Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN | |||||
| 042516 | 12/27/2004 | 10014269 | Malfunction indicator lamp (mil) illuminated with diagnostic trouble code (dtc) p0756, p0761 or p0771 after overhaul or installation of 2005 torqshift transmission. *tt | 04/29/2005 | |
| 04227 | 10/07/2005 | 05176 | 10013402 | Drive away shudder or vibration. *eh | 04/18/2005 |
| 17917 | 07/01/2004 | 10009334 | Low/oscillating line pressure or low/no pto torque due to incomplete pto wiring installation. *tt | 09/23/2004 | |
| 17727 | 04/01/2004 | 10008228 | Clunk or pop on initial engagement from reverse to drive at approximately 2-3 mph. various modles including 2004 econoline. *tt | 07/23/2004 | |
| 17537 | 02/01/2004 | 10008109 | Harsh engagement or shift issues with pulsating cooler lines and erratic line pressure. *mj | 07/22/2004 | |
| 17643 | 03/01/2004 | 10007414 | Harsh/slipping engagements, upshifts and/or downshifts on vehicles with torqshift - adaptive shift strategy. *tt | 06/22/2004 | |
| 17618 | 03/01/2004 | 10007400 | Transmission gear ratio error - diagnostic trouble code (dtc) p0730 on vehicles with torqshift transmission. *tt | 06/17/2004 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 18822 | 09/01/2005 | 10018070 | Torqshift transmission - intermittent clunk when shifting from reverse gear or drive gear to park. multiple vehicles. ford oasis. to include 2006 ford f-53. *tt | 12/14/2005 | |
| 18376 | 01/01/2005 | 10013316 | A cold weather reverse engagement stall. *tt | 04/14/2005 | |
| 17351 | 11/01/2003 | 10008179 | Harsh disengagement when shifting from reverse to park. *tt | 07/22/2004 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
| 19090 | 10019808 | Exhaust pressure sensor input no longer used if pcm is reprogrammed - service tip. *tt | 04/28/2006 | ||
| 042107 | 12/13/2004 | 042414 | 10014086 | General (pcm) power train control module programming procedures. *tt | 04/28/2005 |
| 17437 | 12/01/2003 | 10008298 | White/gray smoke and various driveability concerns after cold start - torqshift harsh downshift and buck/jerk. *tt | 07/27/2004 | |
| 03E03 | 12/01/2003 | 10008282 | Emissions recall 03e03 - powertrain control module and fuel injector control module re-calibration. *tt | 07/26/2004 | |
| 17567 | 02/01/2004 | 10008130 | Pcm (powertrain control module)/ficm/tcm reprogramming errors. *tt | 07/22/2004 | |
| POWER TRAIN - AXLE ASSEMBLY | |||||
| 17486 | 01/01/2004 | 10007329 | Rear axle pinion seal leak. *tt | 06/10/2004 | |
| POWER TRAIN - AXLE HUBS | |||||
| 04185 | 01/01/2004 | 10013110 | Front hubs not engaging, not staying engaged and/or unlocking. *tt | 04/07/2005 | |
| POWER TRAIN - MANUAL TRANSMISSION | |||||
| 17822 | 05/01/2004 | 10008571 | Manual transmission fluid leak. *tt | 08/05/2004 | |
| POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
| 17829 | 05/01/2004 | 10008574 | Transfer case shift issues on vehicles with an electronic shift on the fly (esof) transfer case. *tt | 08/05/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 05/30/2009 | 46000 | ||
| Tl*the contact owns a 2003 ford f550 super duty. while idling, the vehicle shakes and lunges forward without warning. the vehicle almost lunged into traffic while at idling at a stop light on one occasion. a component was replaced by the previous owner, but the failure still persists. the contact feels that a crash could occur. the current mileage was 47,000 and failure mileage was 46,000. | |||
| POWER TRAIN - AXLE ASSEMBLY | |||
| 07/06/2006 | 22143 | 8 | 12/01/2003 |
| Complaint: the front axle traverse rod mounting plate that is welded to the front axle on the passenger side is cracking and has in some cases completely broken off. cause: unknown correction: replace entire front axle. re-use all hubs and parts. *jb | |||