Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| LATCHES/LOCKS/LINKAGES - DOORS - LATCH | ||||||||||||||||
| 06V383000 | FORD MOTOR COMPANY | from 02/16/2004 to 06/20/2005 | V (Vehicle) | 139537 | 11/08/2006 | MFR | FORD MOTOR COMPANY | 10/05/2006 | 10/05/2006 | |||||||
| Defect Summary | On certain passenger vehicles currently registered in the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, new hampshire, new jersey, new york, north dakota, ohio, pennsylvania, rhode island, south dakota, utah, vermont, west virginia, wisconsin, and wyoming. the side door latch mechanisms may experience water intrusion allowing the latch mechanism to freeze in cold weather. | |||||||||||||||
| Consequence Summary | As a result, the door latch pawl may not return to the latch position when the door is closed, and the door could open while the vehicle is moving. | |||||||||||||||
| Corrective Summary | Dealers will install a shield over the front latches; seal a drain hole in the rear window trim molding on the freestyle rear side doors; and apply grease to all front and rear side-door latch mechanisms free of charge. the recall began on november 8, 2006. owners may contact ford at 1-800-392-3673. | |||||||||||||||
| Notes | Ford recall no. 06s45.customers can also contact the national highway traffic safety administration | |||||||||||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| LATCHES/LOCKS/LINKAGES | |||
| 12/28/2007 | |||
| This is the promblem that i am having #06v383000 with my 2005 ford five hundred i took it to a dealer and was told that since it was not a ford recall that they could not fix the promble. it seems to happen when it get extremely cold out. some times i have to drive to work holding the door until the latch catches. any and all help will be greatly appreciated. thank you | |||
| 01/03/2011 | |||
| I have a 2005 ford five hundred and the doors will not latch in cold weather and open while vehicle is moving; we contacted ford and they said they had that recall but not in my state, said it wasn't cold enough in our area; well , it is and it happens every winter with this car. ford should fix this as it is a major safety concern for my family. | |||
| 06/16/2007 | 84000 | 2 | |
| I purchased a 2005 ford 500 ltd. the first incident occurred while driving home from atlantic city. the dashboard lit up like i was starting the car and went into failsafe engine mode. after pulling over, the car ran normal. the next occurrence was when the car started shutting off while driving. it has done this on numerous occastions. then the dashboard lit up again and the reverse lights stayed on. this winter season the door latches would not catch to keep the doors shut. after it rains the rear doors have water sitting inside of them. upon doing some research, i found that these problems were on ford's technical service bulliten (tsb). i called ford and they said there were no recalls according to the vehicle identification number. they also stated that there was work done prior to me purchasing the vehicle. i also had the car worked on for the electrical problem and was told the car was fixed. the car is still experiencing these problems. i don't have the finances to continue to have work done and the problems not be fixed. *tr | |||
| 11/22/2005 | 3000 | ||
| Tl*the contact owns a 2005 ford five hundred. the contact stated that the driver's side door failed to close securely. there was a malfunction with the latch system. the interior door handle had to be held in order to secure the door while the vehicle was in motion. the failure occurred without warning. the vehicle was taken to an authorized dealer, but they could not determine the cause of the failure. the vehicle was taken to the dealer four additional times. the contact stated that the vehicle was previously repaired under a recall; however, the nhtsa campaign id number was unable to be found. the recall remedy has not corrected the failure. the vin was unknown. the failure mileage was 3,000 and current mileage was 3,753. | |||
| LATCHES/LOCKS/LINKAGES - DOORS - LATCH | |||
| 02/28/2008 | 3 | 06/23/2007 | |
| I purchased my first ford product in the spring of 2007. in december the driver side door would not close. there was a tsb dated 06-25-04 for which service was claimed to have been performed. on february 11, 2008 again the driver door would not latch. i had to drive it up to family ford in waterbury, holding the door closed. all they did on that day was spray some sort of lubricant in the door latch. today, february 28th at 5:30 am while taking a right turn on my way into work, the door flew open. it had not latched. i had to slam the door five times to get it to latch closed. this is now the third incident with this door. i feel this now falls into the lemon law category. family ford just wants to spray lubricant and try to blame damp weather. i have always owned gm vehicles and never have i had this type of problem. this is a safety issue. *tr | |||
| 01/29/2008 | 44444 | 1 | 09/28/2005 |
