Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - BATTERY | ||||||||||||||||
04V327000 | FORD MOTOR COMPANY | from 12/01/2002 to 03/31/2003 | V (Vehicle) | 83687 | 07/22/2004 | MFR | FORD MOTOR COMPANY | 07/07/2004 | 07/08/2004 | |||||||
Defect Summary | On certain pickup trucks and sport utility vehicles equipped with 6.0l diesel engines, the engine ground stud that attaches the negative battery terminal eyelet to the engine block may be loose. | |||||||||||||||
Consequence Summary | If the ground wire is loose, electrical current may flow to the radio suppression strap causing it to heat and potentially melt or ignite adjacent components which could result in a fire. | |||||||||||||||
Corrective Summary | Dealers will replace the engine ground stud and the radio suppression strap and adjacent components will be inspected for damage and replaced, if necessary. the recall began on july 23, 2004. owners should contact ford at 1-800-392-3673. | |||||||||||||||
Notes | Ford recall no. 04s15.customers may also contact the national highway traffic safety administration auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM | |||||
17956 | 08/01/2004 | 10011174 | Dtc u1262 (scp communication bus fault) stored in the instrument cluster (ic). *tt | 01/07/2005 | |
0471 | 12/31/2004 | 04262 | 10008201 | Warning indicators-parking aid-reverse sensing system (rss) and forward sensing system (fss)-false activation of warning tone-service tips. *mj update. *tt | 07/23/2004 |
17553 | 02/01/2004 | 10008118 | Low charging system voltage while snow plowing. *mj | 07/22/2004 | |
17535 | 02/01/2004 | 10008107 | Lack of power and/or diagnostic trouble code (dtc) p0103 - air induction system water/snow deflector kit. *mj | 07/22/2004 | |
17613 | 03/01/2004 | 10007399 | Driveability concerns and set diagnostic trouble codes (dtc's) p2614 (camshaft position output circuit open) and p2617 (crankshaft position output circuit open). *tt | 06/17/2004 | |
17508 | 01/01/2004 | 10007341 | False diagnostic trouble codes (dtc's set during use of active commands with wds. *tt | 06/14/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
04/16/2004 | 1 | ||
While driving 30 mph vehicle stalled without warning. this caused loss of steering and brakes. dealer replaced computer and a couple of sensors, however, problem still recurred. *ak | |||
05/24/2003 | 1 | 11/14/2002 | |
Vehicle fire from underneath dashboard.*mr prior to the vehicle fire, the six disc cd changer was replaced due to electrical failure. the damage was sustained through no fault of the owner, while under warranty, due to an electrical/mechanical failure, which is why the owner would like ford to replace the vehicle. ford did agree but the process had taken an extraordinarily long time and continued to move at a unacceptably slow pace. the consumer has incurred major travel expenses as a result of ford not supplying a rental vehicle compatible to the ford f350. *ph *jb | |||
ELECTRICAL SYSTEM - IGNITION | |||
07/22/2003 | 14000 | 1 | 01/04/2003 |
Engine just stopped running. coasted to side of rode, turned ignition off then back on and the truck started.*ak | |||
ELECTRICAL SYSTEM - WIRING | |||
12/25/2004 | 43000 | 1 | |
While vehicle was parked a fire started in the engine compartment. the fire was put out. dealership was notified, but did not resolve the problem. *ak | |||
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
05/06/2003 | 3500 | 01/01/2003 | |
Vehicle fire-2003 ford 350 van-fire occurred as a result of an electrical malfunction in engine per fire analysis-vin 1ftss34lxha27785. *ak | |||
04/07/2003 | 16000 | 1 | |
The vehicle was shooting out flames from the driver side wheel well area. *nlm....*ak | |||
ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
04/01/2004 | 13000 | 1 | 11/06/2003 |
Dt: when the consumer went to start the vehicle it wouldn't start. the vehicle sat for over 12 hours. it had just come out of the shop and it had a down strap installed. the fire started in the right hand side of the dashboard. all the contents of the truck were destroyed. both the police and fire dep artment responded to the fire. *ak |