to 2002 subject vehicles.(2) most the complainants reported hearing a loud pop while driving or upon starting up the vehicle followed by a loud, repetitive clicking or popping sound.(3) many of the complainants reported that the popping sound was accompanied by some loss of vehicle power; however, in 99% of the incidents reported, the vehicle did not stall.in the very few incidents where the vehicle did stall, most vehicles could be restarted.(4) only a small percentage of the complainants cited that they smelled gas or a slight burning smell when the incident occurred.(5) in all but a very few incidents, vehicle damage was limited to the engine.in one incident, the complaint reported that the fuel rail was damaged and replaced after one of the spark plugs ejected from the engine; however, the complainant reported that the damage did not result in any type of fuel leak or fire.in another incident, the only incident where a fire was alleged, the complainant reported that no fluid leak was observed, but that a fire resulted after the spark plug had ejected from the engine and he had restarted the vehicle and driven to another location.none of the complainants reported any damage to the vehicle hood.(6) only two complainants reported that they observed what appeared to be some drops of fuel coming from the cylinder where the spark plug had failed or on the spark plug itself; however, each of these complainants reported that there was no smoke or flames as a result of his incident.as the petitioner noted, and odi | ||||||