| Purchased my 500 9/05 it only had 5 miles on it. 6 months later loud explosion in engine which began to leak some sort of fluid got the car towed to dealer purchased was told a/c leaking oil and they had to replace the manifold i wasn't even using the a/c was march!!! my dash console had to be replaced since it was defective and the computer also had to be reprogrammed since the car wouldn't start in 30 degree weather this happened in jan06......my fuel straps were replaced due to recall and my door locks were replaced due to recall and i had 22k miles when the back brakes began making a terrible grinding noise when backing up took to dealer said that although car is under warranty brakes are under wear and tear and would not be covered now which didn't make any sense since the front brakes were good how could back brakes go bad before front brakes unless you only drive your car in reverse????? i paid the $400 to fix since was informed 500 rotors cant be turned ever will always have to purchase new ones......then 6 months later brakes were recalled and i did request refund which i did receive. however i now have 44k no longer have warranty since expired and i didn't buy extended warranty brought car in to ford since transmission light was turning on and off along with the traction control light then had trans censor replaced was told that was problem then 2 days later light still turning on and car will not reverse took into dealer again was told trans axle broke in half and need new trans which costs $5300 car is only work 9k!!!! ford company said they will offer assistance only of 3k since out of warranty they also informed me that had i purchased the extended warranty i would only be paying $100 nothing like throwing that in your face. i have no choice but to pay it need a car and am a single parent of 2. also back doors trim is coming apart passenger since is completely rotted out. *tr | |||
| 05/10/2007 | 38585 | 1 | 05/06/2005 |
| Tl*the contact owns a 2005 ford five hundred. on march 26, 2007, the contact had the rear brakes on his vehicle checked and was told by the mechanic that the brakes were in good condition. on may 10, 2007, the brakes began to fail. while driving 35 mph under normal conditions, the contact heard the rear brakes grinding metal to metal. the contact took the vehicle to the dealer who replaced the rear rotors and brake pads. the contact has the rear rotors to show the unusual wear. the contact also has the repair orders from both repairs. the engine size was unknown. the current and failure mileages were 38,585. the dealer stated that the recall for this car was performed on the latch of the door for this vehicle. updated 06/06/07 *tr | |||
| 04/10/2007 | 20024 | 2 | 02/06/2006 |
| Tl* - the contact owns a 2005 ford five hundred with a current mileage of 29,345 miles. after driving the vehicle for 191 miles the contact heard a thumping noise coming from the rear brakes. she took the vehicle to the dealer, and was told that there was corrosion between the brake pads and rotors. both rear brakes were replaced. the contact drove the vehicle for another 9,319 miles. when the contact took the vehicle to the dealer for routine maintenance she was told that the rear brakes were 90% corroded. the contact replaced the brakes. the contact called ford, and was told not to use the brakes as frequently. *ak the consumer states door latch freezes at times, dealer performed recall on vehicle. update 05/04/07*tr | |||
| 02/27/2007 | 32000 | 1 | 05/08/2005 |
| Ford recall no. 06s45 did not fix the problem. our ford five hundred drivers door failed to latch the day after a trip through the car wash in below freezing weather. my wife tried to latch the door many times and locked and unlocked it several times. it finally latched. the local dealer looked at it and lubed it (again). the technician stated that this was not the first one he had seen. *jb | |||
| 01/02/2007 | 18600 | 6 | 05/17/2005 |
| Received a recall notice from ford moco. took the wifes vehicle into the dealership for repairs, the technician called and said the car was repaired and we took the vehicle home. i took the vehicle to work that evening and when i got off work my freind and i that rides to work with me noticed thast the door still wasn't shutting properly. i slammed the door 3 or4 times and thought it had latched as the dome light went out. i dropped my freind off at his home and was heading to a nearby convenience store when the door popped open. i was startled and was trying to close the door, while i was distracted with the door i went off the road and struck a power pole and chain link fence. i refused an ambulance ride to the hospital but had to go later with nech pain. | |||
| 12/01/2006 | 720 | 6 | 03/28/2005 |
| I have a recall of nov 2006 on my 2005 ford 500 for the doors flying open after freezing vin 1fafp231x5g137411 and robin of ford corporate headquarters states ford will not pick this car up (as it has defective brakes as previously noted to you and has an affidavit of non use filed). ford is refusing to perform work on the recall. *jb | |||
| 12/21/2005 | 6947 | 1 | 01/01/2005 |
| Consumer 2005 ford 500 door came open while driving. *ts water leaked into the vehicle from the doors. the dealer replaced both front door latches and new water canels. the dash had a bubble in the leather and the dealer replaced it. the molding was coming off the vehicle. the vehicle would not start on one occasion. *nm | |||