Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| 98246 | 12/07/1998 | 604059 | Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc | 03/16/1999 | |
| ELECTRICAL SYSTEM - WIRING | |||||
| 99222 | 10/18/1999 | 6089681 | Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt | 02/11/2000 | |
| 96246 | 11/18/1996 | 50905 | Wiring - electrical diode identification and service replacements. *tw | 06/17/1997 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||
| EA88033 | FORD MOTOR COMPANY | 05/11/1988 | 01/23/1989 | UNDER SEAT FIRES | 88V145000 | |
| There is no summary currently available | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 04/15/1998 | |||
| Truck was bought used and dealer maintained, it sat parked for 3 days without being touched due to son being in a pica cast from chest to feet, at approximately 2 am the locked truck honked and woke me up, when i went outside i could see flames in the passenger seat so got kids out of the house as there was gas line close and called the fire department which was unable to save the vehicle, as soon as the door opened it exploded into a big white ball not even the tires were any good. fire department said it was the computer that shorted out and caught it on fire. contacted dealer and was told there were no complaints of this happening before with the computers but they would notate it. location of occurance and was rupert,idaho and reported to ford dealer in burley,id | |||
| 04/03/2005 | 08/30/2004 | ||
| I had just left a red light. i was the 1st vechicle inthe north lane on a two lane street. the south bound side had about 8 cars . the last car hit a car in front of him, she hit a jeep in front of her, and impact caused her to swearve into the northbound side where i hit her in in the front passenger side. i had my grandson 9 in the front with me. my granddaughter 16 and her friend 15 were in the truck bed. i just had a small indention in the front of my truck. this truck was a 1987 long bed. runs good. it i thought was steaming maybe i busted my radiator. my concern was the children. then it started smoking. a fire extinquisher was used. a little while later it caught and burned up. | |||
| 12/14/1999 | 1 | ||
| Electrical computer short out was the possible cause of vehicle fire. *mjs | |||
| ELECTRICAL SYSTEM - IGNITION | |||
| 08/21/1992 | 3 | 12/01/1986 | |
| I'v had to replace the ignition module 3 times since the first date of the first time of breaking down.*ak | |||
| 6 | 07/01/1999 | ||
| No summary | |||
| 06/27/1996 | 1 | ||
| Vehicle stalled and then caught on fire in the engine compartment. *ak consumer states no vehicle caught fire, then stalled in a matter of 30 seconds, the cab of trucj was on fire and consumer barely had enough time to pull to the side of the road, to get out of traffic, get her purse and get out of truck and get 10 feet away consumer states the fuel clip was never replaced.*jb | |||
| When vehicle is started there is a burnt smell, while driving, console shuts down. *ak | |||
| 04/10/1996 | |||
| Ignition switch wiring harness fire. *ak | |||
| ELECTRICAL SYSTEM - IGNITION - SWITCH | |||
| While backing out of driveway smoke appeared from dash column. vehicle then caught fire do to a faulty ignition switch. vehicle was a total loss. *ak | |||
| 06/01/1995 | 1 | ||
| Ignition switch shorted, causing fire. *dsh | |||
| 05/03/1996 | |||
| After parked and restarted ten minutes, truck caught on fire. please describe details. *ak | |||
| Ignition switch sticks, won't allow key to turn vehicle off, also experiences problem in starting. *ak | |||
| ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
| 08/23/2001 | |||
| Vehicle was parked/ idling when it suddenly caught on fire in engine compartment. please provide any further details.*ak | |||
| 04/09/1996 | |||
| Started vehicle, drove a quarter of block smoke started coming from underneath the hood. vehicle burst into flames and shot up nine feet. *ak | |||