Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - IGNITION | ||||||||||||||||
| 96V071000 | FORD MOTOR COMPANY | from 08/01/1987 to 09/30/1992 | V (Vehicle) | 7900000 | 06/07/1996 | ODI | FORD MOTOR COMPANY | 04/25/1996 | 05/01/1996 | |||||||
| Defect Summary | The ignition switch could experience an internal short circuit. | |||||||||||||||
| Consequence Summary | This condition could cause overheating, smoke, and possibly fire in the steering column area of the vehicle. | |||||||||||||||
| Corrective Summary | Dealers will replace the ignition switch. | |||||||||||||||
| Notes | System: electrical; ignition switch. vehicle description: passenger and multi-purpose vehicles and light duty trucks. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - WIRING | |||||
| 99222 | 10/18/1999 | 6089681 | Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt | 02/11/2000 | |
| 96246 | 11/18/1996 | 50905 | Wiring - electrical diode identification and service replacements. *tw | 06/17/1997 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 08/08/2002 | |||
| When pressure is applied on steering wheel it causes electrical system and vehicle to shutdown while driving. dealer and manufacturer have not been notified at this time. feel free to provide any further information.*ak | |||
| 07/04/1996 | 1 | ||
| Electrical fire. | |||
| ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||
| 09/01/1993 | 3 | 05/01/1993 | |
| Fuel pump safety switch would engage on its own & car wouldn't start unless you hit the switch. alternator has been replaced 3 times and so has battery. | |||
| 10/04/1994 | 1 | 06/02/1998 | |
| Approximately 5 minutes after parking fire started under hood. during extinguish noticed sparking at alternator wire hookups. | |||
| 08/30/1997 | 1 | 02/01/1989 | |
| Alternator fire. | |||
| ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | |||
| 01/13/1999 | 16 | 09/01/1993 | |
| The fuse box caught on fire when consumer accidentally dropped a penny into the cigarette light. consumer feels the fuse should have blown to prevent the fire from occuring. nlm | |||
| 03/01/1996 | |||
| Due to a short circuit headlamp wiring there is a malfunction in the headlights and fog lights, causing the headlights to flash on a off. there is a tsb put out for that problem tsb number 8917-11. *ak | |||
| ELECTRICAL SYSTEM - IGNITION | |||
| 03/25/2008 | 123000 | 1 | 09/14/1988 |
| Tl*the contact owns a 1989 ford mustang. whenever the key is inserted into the ignition to start the engine, the vehicle will not start on the first attempt. the contact must remove the key from the ignition and retry in order for the vehicle to start. he discovered nhtsa campaign id number 96v071000 (electrical system:ignition); however, the dealer stated that his vin was not included in the recall. the failure mileage was 123,000 and current mileage was 125,000. updated 6/16/08 *cn the starter and relay were replaced. | |||
| 03/07/2003 | 1 | ||
| The vehicle experienced the same problem as stated in recall #96 v 071 000, however the vehicle identification number was not included in the recall.*jb | |||
| 08/08/2002 | |||
| When pressure is applied on steering wheel it causes electrical system and vehicle to shutdown while driving. dealer and manufacturer have not been notified at this time. feel free to provide any further information.*ak | |||
| 09/01/1995 | |||
| Under hot conditions ignition sparks and clicks. dealer has replaced switch three times, and problem is still occurring. please provide any further information.*ak | |||
| 09/01/1995 | 1 | ||
| Consumer states under hot weather conditions the vehicles ignition will spark and click. consumer has replaced switch 3 times. please provide any further information.*jb | |||
| 01/30/2002 | 1 | 06/01/1989 | |
| Received recall notice 96v071000. contacted dealership and took vehicle on appointed date. after picking up vehicle, noticed ignition acted same as before going to dealer. owner took ignition apart and contacted manufacturer for part number of replacement. part was never replaced by dealership.*ak *tt | |||
| While traveling and without any indication vehicle stalled. dealer has been notified . please provide further information.*ak | |||
| 08/01/1999 | 6 | 05/01/1995 | |
| I have recently contacted ford about this problem and i was told that there was no problem. my friend has a 1988 mustang, who has had the same problem numerous times. i am an electrical engineer and know that this problem is the result of a bad design (i.e. the ignition control module gets too hot, which causes the transistors to function improperly). this is a real problem and i hope it doesn't take many lives to figure this out. thank you, josh shaw | |||
| 10/11/2000 | 12 | 10/01/1988 | |
| When slowing down to make left or right turns, the engine of the vehicle surges and cuts off with no warning resulting in the loss of power steering and brakes. problem most often occurs when the engine is hot and the air conditioning is on. | |||
| 01/31/1996 | 01/01/1995 | ||
