Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
BC4225 | 04/01/1995 | 3055148 | Unknown | 11/01/1995 | |
95616 | 03/01/1995 | 39911 | Cooling system - leaking radiator hose - upgraded hose clamps. *tw | 11/01/1995 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
BC2621950503 | 05/01/1995 | 40081 | Low fan speed at idle has been identified as a potential service issue. *tw | 11/01/1995 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
032111 | 10/30/2003 | 9667 | 10004822 | No start/hard start and/or long crank time for vehicles with 7.3l di turbo diesel. *tt | 01/09/2004 |
032131 | 10/30/2003 | 98205 | 10004842 | Rough idle and engine miss due to injector bore scuffing at green engine break-in. *tt | 01/09/2004 |
032123 | 10/30/2003 | 97618 | 10004834 | Low rpm, no start, runs poorly, stall. 7.3l dit engine. *tt | 01/09/2004 |
032117 | 10/30/2003 | 962211 | 10004828 | The air cleaner element may allow dust to bypass due to the air cleaner element collapsing/distorting under severe dust conditions. *tt | 01/09/2004 |
032121 | 10/30/2003 | 97216 | 10004832 | A high number of high pressure rexroth pumps and injection pressure regulators (ipr) are being replaced due to oil leaking, when all that is required is a new gasket or seal on either the pump or ipr. *tt | 01/09/2004 |
03211 | 10/30/2003 | 942315 | 10004812 | Loss of power and malfunction indicator lamp may also illuminate with diagnostic trouble codes 128 and 845 or p0236 and p0238 stored in memory. *tt | 01/08/2004 |
032110 | 10/30/2003 | 96318 | 10004821 | Hard or no start, hesitation, idle rough, low power, misses, stalls. *tt | 01/08/2004 |
03219 | 10/30/2003 | 9618 | 10004820 | Availability of new sealant for servicing 7.3l di turbo engine. *tt | 01/08/2004 |
03217 | 10/30/2003 | 951412 | 10004818 | Rear of engine oil pan, near the crankshaft, may leak oil. *tt | 01/08/2004 |
03214 | 10/30/2003 | 95107 | 10004815 | Poor idle quality and/or low output after the engine returns to idle speed. *tt | 01/08/2004 |
03215 | 10/30/2003 | 95108 | 10004816 | Hard starting after the fuel injectors have been replaced. *tt | 01/08/2004 |
14455 | 11/01/2000 | 616551 | Oil leak from the front or rear cylinder head oil supply rail end plugs. *tt | 03/02/2001 | |
980325 | 04/01/1998 | 603518 | Cold engine upper knock/tick. *yc | 07/18/2000 | |
985058 | 11/01/1998 | 613195 | Subject regarding external oil leaks - repeat message. *tt | 06/19/2000 | |
982740 | 04/01/1998 | 603593 | Concerns with high pressure oil pumps are not serviceable. *yc | 02/25/1999 | |
97618 | 03/17/1997 | 52000 | Low rpm- 7.3l dit engine fails to start- code 340 stored in memory and/or engine fails to achieve rated speed for 2-3 minutes after extended cold soak- f-series built through 2/9/96 and all econolines. *jd | 07/17/1997 | |
97114 | 01/02/1997 | 51369 | Engine compartment noise-buzzing or knocking- right front of engine-after starting. *jd | 06/27/1997 | |
97216 | 01/20/1997 | 51404 | Leak - oil leakat engine valley pan and/or high pressure oil pump - vehicles equipped with 7.3l diesel engine. *tw | 06/27/1997 | |
BC1432995090 | 09/01/1995 | 45788 | Engine moan at approximately 1900 rpm due to the flywheel dampening of engine pulses. *tw | 04/25/1996 | |
BC4225 | 04/01/1995 | 3055148 | Unknown | 11/01/1995 | |
95617 | 03/01/1995 | 39912 | Early wear of fead tensioner pulley on vehicles with 5.0l/5.8l engines. *tw | 11/01/1995 | |
BC4178950401 | 04/01/1995 | 39855 | Engines undergoing a running change to smaller diameter a/c compressor pulley. *tw | 11/01/1995 | |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
BC3130970221 | 02/21/1997 | 51716 | Diesel exhaust smell in passenger cabin may be due to poor connection at the inlet or outlet to/from the turbo. *tw | 06/27/1997 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
