Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||||
13990 | 03/01/2000 | 612903 | Some vehicles equipped with rear anti-lock brakes may exhibit diagnostic trouble codes c1113 / c1115 / c1185. *tt | 06/13/2000 | |
8376 | 03/01/2000 | 612774 | Some vehicles equipped with rear anti-lock brakes may exhibit diagnostic trouble codes c1113 / c1115 / c1185. *tt | 06/12/2000 | |
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||||
13105 | 08/01/1999 | 6091909 | Information on brake noise. *tt | 11/16/2000 | |
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||||
15661 | 02/01/2002 | 630725 | Concerns with rattle noises coming from front brake calipers. *tt | 04/23/2002 | |
15328 | 10/01/2001 | 630239 | Concerns with rattle noise originating from the front brake calipers. *tt | 04/15/2002 | |
15579 | 01/01/2002 | 630130 | Some vehicles may exhibit caliper pin rattle noise originating from the front brake calipers. *tt | 04/15/2002 | |
15525 | 01/01/2002 | 630053 | Information regarding a rattle noise originating from the front brake caliper.*yd | 04/12/2002 | |
14277 | 01/01/2000 | 620409 | Some vehicles may exhibit a rattle noise from the front calipers. *tt | 08/07/2001 | |
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - PADS | |||||
14356 | 01/01/2000 | 620423 | Some super duty f series vehicles may exhibit a brake squeal / squeak from the rear brakes. *tt | 08/07/2001 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SERVICE BRAKES, HYDRAULIC | |||
05/27/2011 | 174000 | ||
2000 ford f350 crew cab 4x4 brake line was coroded from different metals used. had hole in line and brake pedal went to the floor causing me to have no brakes. extremely dangerous!!! | |||
09/10/2009 | 119000 | ||
Brake line failure on main line from master cylinder to rear axle. released fluid on ground and in air, basically no brakes when this happened' line was corroded right where stainless line changes to metal some sort of dissimilar metal corrosion going on many cases on line about these trucks and brake lines. | |||
12/12/2009 | 51340 | 1 | |
Loss of power steering and power braking making driving very difficult and extremely dangerous. *tr | |||
SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
02/15/2000 | 4 | ||
Brake system malfunctioned, and consumer lost all power when braking. vehicle has been at the dealer 4 times & they have found no remedy. also, when starting the vehicle, the steering wheel is difficult to turn. after the brakes were repaired, steering became more difficult. *ak *ml | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
03/08/2004 | 76507 | 2 | 11/27/2001 |
The front brakes on my f350 4x4 failed while driving interstate 77.*ak | |||
01/24/2000 | 2 | ||
Consumers experienced problems concerning loss of braking ability, steering, and throttle sticking which caused 2 accidents. nlm | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||
10/01/2001 | 2 | 10/01/2001 | |
The front wheel rotors warped and had to be re-surfaced at 22,000 miles. the dealer turned the rotors and installed new front brake pads. at 32,000 miles the front rotors were warped again. wheel vibration could be felt in the brake pedal and front end on hard braking while going down steep hills. the dealer said that the warping was caused by excessive heat. at 32,000 and 38,000 miles they said that brakes are not covered under warranty and they would not correct the problem. the recommened having the rotors turned and installing composite/metallic brake pads. they stated that the factory brake pads are too hard for the rotors. the brake pads have shown little wear. there is an exhaust brake on the vehicle and the brakes have been used sparingly. i feel that there is an engineering problem with the front brake system. dt | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||
09/02/2004 | 77000 | 1 | 12/22/2000 |
Right front caliper won't release. apparently common problem with 4x4 per mechanic. gouged out rotor and almost caused accident. *jb | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | |||
08/28/2007 | 101277 | 1 | 04/15/2002 |
#1 just using vehicle. #2 brakes became spongy. after stopping vehicle i noticed brake fluid running on ground in front of driver side rear wheel coming from frame rail. it appears brake line is corroded. vehicle has 100 thousand miles on it, and under carriage is rinsed as needed. a written request has been sent to klaben ford (kent ohio) request all broken parts. *tr updated 01/11/08. *lj updated | |||
06/16/2006 | 74585 | 1 | 12/20/2005 |
Driving at rate of 40 mph when i had to suddenly stop from hitting animal on the road. brake pedal went to floor when pedal was suddenly pressed. brake line was busted on drivers side underneath the clip holding brake line. vehicle has not been repaired as of yet. *jb | |||
09/19/2005 | 67200 | 1 | 05/20/2000 |
I experienced a complete brake line failure and loss of brake use on my 2000 ford f350 super duty 4x4 pickup. luckily, the failure occurred while my vehicle was being inspected by the state of new jersey. i had to have it towed to the nearest ford dealership where they proceeded to bill me extensively for replacing the main brake line. *jb | |||
SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC | |||
07/31/2007 | 106000 | 1 | 06/10/2000 |
Inlet for turbo was mis positioned and ate thru power steering pump and hose, causing sudden loss of steering control and brakes. *tr | |||
SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC - HOSES, LINES/PIPING, AND FITTINGS | |||
08/28/2007 | 101277 | 1 | 04/15/2002 |
#1 just using vehicle. #2 brakes became spongy. after stopping vehicle i noticed brake fluid running on ground in front of driver side rear wheel coming from frame rail. it appears brake line is corroded. vehicle has 100 thousand miles on it, and under carriage is rinsed as needed. a written request has been sent to klaben ford (kent ohio) request all broken parts. *tr updated 01/11/08. *lj updated |