| Car was parked in the parking lot at place of employment on 1/31/96. approximately 10 minutes later i was informed that the car was on fire in the parking lot. the fire completely consumed the engine compartment and interior dashboard area. the palm beach gardens fire department arrived to extinguish the fire, however the car was totaled due to the extensive damage. the fire department incident report indicated that the fire was caused by a faulty ignition relay. the car was removed by a towing service and delivered to a junk yard. a total of $100 was provided for the car for used parts. there was no insurance coverage for this incident. on sept. 1996, we received a safety recal notice from the ford motor co. stating that 1988-93 model mustangs could experience a short circut in the ignition switch leading to overheating and possibly fire. we have attempted several times to contact ford motor co. but have received no supporting responce. also, the dispute settlement board has been contacted, but indicated that our application does not fall within the jurisdiction of the board. we have a copy of the fire report and photos of the vehicle. please advise. | |||
| 04/26/1999 | 1 | 01/07/1999 | |
| Vehicle received recall repair work on the ignition system (96v-071) on april 21, 1999 on april 26, 1999 vehicle fire due to electrical failure. mjs | |||
| 06/21/1995 | 1 | ||
| Parked vehicle, turned ignition off and upon return vehicle caught on fire due to ignition wiring failure. *ak | |||
| ELECTRICAL SYSTEM - IGNITION - SWITCH | |||
| 07/31/2000 | |||
| Had received recall notice 96v071000 and contacted dealer. took vehicle for repairs of ignition switch. 4 years later, ignition switch had a short. dealer refused to repair, was not taking responsibility for problem. manufacturer agreed with dealer.*ak | |||
| 05/26/2000 | |||
| Recall 96v071000/electrical system ignition switch. vehicle had a broken ignition switch, and consumer believed that the recall was the reason for this problem. also, msnufacturer informed consumer that this vehicle was not covered under the recall due to vin. *ak | |||
| 07/04/1996 | 1 | ||
| Vehicle fire due to faulty ignition switch (electrical) prior to recall notice. | |||
| 07/04/1996 | 1 | ||
| Vehicle faulty ignition failed after recall repair causing it to catch on fire. | |||
| 1 | |||
| Ignition switch failure resulted in fire prior to recall notice. | |||
| 06/18/1995 | 1 | 01/01/1991 | |
| Vehicle fire due to ignition switch failure prior to recall notice. | |||
| 08/28/1997 | |||
| Consumer received recall for ignition switch, states that dealer will replace switch with new one. dealer did not, therefore 10 months later vehicle caught on fire due to this.*ak | |||
| 06/18/1995 | 1 | ||
| Ignition switch fire. | |||
| 12/20/1989 | |||
| The vehicle caught on fire in the ignition switch. vehicle had a recall for the ignition switch. *ak | |||
| 07/04/1996 | 1 | 02/16/1995 | |
| Ignition switch fire after recall repair. | |||
| The electrical ignition switch was sticking, had it replaced, the car started overheating after replacing the switch , the recall letter was send out . please describe.*ak | |||
| 05/01/1996 | 1 | ||
| Ignition switch fire prior to recall. *sd | |||
| 09/23/1994 | |||
| Electrical short or shock in ignition switch, causing the vehicle to catch on fire. *ak | |||
| 04/19/1996 | |||
| Engine compartment fire while driving vehicle, unknown source of fire. *ak | |||
| 04/19/1995 | |||
| Pulled key out of ignition vehicle continued to run. after repair smoke came from steering column. *ak | |||
| 04/12/1994 | 2 | ||
| Electrical fire, caused by a short or ground in the ignition switch. *skd | |||
| ELECTRICAL SYSTEM - STARTER ASSEMBLY | |||
| 03/25/2008 | 123000 | 1 | 09/14/1988 |
| Tl*the contact owns a 1989 ford mustang. whenever the key is inserted into the ignition to start the engine, the vehicle will not start on the first attempt. the contact must remove the key from the ignition and retry in order for the vehicle to start. he discovered nhtsa campaign id number 96v071000 (electrical system:ignition); however, the dealer stated that his vin was not included in the recall. the failure mileage was 123,000 and current mileage was 125,000. updated 6/16/08 *cn the starter and relay were replaced. | |||
| ELECTRICAL SYSTEM - WIRING | |||
| 05/05/2000 | 1 | 05/01/1989 | |
| A fire starting in the engine compartment due to a defective wiring harness and alternator without any warning. *ak *ml | |||
| 01/17/1996 | 1 | 02/13/1995 | |
| Wiring harness fire after recall repair. | |||
| 03/05/1997 | |||
| While driving an electrical short in the wiring, caused the vehicle to catch on fire. *ak | |||
| 5 months after recall campaign 96v071000 was done, wiring harness within steering column which controls high beams/ flashers and windshield wipers burned, rendering wiring harnessinoperative as result of short circuit. *ak | |||
| While parked, wires in the steering column caught on fire. please describe. *ak | |||
| 10/08/1994 | 1 | ||
| Ignition switch wiring shorted out, resulting in a fire. *ak | |||
| 02/01/1994 | |||
| When lights or heater are on high will damage battery. tt | |||
| ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
| While driving vehicle there was smoke coming from hood.owner pulled over and fire started, causing vehicle to burn up completely. *ak | |||
| 01/17/1997 | 02/13/1995 | ||
| Vehicles caught on fire while parked due to a short in the electrical system in the area of the underhood. *ak | |||
| Parked car and a fire broke out, fire originated from under the hood . *ak | |||
| ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
| 07/27/1990 | 7 | ||
| Faulty wiring from factory drains battery, also causes failure of battery/alternatotor. *dh | |||
| 04/08/1996 | |||
| There was a fire in the vehicle around the steering column area. please describe. *ak | |||
| 06/23/1995 | 1 | ||
| Electrical fire started under dash and steering column. *ak | |||