Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN | |||||
021001 | 05/01/2002 | 637863 | Some all wheel drive vehicles may exhibit a growl noise at speeds of 65-112 km/h (40-70 mph). *tt | 12/06/2002 | |
020802 | 04/01/2002 | 637610 | Some vehicles built prior to 9/15/2001 may exhibit low line pressure readings, no 2nd, 3rd gear, no engine braking in manual 1st, and / or slipping shifts and / or delayed engagements. *tt | 12/03/2002 | |
020508 | 03/01/2002 | 636424 | Inoperative or inaccurate speedometer, 4x4 lamp illuminated, and / or diagnostic trouble code p1635 or p1639 present after powertrain control module (pcm) or instrument cluster replacement. 1999-2002 various ford vehicles. *tt | 11/08/2002 | |
021308 | 07/01/2002 | 636293 | Concerns with slipping shifts and / or delayed engagements with possible diagnostic trouble codes p0732, p0733, p1762 set. *tt | 11/07/2002 | |
012203 | 11/01/2001 | 630477 | Some vehicles built prior to 11/11/2001 equipped with 5r55w and 4.6l engines, may exhibit a buzzing noise from the transmission when the torque converter is engaged. *tt | 04/17/2002 | |
012107 | 10/01/2001 | 630304 | Concerns with moaning/droaning during light acceleration with transmission in 5th gear at highway speeds. *tt | 04/16/2002 | |
012007 | 10/01/2001 | 630290 | Vehicles produced prior to 9/6/2001 with 5r55w transmission may exhibit a tick noise from the transmission front or intermediate servo cover area. *tt | 04/16/2002 | |
020103 | 01/01/2002 | 630157 | Some all wheel drive vehicles may exhibit a growl noise at speeds of 65-112 km/h (40-70 mph). *tt | 04/15/2002 | |
15577 | 01/01/2002 | 630124 | Some control trac eqiupped vehicles in 4 auto mode may exhibit a shudder on acceleration and/or noise from the front driveline and transfer case while driving. *tt | 04/15/2002 | |
020201 | 01/01/2002 | 630167 | Some vehicles equipped with the 6.8l-2v engine, 4r100 transmission and pto option may exhibit a low power condition while in reverse gear. *tt | 04/15/2002 | |
011804 | 09/01/2001 | 625827 | Subject regarding speedometers dropping to zero mph while driving. *jg | 12/03/2001 | |
011507 | 07/01/2001 | 621126 | Information regarding transmission fluid usage charts. *tt | 09/07/2001 | |
13153 | 08/01/1999 | 6091964 | Subject regarding inaccurate odometer / speedometer readings. *tt | 11/17/2000 | |
001402 | 06/01/2000 | 613915 | Inoperative or inaccurate speedometer, 4x4 lamp illuminated, and / or diagnostic trouble codes p1635 or p1639 present after a powertrain control module (pcm) or instrument cluster replacement. *tt | 09/21/2000 | |
BC1016097020 | 01/02/1997 | 51227 | Intermittent surging, bucking or shudder concern, intermediate erratic speedometer and/or possibly dtc 452/p0500/p0503/p1501/p1503. *jd | 06/27/1997 | |
BC8949950601 | 06/01/1995 | 42066 | Unknown | 11/01/1995 | |
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
12-3-15 | 03/27/2012 | 10044125 | Ford: some 2009- 2011 e-series, f-super duty-f-53 motorhome and f-59 stripped chassis vehicles equipped with a torqshift transmission may exhibit mil with dtcs p0751, p0730 and/or p2700. *js | 05/14/2012 | |
020803 | 04/01/2002 | 637611 | Some vehicles equipped with a 2.3l, 3.0l or 4.0l engine and 5r44e or 5r55e automatic transmission, may exhibit a fluid leak at the transmission servo covers. *tt | 12/03/2002 | |
020606 | 03/01/2002 | 636431 | Some vehicles equipped with 5r55n automatic transmission may exhibit a fluid leak around the fluid pan drain plug. *tt | 11/08/2002 | |