01246 | 12/10/2001 | 630515 | Engine oil system priming procedures, service tips for reports of premature engine failure. *tt | 04/18/2002 | |
980307 | 01/01/1998 | 607708 | Vehicle stalls/quits while driving. *ak | 02/06/2001 | |
5254 | 12/01/1998 | 615371 | Information on super duty 7.3 dit diesel engine vehicles exhibiti lack of power. *tt | 01/13/2001 | |
4625 | 08/01/1998 | 615162 | Brief information on vehicles exhibiting a stall on deceleration condition. *tt | 01/02/2001 | |
4629 | 08/01/1998 | 615165 | Brief information concern vehicles exhbiting external oil leaks. *tt | 01/02/2001 | |
4617 | 08/01/1998 | 615155 | Brief information on vehicles exhibiting lack of power condition. *tt | 01/02/2001 | |
4616 | 08/01/1998 | 615154 | Brief information vehicles exhibiting hard start / no start condition. *tt | 01/02/2001 | |
98-4726 | 09/01/1998 | 607139 | Repeat message, no change: hard start/ no start. *ak | 11/02/2000 | |
980312 | 04/01/1998 | 603506 | Excessive white smoke. verify glow plug operation by performing glow plug system operation check on the hard start/no start diagnostic sheet. *tt | 07/14/2000 | |
96727 | 03/25/1996 | 613349 | Experiencing a knocking noise when the engine is cold and under acceleration. *tt | 06/22/2000 | |
5047 | 11/01/1999 | 613141 | Repeat message regarding a hard start / no start condition. *tt | 06/19/2000 | |
985042 | 11/01/1998 | 613086 | Repeat message regarding vehicles exhibiting rough idle / miss condition. *tt | 06/16/2000 | |
5046 | 11/01/1998 | 613103 | Repeat message regarding vehicles exhibiting a lack of power. *tt | 06/16/2000 | |
9811335 | 09/24/1999 | 607505 | Exhibiting a vibration, noise or ground out condition when turning or under load. *tt | 09/24/1999 | |
982313 | 11/23/1998 | 603760 | Some vehicles with a 7.3l direct injection (di) turbo diesel engine, one or more of the following concerns may be present: rough idle, stalling, hesitation/ stumble, loss / lack of power, poor fuel economy, and excessive oil consumption. | 03/04/1999 | |
98205 | 10/12/1998 | 603690 | Exhibiting rough idle and engine miss due to injector bore scuffing at green engine break-in. *yc | 03/02/1999 | |
980323 | 04/01/1998 | 603516 | Concerns with external oil leaks. *yc | 02/23/1999 | |
962212 | 10/21/1996 | 50951 | Engine compartment noise - buzzing or knocking - right front of engine - after starting - 4.9l engines - f series built from 8/1/94 through 10/15/95 - econolines built from 8/15/94 through 10/15/95. *tw | 06/17/1997 | |
951714 | 08/01/1995 | 45971 | Engine- 'knocking' noise - when operating engine at 200-2300 rpm - fd1460 engine | 04/25/1996 | |
95712 | 41013 | During highway deceleration or engine start-up, there may be a hooting noise coming from the engine compartment. *tw | 11/01/1995 | ||
95514 | 03/01/1995 | 39886 | Revised oil fill procedures. *tw | 11/01/1995 | |
95710 | 04/01/1995 | 41011 | Some vehicles may exhibit a poor idle quality and/or low output after the engine returns to the idle speed. *tw | 11/01/1995 | |
BC4225 | 04/01/1995 | 3055148 | Unknown | 11/01/1995 | |
9588 | 04/01/1995 | 41029 | Knocking noise on initial start-up. *tw | 11/01/1995 | |
95107 | 05/01/1995 | 42092 | Vehicles may exhibit a poor idle quality and/or low output after the engine returns to idle speed. *tw | 11/01/1995 | |
9579 | 04/01/1995 | 41010 | Vehicles with 7.3l direct injection diesel engines may experience one or more of the following conditions: rough idle, stalling hesitation/stumble, loss/lack of power, poor fuel economy excessive oil consumption. *tw | 11/01/1995 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
032114 | 10/30/2003 | 961719 | 10004825 | The front end accessory drive (fead) belt may wear, shred and/or come off during deceleration. *tt | 01/09/2004 |
