Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
99152 | 07/26/1999 | 608431 | Information on the new flush and fill tool available through rotunda. *tt | 01/05/2001 | |
0015 | 01/10/2000 | 612203 | Information regarding the new transmission cooler flusher- service tip. *mjs | 06/06/2000 | |
98112 | 01/19/1998 | 605573 | Subject regarding a new service center support that uses a thrust bearing (#3 and #4) in place of thrust washers has been released. *tt | 07/12/1999 | |
9888 | 04/27/1998 | 601238 | Information on a new transmission fluid usage chart. *yc | 07/10/1998 | |
97511 | 03/03/1997 | 51945 | Fluid- transmission fluid usage charts. *jd | 07/17/1997 | |
BC1350950906 | 09/01/1995 | 45756 | High altitude transmission available. *tw | 04/25/1996 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||||
03148 | 07/21/2003 | 10003748 | New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt | 10/29/2003 | |
002310 | 11/13/2000 | 616522 | Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt | 03/05/2001 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER | |||||
96249 | 11/18/1996 | 50908 | Torque converter - leak test procedure - service tip. *tw | 06/17/1997 | |
962612 | 12/16/1996 | 50997 | Transaxle - torque converter replacement guidelines and torque converter/transaxle cooling system cleaning procedures - service tip. *tw | 06/17/1997 | |
POWER TRAIN - AXLE ASSEMBLY | |||||
983074 | 02/27/1998 | 607369 | Concerns with axle wind-up and / or clunking, popping, ratcheting type noises when making cornering maneuvers. *tt | 09/21/1999 | |
12905 | 06/01/1999 | 606937 | Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt | 09/08/1999 | |
BC0131960102 | 12/01/1995 | 46438 | 4x4 front axles must use hypoid 4x4 gear oil p/n f1tz-19580-a & high temp 4x4 front axle & wheel bearing grease when servicing. it is not recommended to use heavier weight lubes in these front axles. | 04/25/1996 | |
POWER TRAIN - DRIVELINE | |||||
6603 | 07/01/1999 | 610704 | Some vehicles may exhibit an audible pinging or creaking noise that may be heard from the driveline when engine torque is initially applied to the driveline. *tt | 05/11/2000 | |
971110972312 | 11/10/1997 | 53668 | Concerns with pinging or creaking being heard from the driveline when shifting from park to drive or reverse, between drive and reverse, or when engaging the clutch. *yc | 03/30/1998 | |
962417 | 11/18/1996 | 50915 | Noise - pinging or creaking from driveline when vehicle is put into gear. *tw | 06/17/1997 | |
POWER TRAIN - MANUAL TRANSMISSION | |||||
7366 | 11/01/1999 | 610793 | Some vehicles equipped with manual transmission may exhibit neutral gear rollover noise (a light metallic rattling sound from the transmission) which occurs at idle with transmission in neutral clutch engaged (clutch pedal up). *tt | 05/15/2000 | |
13423 | 10/01/1999 | 609688 | Vehicles equipped with manual transmission may exhibit neutral gear rollover noise which occurs at idle with transmission in neutral and clutch engaged. *tt | 04/06/2000 | |
BC0678961025 | 10/25/1996 | 50356 | Information on aode/4r7w transmission main control & case replacement. *tt | 04/24/1997 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||
08/15/1999 | |||
Transmission plastic funnel bearing snapped, causing the transmission to lock up manufacturer has been notified. *ak | |||
1 | 01/15/1992 | ||
Transmission does not provide compression braking in any gear, including reverse; vehicle freewheels as though it were in neutral; also, will not shift into any lower gear manually regardless of speed/gear position. *ak | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||
01/09/1996 | 1 | ||
Motor in four wheel drive would not activate during inclimate weather. explain in more detail. tt | |||
POWER TRAIN - CLUTCH ASSEMBLY | |||
11/06/1997 | 1 | ||
Main shaft went through transmission causing extensive damage to transmission. | |||
POWER TRAIN - CLUTCH ASSEMBLY - PEDAL/LINKAGE | |||
01/01/1994 | 2 | 08/14/1992 | |
Clutch throw-out bearing/hydraulic sleeve/pressure plate failed. | |||
POWER TRAIN - DRIVELINE - CONSTANT VELOCITY JOINT | |||
12/24/1996 | 8 | 01/01/1992 | |
Universal joint: constant velocity failure; also engine valve cover/water pump leaks. *ak | |||
POWER TRAIN - MANUAL TRANSMISSION | |||
02/01/1999 | 01/01/1993 | ||
The problem with getting the truck to go into gear happens off and on. it is getting worse. ignition is to a point that i must jump start it. i am disable to the point of pushing the truck in order to start it. | |||
12/01/1999 | 03/01/1996 | ||
Transmission manual failed output shaft at 20 mph replaced internal gears gave out at 65 mph.//abs brakes became spongy & lock in rear pull to right in front .//headlights began blinking off &on after 15 minutes of driving.//transfer case split while in 2 wheel drive at 35 mph.//front suspension giving out can't align front end ,eratic steering & worn tires.//rear springs slipped out on left side axle slid forward to body.//heater began rattliing ,more as you turn fan up. | |||
05/22/1998 | 1 | 01/01/1992 | |
Manual transmission failed causing gear to stick. | |||
11/06/1996 | 1 | 07/01/1992 | |
Five speed manual transmission locked up due to bad seals where shifting rods go through, owner pulled over immediately and was informed that this is a common problem. mechanic said heat expansion causes them to leak only in motion. *ak *slc | |||
Purchased truck new the standard transmission is leaking fluid from clutch. please describe . *ak | |||
5-spd manual transmission failed losing power not responding to shifting of gears. please describe details. tt | |||
12/23/1994 | 1 | ||
Transmission jumped out of gear twice (other vehicle on 479214). *ak | |||
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||
12/01/1999 | 03/01/1996 | ||
Transmission manual failed output shaft at 20 mph replaced internal gears gave out at 65 mph.//abs brakes became spongy & lock in rear pull to right in front .//headlights began blinking off &on after 15 minutes of driving.//transfer case split while in 2 wheel drive at 35 mph.//front suspension giving out can't align front end ,eratic steering & worn tires.//rear springs slipped out on left side axle slid forward to body.//heater began rattliing ,more as you turn fan up. |