020602 | 03/01/2002 | 636426 | Concerns with harsh upshifts during light to medium throttle on vehicles produced through 2/15/2002 equipped with 5r55w transmissions. *tt | 11/08/2002 | |
012003 | 10/01/2001 | 630283 | Some vehicles built through 9/21/2001 may exhibit harsh upshift at light to medium throttle. *tt | 04/16/2002 | |
011308 | 07/01/2001 | 621130 | Some vehicles equipped with a 3.0l engine and 5r44e automatic transmission produced 8/8/2000 through 6/18/2001 may exhibit a delayed reverse engagement. *tt | 09/07/2001 | |
011307 | 07/01/2001 | 621129 | Some vehicles equipped with a 4r70w automatic transmission may exhibit a clunk noise during the 2-1 downshift event. *tt | 09/07/2001 | |
010901 | 05/01/2001 | 620243 | Some 4x2 models equipped with 4r70w auotmatic transmission and 139 inch wheelbase only may exhibit a high speed driveline vibration that may cause possible transmission and / or driveshaft damage. *tt | 07/23/2001 | |
010508 | 03/01/2001 | 619499 | Some vehicles equipped with the 4r70w automatic transmission may exhibit a ticking or clicking type noise in first gear. *tt | 06/01/2001 | |
14720 | 03/01/2001 | 619453 | Information on pre-delivery transmission fluid level checks. *tt | 05/31/2001 | |
13506 | 11/01/1999 | 614631 | Some control trac equipped vehicles in 4 auto mode may exhibit a shudder on acceleration and / or noise from the front driveline and transfer case while driving. some 4x4 and all wheel drive vehicles may exhibit axle windup or binding wh | 11/29/2000 | |
99-4716 | 09/01/1998 | 607126 | No charge plant transmission assembly core return policy.*ak | 11/02/2000 | |
985145 | 11/01/1998 | 613281 | This bulletin states that the 1999 scheduled maintenance guide for any light truck, sport utility or van equipped with a 4r100 transmission, normal maintenance schedule, is not correct. *tt | 06/20/2000 | |
976007 | 07/01/1997 | 605792 | Information on testing transmission range (tr) sensor. *tt | 06/13/2000 | |
7351 | 11/01/1999 | 610784 | Information regarding ford quality remanufactured (fqr) transmissions with inline filter. *tt | 05/15/2000 | |
BC1016197020 | 01/02/1997 | 51229 | Beginning december 2, 1996, all cd4e transaxles are built with a redesigned pump body separator plate and pump body separator plate gasket. *jd | 06/27/1997 | |
BC8986950705 | 07/01/1995 | 45063 | Slave cylinders/throwout bearings now available in lieu of transmission assembly. *tw | 11/01/1995 | |
BC4221950401 | 04/01/1995 | 39830 | Delayed upshift into overdrive. *tw | 11/01/1995 | |
BC4227950401 | 04/01/1995 | 39866 | Some service parts have been found without the resdiual check ball installed. transmissions without the check ball will experience a no forward engagement condition. *tw | 11/01/1995 | |
BC8901950401 | 04/01/1995 | 3010000 | Unknown | 11/01/1995 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
01107 | 06/01/2001 | 622850 | Some vehicles equipped with a 4r70w automatic transmission exhibiting a no forward or a delayed engagement may have a damaged forward clutch. *tt | 10/23/2001 | |
011405 | 07/01/2001 | 621138 | Concerns with vehicles built prior to 10/17/2000 with the 5r55n transmission may exhibit delayed reverse or drive engagements, harsh upshifts or downshifts, erratic upshifts, or delayed downshifts near 32 km/h (20 mph). *tt | 09/07/2001 | |
011003 | 05/01/2001 | 620252 | Some vehicles equipped with a 3.0l engine and 5r44e transmission may exhibit a flashing transmission control indicator lamp (tcil) and / or a delayed 1-3 shift with diagnostic trouble code (dtc) p0733. *tt | 07/23/2001 | |