982314 | 11/23/1998 | 603761 | Premature wear of the belt tensioner may occur on some vehicles. *yc | 03/04/1999 | |
9748 | 02/17/1997 | 51691 | Accessory drive belts- fead belt comes off- vehicles with 4.9l engine. *jd | 06/27/1997 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
03213 | 10/30/2003 | 95613 | 10004814 | A no-start or reduced power condition may occur intermittently. *tt | 01/08/2004 |
98-4734 | 09/01/1998 | 607148 | Lack of power due to failure of engine turbo boost | 11/02/2000 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
982010 | 10/12/1998 | 603695 | Experiencing a buzzing or rattling noise from the exhaust system. *yc | 03/02/1999 | |
9864 | 03/30/1998 | 601312 | Information on a buzzing or rattle noise from the exhaust system. *tt | 07/21/1998 | |
951015 | 05/01/1995 | 42099 | Hydromounted cab - evaporative emission lines rubbing on the fender. *tw | 11/01/1995 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
982310 | 11/23/1998 | 603724 | Mass air flow (maf)- sensor contamination- service tip. *ak | 03/03/1999 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||||
98156 | 08/03/1998 | 609536 | Exhaust leak at exhaust manifolds--vehicle equipped with 7.0l 0r 7.5l engine. *ak | 01/29/2001 | |
BC3241970210 | 02/10/1997 | 51863 | Exhaust leaks or noise at the joint between the y-pipe and the exhaust manifold. *tw | 07/17/1997 | |
962213 | 10/21/1996 | 50952 | Exhaust - exhaust leak at exhaust manifolds - vehicles equipped with 7.0l or 7.5l engine. *tw | 06/17/1997 | |
BC0883961004 | 10/04/1996 | 50440 | Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds. *tt | 04/24/1997 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
11/16/2007 | 100000 | 1 | |
Tl*the contact owns a 1995 ford f350. the vehicle caught fire approximately one hour after it was parked on the side of the road. the flames were coming from the hood of the vehicle. the fire department was called to the scene and a report was filed. the vehicle was destroyed. there was no property damage. the vehicle was not insured for full coverage. recently, the contact received a recall notice and he strongly believes that the fire was related to the recall. the current and failure mileages were 100,000. updated 09/13/08. *lj | |||
02/15/2007 | 3 | ||
Failure of the cam position sensor - multiple times. *ak | |||
1 | |||
Vehicle fire. *ak | |||
1 | 11/26/1995 | ||
Temperature gauge inoperative. | |||
1 | 11/26/1995 | ||
Knocking noise from engine. | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM - HOSE | |||
1 | 11/26/1995 | ||
Hose fell off. | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
07/22/1996 | 1 | 02/12/1995 | |
Thermostat failed. | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
06/13/2005 | 1 | ||
1995 ford f350 caught on fire in engine compartment. *ts *jb | |||
04/17/1996 | 1 | 02/12/1995 | |
Idler pulley failed, causing noise. | |||
W/power stroke motor oil cooler assembly resulting in repeated leakage after repaired. please describe details. tt | |||
01/09/1995 | 2 | ||
Loud noise coming from engine unknown source. tt | |||
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||
06/26/2006 | 223828 | 1 | |
On or about 6-26-06 we were getting off highway and make a turn right after. coasted around corner and 1995 f-350 7.3 diesel truck died. was not time to move off the road. truck was toed to shop and was the camshaft sensor. i know recall doesn't cover 1995, but it should, be looked into, as there are plenty older 7.3 on the road. *tr | |||
06/20/2002 | 168000 | 1 | 03/12/1998 |
