Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN | |||||
04227 | 10/07/2005 | 05176 | 10013402 | Drive away shudder or vibration. *eh | 04/18/2005 |
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
15109 | 08/01/2001 | 624626 | A cold weather reverse engagement stall. *yd | 11/08/2001 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
042107 | 12/13/2004 | 042414 | 10014086 | General (pcm) power train control module programming procedures. *tt | 04/28/2005 |
POWER TRAIN - AXLE HUBS | |||||
04185 | 01/01/2004 | 10013110 | Front hubs not engaging, not staying engaged and/or unlocking. *tt | 04/07/2005 | |
POWER TRAIN - MANUAL TRANSMISSION | |||||
17822 | 05/01/2004 | 10008571 | Manual transmission fluid leak. *tt | 08/05/2004 | |
15798 | 04/01/2002 | 637517 | Some vehicles equipped with a 7.3l di, 4r100 transmission and built before december 10, 2001 may remain in 2nd gear with the gear shift lever in the first gear position. *tt | 12/02/2002 | |
15607 | 02/01/2002 | 630644 | Concerns with tr4050 manual transmission exhibiting a no engagement from 1st to 2nd gear. *tt | 04/19/2002 | |
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
17829 | 05/01/2004 | 10008574 | Transfer case shift issues on vehicles with an electronic shift on the fly (esof) transfer case. *tt | 08/05/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||
12/10/2007 | 58347 | 3 | 06/11/2003 |
Tl*the contact owns a 2002 ford f350 super duty. the vehicle was taken to the dealer to have a safety recall repaired. at that time, the contact was informed that the vehicle needed to have an oil change. also, the oil pan needed to be changed because it was rusting and pitting. the cost to replace the oil pan on her diesel engine is $2,399.82. the contact stated that the rear universal had to be replaced at 27,770 miles and then had to be replaced a second time, in addition to the carrier bearings at 47,325 miles. the vehicle was under warranty the first time, but the contact paid for the repair the second time. the recall number was unknown. the current and failure mileages were 58,347. updated 02-04-08. *kb the consumer stated replaced weatherstrip, replaced rear u joint, disc pads replace, and replaced broken console lid. updated 02/04/08 *tr | |||
04/04/2004 | 8 | 02/01/2002 | |
I have a 2002 f350 super duty diesel truck. several times (6-8 times) this vehicle has spontaneously moved from park to reverse. so far no injuries or damage to vehicle has occurred as a result of this failure. a co-worker of mine has reported the same problem with his 2004 ford f250 superduty diesel truck.*ak | |||
POWER TRAIN - AXLE HUBS | |||
12/27/2003 | 1 | 500 | 01/07/2002 |
2002 ford super duty powerstroke diesels with 4 wheel drive. the 4 wheel drive system on these trucks is called, electonic shift on the fly ... there is a dash mounted knob on the dash. the nob has written, 4x2-4x4 and 4x4 lo. this past snow storm in northern nevada had chains or snow tire restrictions. so, on my way to work i turned the dash knob from 4x2 to 4x4. the 4x4 system light on the dash lit up and the truck went into 4 wheel drive. shortly after driving and proceeding from a stop sign the rear tires started to spin, nothing from the front tires!! the dash light still showed 4x4 mode.. i pulled to the side of the road and turned the knob from 4x4 to 4x2 and then back to 4x4. again the 4 wheel drive system worked.. upon climbing up a slight hill the rear tires started sliding causing the back of the truck to fishtail. again, without warning the truck left it's 4 wheel drive mode and went back into 2 wheel drive..this is extremly dangerous!!!!the truck unlike a 4x4 system that just does not work or quits working, tells the driver it is in 4x4, but without warning, goes back into 4x2 mode. this defect can cause property damage, an accident or even death!!! please look into this matter!!! all owners of this setup, which involves model years 1999, to 2004 should be advised by ford and to repair permantly the flaw..if you need further information, please check www.the diesel stop.com.. this is an internet web site dedicated to the owners of ford diesel pickup trucks..many owners of the 99 to 04s with 4x4s are having problems with this system..we are looking foward to your assistance.. thanks.. dan bolduc. *ak | |||
POWER TRAIN - CLUTCH ASSEMBLY | |||
06/01/2003 | 40441 | 6 | 10/03/2001 |
When coming to a stop or shifting the clutch will not disengage, and the pedal stays on the floor -- multiple incidents. *ak | |||
05/20/2003 | 37525 | 2 | 10/03/2001 |
When coming to a stop or shifting the clutch will not disengage, and pedal stays on the floor. *ak | |||
POWER TRAIN - CLUTCH ASSEMBLY - PEDAL/LINKAGE | |||
06/01/2003 | 40441 | 6 | 10/03/2001 |
When coming to a stop or shifting the clutch will not disengage, and the pedal stays on the floor -- multiple incidents. *ak |