011101 | 05/01/2001 | 620261 | Some vehicles equipped with a 4.0l engine and 5r55w automatic transmission built 11/13/2000 through 5/21/2001 may exhibit light throttle soft or long 2-3 upshifts between 16-40 km/h (10-25 mph) or harsh 3-4 upshifts between 32-56 km/h (20-3 | 07/23/2001 | |
010801 | 04/01/2001 | 619345 | Some vehicles equipped with a 3.0l vulcan engine built prior to 3/1/2001 may exhibit a perceived high idle when shifting from park / neutral to drive / reverse on a cold start, high creep speed in drive or reverse when cold, rough and harsh | 05/23/2001 | |
010203 | 01/01/2001 | 618031 | Some vehicles equipped with a 4.0l engine and automatic transmission built prior to 11/27/2000 may exhibit a cold start neutral idle dip. *jb | 04/03/2001 | |
010105 | 01/01/2001 | 618017 | Subject regarding delayed reverse or drive engagements harsh uplifts or downshifts. *jb | 04/03/2001 | |
010204 | 01/01/2001 | 618032 | Subject rearding slightly extended 1-2 / 3-4 upshifts during cold start-up conditions. *jb | 04/03/2001 | |
002501 | 12/01/2000 | 617130 | Concerns with engine rpm rise during light throttle 3-4 shifts, flashing transmission control indicator light (tcil) - diagnostic trouble code (dtc) p0782 stored in memory. *tt | 03/14/2001 | |
4713 | 08/01/1998 | 615252 | Information on all eec-v equipped cars now having the pcm programmed out of the vehicle using the rotunda 15 to 104 flash cable. *tt | 01/10/2001 | |
12991 | 07/01/1999 | 614777 | Some obdii vehicles may exhibit a key on engine off (koeo) self test diagnostic trouble code (dtc) of p0605 (pcm rom test error). *tt | 12/14/2000 | |
12136 | 11/01/1998 | 613158 | All 1996-1999 vehicles except (aspire, probe and villagers) with eec-v that require powertrin control module (pcm) replacement. *mjs | 06/19/2000 | |
8252 | 03/01/2000 | 612687 | Information on accessing the ngs / pcm program. *tt | 06/12/2000 | |
7670 | 11/01/1999 | 610872 | Information regarding november rotunda promotion - anglemaster ii driveline inclinometer, rotunda item number 164-r2402, used to diagnose vehicle noise, vibration and harshness problems. *tt | 05/16/2000 | |
6687 | 07/01/1999 | 610730 | Some obdii vehicles may exhibit a key on engine off self test diagnostic trouble code of p0605 (pcm rom test error). *tt | 05/11/2000 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||||
002404 | 11/01/2000 | 616583 | Some vehicles, equipped with 4r100 transmission, built prior to 2/6/2000 may benefit from additional cooling during heavy duty use conditions (i.e., snow plowing, towing, carrying heavy loads). a revised transmission fluid filter / cooli | 03/06/2001 | |
002310 | 11/01/2000 | 616577 | Concerns with contamination from prior transmission concerns may be trapped in the transmission fluid cooling system. *tt | 03/06/2001 | |
002310 | 11/13/2000 | 616522 | Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt | 03/05/2001 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||||
15474 | 12/01/2001 | 630556 | Information on noise from manual shift transfer case when shifting to 4low. *tt | 04/18/2002 | |
BC1010797020 | 01/02/1997 | 51171 | Procedure to purge potential water cotamination from transfer case. *jd | 06/27/1997 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - PARK/NEUTRAL START SWITCH | |||||
BC1034797020 | 02/01/1997 | 51818 | Check ride control warning may intermittently be displayed accompanied by codes 1873 and/or 1877. *jd | 07/17/1997 | |
BC8936950503 | 05/01/1995 | 41000 | Inoperative transmission interlock. *tw | 11/01/1995 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER | |||||