Ford f-350,power stroke,injector cup failure, resulting in fuel in the cooling system and consumer not know. the results as you know can become catastrophic, fire ,death, ect. i am a mechanic for cat ,have seen first hand, and also have one of these trucks,there isn't any warning,just over-heats the fuel ,inside the cooling system. have contacted ford but was blown off,i've done this kind of work for 20yrswhat do i know. *jb | |||
12/25/1999 | |||
Due to a defective glow plug in the engine compartment caught on fire. please provide further information. *ak | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
1 | |||
While driving the engine stalls intermittently causing loss of power steering and brakes. nlm | |||
02/26/2001 | 1 | ||
While driving the vehicle developed engine problems, the driver noticed smoke under the hood and pulled to the side and the vehicle became engulfed in flames damaging the entire front end, cab, engine compartment, both front tires and front cargo compartment (ohio traffic crash report). nlm | |||
09/12/1999 | 1 | ||
Consumer smelt smoke and discover vehicle was on fire under the hood. the fire casued damage to alternator, serpentine bet and insulation lining of the hood. (ohio traffic crash report) nlm | |||
01/22/1997 | 4 | 09/01/1995 | |
#1 while running 55 mph od indicator light started flashing and transmission shifted out of od and into 1st, shifed back to od after coming to complete stop! parts list: camshaft position sensor #2 while slowing to turn corner od indicator light started flashing and transmission shifted so hard it felt like you just hit somthing parts list camshaft position sensor #3 while running 70 mph od indicator light started flashing and transmission started shifting very hard! parts list kit pump asy-trans oil f ft band asy -trans inter fluid-auto trans gskt-trans ext plate-trans cl ext s plate asy-cl interm plate asy-trans o/dr plate-trans cl ext s gasket gasket converter asy #4 while running 65 mph od indicator light started flashing and engine lost all power, in very heavy fog, forced to stop on very busy hwy! currently in shop do not have parts list yet!! | |||
11/01/1994 | 1 | ||
Engine would not start. *dsh | |||
03/05/1996 | |||
While driving on the highway the truck caught fire,was an engine comparment fire. *ak | |||
02/01/1995 | 6 | ||
Severe loss of engine power. *ak | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||
07/22/1996 | 1 | 02/12/1995 | |
Serpentine belts failed. | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
16 | 01/01/1995 | ||
Exhaust system creates pressure which breaks bolts on exhaust manifold or melts yoke pipe, several failures within the system due to a faulty system. | |||
1 | 11/26/1995 | ||
Severe exhaust leak. | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
12/13/1999 | 1 | 04/20/1995 | |
A leak from the fuel canister, causing fuel leakages on top of firewall and engine. can lead to a possible engine fire. dealer / manufacturer were not contacted at this time. *ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
Exhaust mainfold has warped and is leaking. a tsb has been issued on the vehicle . *ak | |||
11/18/1999 | 10/01/1994 | ||
Following servicing and installation of new exhaust manifold, had a bolt/bracket come loose while towing a horse trailer, bolt/bracket impacted left rear tire, inducing a blow out through the tread. failure to properly install bolt/bracket is the primary cause of this damage. extensive damage from this induced tire failure on under body of truck in front of and behind the left rear truck wheel as well as underbody dents to aluminuim horse trailer. | |||
09/30/1998 | 12/18/1995 | ||
Exhaust manifold yoke pipe failed. | |||
06/06/1996 | 1 | 02/12/1995 | |
Exhaust manifold bolt broke. | |||
1 | 11/26/1995 | ||
Muffler brackets bang against chassis. | |||
03/01/1995 | 3 | 10/01/1995 | |
Exhaust manifold bolts broke 3 times, causing gas vapors to enter vehicle. |