Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
99152 | 07/26/1999 | 608431 | Information on the new flush and fill tool available through rotunda. *tt | 01/05/2001 | |
0015 | 01/10/2000 | 612203 | Information regarding the new transmission cooler flusher- service tip. *mjs | 06/06/2000 | |
98167 | 04/07/2000 | 609736 | Transmission-e40d-no 2-3 upshift. some vehicles may exhibit a no 2-3 upshift condition. *ak | 04/07/2000 | |
98168 | 04/07/2000 | 609737 | Transmission- e40d/4r100-1989-99-main controls, separator plates and separator plate gaskets usage chart. yd | 04/07/2000 | |
98123 | 01/19/1998 | 605599 | Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes (dtcs) 62, 628, and / or 1728 may be stored in memory. *tt | 07/13/1999 | |
9888 | 04/27/1998 | 601238 | Information on a new transmission fluid usage chart. *yc | 07/10/1998 | |
97511 | 03/03/1997 | 51945 | Fluid- transmission fluid usage charts. *jd | 07/17/1997 | |
951112 | 06/01/1995 | 45085 | Revised design transmission rear case bushing. *tw | 11/01/1995 | |
95619 | 03/01/1995 | 39913 | New design transmission range sensor. *tw | 11/01/1995 | |
951113 | 06/01/1995 | 45086 | Delayed forward engagement and/or heat stained forward clutch plates after installing center support service. *tw | 11/01/1995 | |
BC4225 | 04/01/1995 | 3055148 | Unknown | 11/01/1995 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||||
002310 | 11/13/2000 | 616522 | Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt | 03/05/2001 | |
0038 | 02/07/2000 | 612343 | Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs | 06/07/2000 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER | |||||
962612 | 12/16/1996 | 50997 | Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw | 06/17/1997 | |
96249 | 11/18/1996 | 50908 | Torque converter - leak test procedure - service tip. *tw | 06/17/1997 | |
POWER TRAIN - AXLE ASSEMBLY | |||||
983074 | 02/27/1998 | 607369 | Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers. *tt | 09/21/1999 | |
12905 | 06/01/1999 | 606937 | Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt | 09/08/1999 | |
BC0131960102 | 12/01/1995 | 46438 | 4x4 front axles must use hypoid 4x4 gear oil p/n f1tz-19580-a & high temp 4x4 front axle & wheel bearing grease when servicing. it is not recommended to use heavier weight lubes in these front axles. | 04/25/1996 | |
POWER TRAIN - CLUTCH ASSEMBLY | |||||
96728 | 03/25/1996 | 613350 | Service tip information regarding the reverse clutch piston and piston seal usage. *tt | 06/22/2000 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
POWER TRAIN | ||||||
PE91064 | FORD MOTOR COMPANY | 04/09/1991 | 07/05/1991 | TRANSMISSION FLUID FIRES | ||
There is no summary currently available |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||
07/07/1999 | |||
When accelerating there is excessive vibration coming from the truck. this is due to a defective plate converter in the transmission. this has been an ongong problem since 1993. please provide any further information. *ak | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - GEAR POSITION INDICATION (PRNDL) | |||
09/05/1994 | |||
Auto-tran: gear shift selector does not show what gear its in; driver have to feel around to determine what gear transmission is in. tt | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER | |||
12/22/1996 | 1 | ||
Torque converter seized at low vehicle mileage. |