011105 | 05/01/2001 | 620264 | Some vehicles may exhibit a fluid leak in the converter housing area. this may be caused by an internal issue with the fluid vent assembly. *tt | 07/23/2001 | |
BC9027950906 | 09/01/1995 | 45778 | Vibration/shudder at steady cruise (45-55 mph) due to torque converter friction disc slipping/chattering. *tw | 04/25/1996 | |
BC8901950401 | 04/01/1995 | 3010000 | Unknown | 11/01/1995 | |
BC8901950401 | 04/01/1995 | 39873 | Torque converter clutch shudder or vibration. *tw | 11/01/1995 | |
POWER TRAIN - AXLE ASSEMBLY | |||||
020204 | 01/01/2002 | 630171 | Exhibiting harsh and delayed 1-2/3-4 upshifts after transaxle or turbine shaft speed sensor (tss) replacement. *tt | 04/15/2002 | |
011104 | 05/01/2001 | 620263 | Some 4x4 vehicles may exhibit a high-pitched squeal or whistle type noise from the front of the vehicle at speeds from 16 to 64 km/h (10 to 40 mph). this noise may be caused by the front halfshaft excluder (dust) seals (-3k070-) as they r | 07/23/2001 | |
011008 | 05/01/2001 | 620257 | Experiencing a whining noise from the rear on some vehicles during coastdown from 97 to 56 km/h (60 to 35 mph). this noise will disappear when the vehicle slows down below 56 km/h (35 mph). this may be caused by variation in tooth conta | 07/23/2001 | |
010507 | 03/01/2001 | 619498 | Some vehicles may exhibit a gear whine noise from the front under light acceleration while driving between 40 km/h (25 mph) and 113 km/h (70 mph). *tt | 06/01/2001 | |
010806 | 04/01/2001 | 619349 | Concerns with front axle leaking fluid from vent tube on vehicles equipped with 4x4 or awd. *tt | 05/23/2001 | |
14551 | 01/01/2001 | 617858 | Subject regarding added information to tsb 00-23-01 (whining from rear axle on coastdown from 97-56 km/h (60-35 mph). *tt | 04/02/2001 | |
13517 | 11/01/1999 | 614641 | Technicians requiring assistance with driveline or axle vibration and related noise concerns should obtain electronic vibration analyzer (eva) readings, driveline angle and runout measurements before contacting the technical service hotline | 11/29/2000 | |
POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT | |||||
BC4134950301 | 03/01/1995 | 39205 | Front axle bearing hum. *tw | 03/30/1995 | |
POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT - SEAL | |||||
010707 | 04/01/2001 | 619342 | Some 4x4 equipped vehicles may exhibit a rear axle pinion seal leak at the rotary blade coupling (rbc). *tt | 05/23/2001 | |
POWER TRAIN - AXLE ASSEMBLY - BANJO HOUSING | |||||
010903 | 05/01/2001 | 620245 | Some 4x2 vehicles with 4r70w transmission and 139 inch wheelbase may exhibit fluid leak from extension housing seal. *tt | 07/23/2001 | |
002402 | 11/01/2000 | 616581 | Concerns with vibration at high speeds which may cause the transmission extension housing seal to leak or the transmission extension housing bushing to move out of position or become damaged on some vehicles. *tt | 03/06/2001 | |
13522 | 11/01/1999 | 610910 | Supplemental information to used when performing tsb 991801 (maximum speed recalibration, driveline vibration and / or transmission fluid leak at the extension housing). *tt | 05/18/2000 | |
POWER TRAIN - AXLE HUBS | |||||
12-2-5 | 02/10/2012 | 10044118 | Ford: some vehicles exhibit a 4x4 not engaging, not staying engaged and/or unlocking in extreme cold temperatures below -18 degrees celsius or 0 degrees fahrenheit. include ford model f250, f350,f450, and f550 model years 2011-2012. *js | 05/14/2012 | |
000806 | 04/01/2000 | 613737 | Front locking hubs - service tip. **mr | 07/28/2000 | |
POWER TRAIN - CLUTCH ASSEMBLY | |||||
020505 | 03/01/2002 | 636420 | Service information on hotting, eeking or moaning noise emitted from the clutch when shifting into gears while the engine is running. *tt | 11/08/2002 | |
12849 | 06/01/1999 | 6092012 | Customer may comment about a hash / whining noise at idle that disappears when the clutch is fully depressed. *tt | 11/17/2000 | |
12927 | 07/01/1999 | 610748 | Some customers may have an issue with a hash / whining noise at idle that disappears when the clutch is fully depressed or reduces when the gearbox temp rises. *tt | 05/12/2000 | |
BC1009497020 | 01/02/1997 | 51145 | When replacing service p/n f6xz-7a360-aa (forward clutch cylinder) in a 4f20e transmission, you must also install the f6xz-7h198-aa (residual check ball) into the forward clutch cylinder. *jd | 06/27/1997 | |
POWER TRAIN - CLUTCH ASSEMBLY - PEDAL/LINKAGE | |||||
020601 | 03/01/2002 | 636425 | Concerns with clutch pedal going to floor, when not fully disengaged. *tt | 11/08/2002 | |
012401 | 11/01/2001 | 630492 | Concerns with clutch pedal staying on floor, not disengaging, fluid leaking from hydraulic clutch line. *tt | 04/17/2002 | |
011404 | 07/01/2001 | 621137 | Concerns with clutch pedal that when pressed to the floor, may not return or release the clutch. *tt | 09/07/2001 | |
010509 | 03/01/2001 | 619500 | Exhibiting a clutch pedal that when pressed to the floor, may not return or release clutch. *tt | 06/01/2001 | |
002401 | 11/01/2000 | 616580 | Concerns with vehicles exhibiting a vibration that may be heard or felt at the clutch pedal between idle and 2300 rpm, and goes away when depressing the clutch. *tt | 03/06/2001 | |
BC1024597230 | 01/23/1997 | 51615 | Clutch may be hard to depress and/or the clutch slave may require frequent replacement on some vehicles. *jd | 06/27/1997 | |
POWER TRAIN - DRIVELINE | |||||
7541 | 11/01/1999 | 610867 | Information stating that technicians requiring assistance with driveline or axle vibration and related noise concerns should obtain electronic vibration analyzer (eva) readings, driveline angle and runout measurements before contacting the | 05/16/2000 | |
BC1031897020 | 02/01/1997 | 51776 | Clinking noise in some cd4e transaxles may be caused by the differential lube tube contacting the differential case. *jd | 07/17/1997 | |
BC1029197020 | 02/01/1997 | 51738 | A driveline clunking or grunting noise may be heard on some vehicles during acceleration or stopping. *jd | 07/17/1997 | |
BC4243950503 | 05/01/1995 | 40092 | Clutch system squeak when stroking the pedal. *tw | 11/01/1995 | |
POWER TRAIN - DRIVELINE - DRIVESHAFT | |||||
021009 | 05/01/2002 | 637872 | This bulletin states a driveshaft thump or bump sensation may be felt immediately on acceleration from a stop or upon braking when coming to a complete stop on some vehicles. *tt | 12/06/2002 | |
010906 | 05/01/2001 | 620248 | Some 4x4 super cab vehicles may exhibit a low frequency thump type noise / vibration on light acceleration from a stop, and / or when coming to a stop with light to moderate braking. *tt | 07/23/2001 | |
POWER TRAIN - MANUAL TRANSMISSION | |||||
012305 | 11/01/2001 | 630490 | Concerns with t45 manual transmission stuck in reverse, difficult to shift into reverse, pops out of reverse. *tt | 04/17/2002 | |
011601 | 08/01/2001 | 625024 | Some vehicles equipped with the 4.6l engine and 5 speed maual transmission may exhibit a slight hesitation on light tip-in and a check engine light with diagnostic trouble codes. *et | 11/16/2001 | |
15177 | 08/01/2001 | 624559 | Information regarding 4r100 intermediate one-way installation. *yd | 11/07/2001 | |
011402 | 07/01/2001 | 621135 | Some vehicles, built prior to 8/1/2001, may exhibit a whine or howl noise during cold starts at temperatures below 4c (40f). *tt | 09/07/2001 | |
010706 | 04/01/2001 | 619339 | Information on correct 5r55w transmission fluid checking procedure. *tt | 05/23/2001 | |
13410 | 10/01/1999 | 614614 | Subject regarding fqr remanufactured transmissions with inline filters. *tt | 11/28/2000 | |
14199 | 06/01/2000 | 613896 | Some vehicles equipped with e40d/4r100 transmission may exhibit an engine stall when the transmission is placed into gear. *tt | 09/20/2000 | |
BC1015897020 | 01/02/1997 | 51225 | Stop updating the processor to the r-12 calibration. this update may cause the vehicle to stall on cold engagement. *jd | 06/27/1997 | |
BC1020997230 | 01/23/1997 | 51569 | As of 1/7/97 the automatic shift lock feature tag that was affixed around the gear selector, has been discontinued for production. *jd | 06/27/1997 | |
BC0023961101 | 11/01/1996 | 50806 | Pops out of 3rd or 5th gear concerns on manual transmission may be caused by powertrain mis-alignment. *tw | 06/17/1997 | |
BC4405950906 | 09/01/1995 | 45776 | Vehicles may exhibit a rattle noise or vibration through the shifter in fifth gear due to high lateral runout of the fifth gear. *tw | 04/25/1996 | |
BC8767941201 | 12/01/1994 | 37796 | Vehicles may experience stiff shift lever movement/high shift effort in all gears. *tw | 01/10/1995 | |
POWER TRAIN - MANUAL TRANSMISSION - LUBRICANT | |||||
983214 | 02/01/1998 | 607429 | Please reverse dtc chart for dtc p1309 found on pgs 4-13 in 1998 pc manual. | 12/21/2000 | |
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
011401 | 07/01/2001 | 621131 | Some vehicles may exhibit inadvertent 4x4 high or low shift events, 4x4 and / or low range indicator flashing or solid or vehicle stuck in 4l after uncommanded shift. *tt | 09/07/2001 | |
7495 | 11/01/1999 | 610854 | Some control trac equipped vehicles in 4 auto mode may exhibit a shudder or acceleration and / or more noise from the front driveline and transfer case while driving. *tt | 05/16/2000 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
POWER TRAIN | ||||||
DP79026 | FORD MOTOR COMPANY | 01/15/1979 | 03/19/1979 | TRANSMISSIONS JUMP FROM PARK TO REVERSE | ||
Transmissions jump from park to reverse | ||||||
DP81020 | FORD MOTOR COMPANY | 06/22/1981 | 10/17/1981 | TRANSMISSIONS | ||
Transmissions | ||||||
DP82007 | FORD MOTOR COMPANY | 02/18/1982 | 06/18/1982 | REOPEN FORD TRANSMISSION CASE C8-02 | ||
Reopen ford transmission case c8-02 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
POWER TRAIN | |||
12/03/2012 | 1 | ||
Letter from congressman regarding constituent re complaints about 2005/6/7 ford motor vehicles cvt transmission (dot/i#: h-2012 274). *kb the consumer stated the transmission failed on his vehicle. | |||
1 | |||
Speedometer failed, causing noise. | |||
POWER TRAIN - AUTOMATIC TRANSMISSION | |||
08/25/1997 | 1 | ||
Excessive banging in transmission from park to drive gear, repaired under recall. (97s75) | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER | |||
09/01/2012 | 1 | ||
Consumer writes in regards to defective parts for a van. recall# 12v006000. *tgw | |||
POWER TRAIN - MANUAL TRANSMISSION | |||
07/01/1997 | |||
Recall #97s75, dealer waiting on part. | |||
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||
08/07/2004 | 1 | ||
The transfer case leaked. *nm *jb |